Trane Voyager RT-SVX17C-EN Installation Operation & Maintenance page 39

Figure 13
VAV Test Modes
TEST MODE
STEP
1 IGV/VFD TEST
2 IGV/VFD TEST CLOSED/OFF
3 MINIMUM
VENTILATION
4 ECONOMIZER
5 COOL
STAGE 1
6 COOL
STAGE 2
7 COOL
STAGE 3
8 HEAT
STAGE 1
9 HEAT
STAGE 2
10 RESET
CV Test Modes (Also VAV w/o IGV)
TEST MODE
STEP
1 MINIMUM
VENTILATION
2 ECONOMIZER
TEST OPEN
3 COOL
STAGE 1
4 COOL
STAGE 2
5 COOL
STAGE 3
6 HEAT
STAGE 1
7 HEAT
STAGE 2
8 RESET
Notes:
1. The IGV/VFD will be controlled to the supply pressure setpoint unless test mode has been running for 6 minutes or
longer. After 6 minutes, the IGV damper will drive to the full open position/VFD will drive to 100% .
2. The supply fan will not be allowed to go from an off state to an on state until the IGV are fully closed.
3. The Heat outputs will not be allowed to come on until the IGV are at the full open position/VFD will drive to 100% .
4. The condenser fans will operate any time a compressor is ON providing the outdoor air temperatures are
within the operating values listed in Table 16.
5. For 27.5 thru 35 Ton units, cool stage 2 is not used and cool stage 3 becomes the active sequence.
6. The exhaust fan will turn on anytime the economizer damper position is equal to or greater than the exhaust
fan setpoint.
7. The VHR relay output will be energized at the start of the test mode to allow time for the boxes to open. It takes
6 minutes for the boxes to drive from the full closed position to the full open position. The timing cannot be
changed in the field.
IGV/VFD FAN
(Note 7)
OPEN/100% OFF
OFF
(Note 1) IN
CONTROL ON
(Note 1) IN
CONTROL ON
(Note 1) IN (Note 2)
CONTROL ON
(Note 1) IN (Note 2)
CONTROL ON
(Note 1) IN (Note 2)
CONTROL ON
(Note 1) (Note 2)
OPEN ON
(Note 1) (Note 2)
OPEN ON
FAN ECON
(Note 6)
MINIMUM
ON POSITION
ON OPEN
MINIMUM
ON POSITION
MINIMUM
ON POSITION
MINIMUM
ON POSITION
ON CLOSED
ON CLOSED
Unit Start-Up (Continued)
ECON COMP COMP
(Note 6) 1
CLOSED OFF
CLOSED OFF
MINIMUM
POSITION OFF
OPEN OFF
MINIMUM (Note 4)
POSITION ON
MINIMUM (Note 5) (Note 4,5)
POSITION OFF
MINIMUM (Note 4) (Note 4)
POSITION ON
CLOSED OFF
CLOSED OFF
COMP COMP
1 2
OFF OFF
OFF OFF
(Note 4)
ON OFF
(Note5) (Note 4,5)
OFF ON
(Note 4) (Note 4)
ON ON
OFF OFF
OFF OFF
39
HEAT HEAT
2 1 2
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
ON OFF OFF
ON OFF OFF
(Note 3)
OFF ON OFF
(Note 3) (Note 3)
OFF ON ON
HEAT HEAT OHMS
1 2
OFF OFF 4.7K
OFF OFF 6.8K
OFF OFF 10K
OFF OFF 15K
OFF OFF 22K
ON OFF 33K
ON ON 47K
OHMS
2.2K
3.3K
4.7K
6.8K
10K
15K
22K
33K
47K