Spoke Wheels; Adjusting The Clutch Lever Free Play - Yamaha CRUX REV YD110-1 2016 Owner's Manual

Tires age, even if they have not been
used or have only been used occasion-
ally. Cracking of the tread and sidewall
rubber, sometimes accompanied by
carcass deformation, is an evidence of
ageing. Old and aged tires shall be
checked by tire specialists to ascertain
their suitability for further use.
WARNING
The front and rear tires should be of
the same make and design, other-
wise the handling characteristics of
the vehicle may be different, which
could lead to an accident.
After extensive tests, only the tires list-
ed below have been approved for this
model by Yamaha.
Front tire:
Size:
2.75-17 41P
Manufacturer/model:
TVS/ATT625
Rear tire:
Size:
3.00-17 50P
Manufacturer/model:
TVS/ATT925
Periodic maintenance and adjustment

Spoke wheels

To maximize the performance, durabil-
ity, and safe operation of your vehicle,
note the following points regarding the
specified wheels.
The wheel
checked for cracks, bends, warp-
age or other damage, and the
EWA10462
spokes for looseness or damage
before each ride. If any damage is
found, have a Yamaha dealer re-
place the wheel. Do not attempt
even the smallest repair to the
wheel. A deformed or cracked
wheel must be replaced.
The wheel should be balanced
whenever either the tire or wheel
has been changed or replaced. An
unbalanced wheel can result in
poor performance, adverse han-
dling characteristics, and a short-
ened tire life.
EAU49712
Adjusting the clutch lever free
play
1
rims should be
ZAUE2592
1. Clutch lever free play
The clutch lever free play should mea-
sure 10.0–15.0 mm (0.39–0.59 in) as
shown. Periodically check the clutch
lever free play and, if necessary, adjust
it as follows.
1. Loosen the locknut at crankcase
2. To increase the clutch lever free
7-18
side.
play, turn the adjusting nut in di-
rection (a). To decrease the clutch
lever free play, turn the adjusting
nut in direction (b).
EAU69930
7