Replacing Batteries - Invacare TDX Series Owner's Manual

All manuals and user guides at all-guides.com
BATTERIES

REPLACING BATTERIES

GROUP 24 BATTERIES GROUP 24 BATTERIES GROUP 24 BATTERIES
GROUP 24 BATTERIES GROUP 24 BATTERIES
Rear Battery with Battery Connector Bracket (FIGURE 6)
1. Remove the batteries from the chair. Refer to REMOVING/INSTALLING BATTER-
IES FROM/INTO WHEELCHAIR in this section of the manual.
2. Cut the tie-wraps that secure the battery terminal covers to the battery terminals.
Refer to Detail “A” in FIGURE 6.
3. Perform the following: (Detail “A” in FIGURE 6)
A. Slide the RED battery terminal cover back on the RED battery cable to expose
the positive battery terminal.
B. Slide the BLACK battery terminal cover back on the BLACK battery cable to
expose battery terminal.
NEVER allow any of your tools and/or battery cable(s) to contact BOTH
battery post(s) at the same time. An electrical short may occur and
serious personal injury or damage may occur.
4. Perform the following:
A. Remove the locknut that secures the bracket of the POSITIVE battery cable to
the POSITIVE (+) battery post of the REAR battery.
B. Remove the locknut that secures the NEGATIVE battery cable to the NEGA-
TIVE(-) battery post of the FRONT battery.
5. Discard the EXISTING battery.
NOTE: If there is battery acid in the bottom of the battery tray or on the sides of the battery(ies),
apply baking soda to these areas to neutralize the battery acid. Before installing the NEW or
existing battery(ies), clean the baking soda from the battery tray or battery(ies).
6. Position battery connector bracket onto the NEW GP24 battery as shown.
7. Perform the following:
A. Secure the NEGATIVE battery cable to the NEGATIVE(-) battery post of the
with existing mounting screw and locknut.
B. Secure the bracket of the POSITIVE battery cable to the POSITIVE (+) battery
post with existing mounting screw and locknut.
8. Position each battery terminal cover over top of each battery terminal.
9. Secure battery terminal covers in place with one tie-wrap.
10. Install batteries into wheelchair. Refer to REMOVING/INSTALLING BATTERIES
FROM/INTO WHEELCHAIR in this section of the manual.
Part No. 1114809
WARNING
57
SECTION 7
TDX WHEELCHAIRS