Graco PR70 Manual page 51

Accumulators
Pneumatic Accumulator Assembly
1 01/1449/99 COVER,BACK,MINI,ACCUM,MS
2 84/1460-5/11 LEGEND,START,STOP,TRANS PUMP
3 01/1448/99 COVER,FRONT,MINI ACCUM,MS
4 96/0282/98 SCREW,BHCS,8-32X0.38,MS,E@@@
5 84/1460-1/11 LEGEND,ACCUMULATOR,AIR PRESS
6 84/1460-2/11 LEGEND,HIGH LIMIT
7 96/0360/99 SCREW,SHC,4-40X0.25,MS,E@@@
8 96/0270-1/11 KNOB,KNURLED,6-32X0.38,M
9 96/0161/99 WASHER,FLAT,#6,SS,1/2OD,0.06THIC
K
10 01/2264/97 POINTER,SW,PROX,PRMV/F
11 84/0067/86 DECAL,SCALE,1" TO 6",PR
12 94/0070/96 NIPPLE,1/8NPTX1.50,BRS
13 94/0525/96 NIPPLE,HEX,1/8NPT,BRS
14 01/1457/97 BLOCK,MANIFOLD,1/8PORT>
15 94/0642/96 ELBOW,1/8NPT,F,90DEG,BRS
16 94/0809/96 VALVE,BALL,2W,1/8NPT,M,LP,BRS
17 96/0876/99 SCREW,BHCS,8-32X0.50,MS
18 96/0176/99 NUT,HEX,8-32,MS
19 84/1460-3/11 LEGEND,LOW LIMIT
20 84/1460-4/11 LEGEND,AIR IN/OUT
21 01/1456/97 CAP,END,CYLINDER,ACCUM,1.5
22 01/1455/98 CYLINDER,ACCUM,1.5,SS
23 95/0605/01 U-CUP,1/2IDX3/4OD,NIT
24 01/1451/98 TUBE,VENT,ACCUM,1.5,SS
25 01/1453/99 ROD,TIE,ACCU,1.5
26 96/0010/99 NUT,HEX,10-24,MS
27 96/0611-08/98 NUT,JAM,1/2-20,SS
28 96/0556-08/99 WASHER,SEALING,1/2,MS
29 01/1450/70 PISTON,1-
1/2",ACCUM,SEAL/MAG,DEL
30 01/1454/98 FLANGE,PUMP,ACCUM,1.5,SS
*Items 36, 37, 38 and 45 Depend on which configuration is being run. Descriptions ending in VIT are for
configurations using VITON and Descriptions ending in EP are for configuration using EPDM.
P/N LC0133 RUNS VITON SEALS
P/N LC0134 RUNS EP SEALS
IT IS RECOMMENDED THAT ALL SEALS SHOULD BE REPLACED AT THE SAME TIME, SO THE
HIGHLIGHTED PARTS CAN BE ORDERED AS PART OF SEAL KITS:
- LC0154 FOR VITON
- LC0155 FOR EP
All fittings and hose are called out on the following page with the logic diagram
312394B
31 94/0545/98 PLUG,SKT HD,1/8NPT,18-8SS
32 121307 NIPPLE,1/2NPTX3.00,304SST
33 94/0616/98 TEE,1/2NPT,F,150PSI,304SS
34 94/0348/11 CAP,VALVE,CHECK,1/2
35 82/0047/11 PUSHBUTTON,5/8 DIA HEAD,1/8 DIA ROD
*36 95/0913/00 O-RING,VIT,JBH,>
95/0913/02 O-RING,EP,JBH,>
*37 95/0601/00 U-CUP,1-3/16IDX1-1/2OD,VIT
95/0601/02 U-CUP,1-3/16IDX1-1/2OD,EP
*38 94/0360-2/98 VALVE,CHECK,1/2NPT,M,VIT,SS,ADJ,50-150PS
94/0360-3/98 VALVE,CHECK,1/2NPT,M,EP,SS,ADJ,50-150PS
39 96/0726/99 SCREW,SHC,4-40X0.75,MS,E@@@
40 82/0263-A/11 ACTUATOR,LEVER,ROLLER
41 01/1452/11 STRIP,PISTON,MAGNETIC
42 01/2259-O1/70 MOUNT,PROX SW,ODV,PRMV/F,7/16WIDE
43 01/2259-R1/70 MOUNT,PROX SW,RET,PRMV/F,7/16WIDE
44 15M849 ADAPTER,ACCUMLATOR
*45 95/0223/00 O-RING,VIT,BBC
95/0223/02 O-RING,EP,BBC
46 94/3201/96 UNION,BULKHEAD,1/4TUBE
47 94/0786/96 TEE,1/4TUBE,PRESTOLOCK,BRS
48 94/0667/96 REDUCER,1/4TUBEX5/32TUBE,PRESTOLOCK
50 94/0740-A/99 ELBOW,SWVL,1/4TUBEX10-32,FXM,90DEG
56 94/0463/96 BUSHING,1/8NPTX10-32,BRS
57 82/0171/11 ELBOW,STREET,10-32,ADJ,BRS
58 94/0102/96 CONNECTOR,1/4TUBEX10-32,BRS
66 SX10/320/011 VALVE,3W,SR,NC,MANUAL ACTUATION>
67 G0100088 BODY,VALVE,3W,PBSR,NC,10-32,F
69 82/0053/11 GAUGE,PRESS,0-30PSI,2",1/8NPT,BACK
70 82/0241/11 VALVE,QCK EXH,10-32,MINI
71 82/0052/11 REGULATOR,AIR,1/8NPT,3-30PSIG,10SCFM>
72 82/0395/11 VALVE,PWR,4W,DP,10-32,SIDE PORT
74 120904 SCREW,SHCS,M5X0.8X18MM,SST
51 of 71