Volvo Penta D3 Operator's Manual page 92

Maintenance
1
P0003060
90
Water in Fuel
If the EVC system warns for too much water in the fuel
filter, the water separator needs emptying.
IMPORTANT!
Do not continue operating if there is water in the water
separator, it can damage the engine.
Draining the fuel filter
1 Stop the engine and remove the ignition key from
the ignition lock.
2 Remove the connector piece (1) from the sensor
(2).
3 Place a container under the fuel filter and carefully
unscrew the sensor (2). Let the water run out. When
diesel runs out, screw in the water separator until it
bottoms against the filter. Then tighten an addi-
tional 1/4 to 1/2 turn.
4 Refit the connecting piece (1).
Draining the fuel pre-filter (extra
equipment)
1 Place a container beneath the fuel filter.
2 Open the bleed screw (1) on the fuel filter about 4
turns.
3 Drain the water and contaminants via the plug in the
bottom of the filter.
4 Bleed the fuel system.
47705992 05-2015 © AB VOLVO PENTA