Checking The Fuel; Checking For Fuel, Oil And Coolant Leaks - Shindaiwa DG25MK Assembly And Instruction Manual

 When replenishing LLC, be sure to use the same brand as the LLC remaining in the
radiator and sub-tank.
 Never use an LLC mixture of two different brands.
 Be sure to completely change every 2 years or 2,000 hours or less.
 LLC is a toxic substance. Wear rubber gloves and other protective wear when handling.
 If someone mistakenly ingests LLC, induce vomiting immediately and seek medical care.
 If LLC gets on skin or clothing, wash with water immediately.
 LLC is flammable. Store in a location where flame is prohibited and it cannot be accessed by
children.
 Engine coolant could leak if the radiator is not completely tightened or there is a gap in the
seating face. Always be sure to securely tighten the radiator cap.
 Do not add engine coolant past the FULL level line of the coolant sub-tank.
(3) Coolant Amount

8-3. Checking the Fuel

CAUTION : FIRE
 This generator uses diesel fuel. Always be sure to stop the engine and not
bring flames close when inspecting fuel or refueling. Wait until the engine has
cooled before performing such procedures.
Check if there is a sufficient amount of fuel and add fuel if insufficient. The engine fuel
level on the controller will only display the fuel level for the internal fuel tank.
Be sure to close the cap tightly after refueling.
< Note >
 Use Diesel fuel, ASTM D975 No.2-D in the event ambient
temperature reaches down to –5 °C.
 The fuel supply pump, injectors and other parts of the fuel
system and engine can be damaged if any fuel or fuel
additives are used other than those specifically
recommended by the engine manufacturer.
 Always be sure to use the fuel strainer attached to the fuel inlet.
 Carefully add fuel until the tank is full.
 Always be sure to wipe up any spilled fuel.

8-4. Checking for Fuel, Oil and Coolant Leaks

CAUTION : FIRE
 If fuel or oil is leaking, repair the leaking location before operating.
Open the check door and check for fuel, oil and coolant leakage from fuel piping
connections and similar locations.
Total Coolant Amount
9.7(1.1)
Value in parenthesis is the sub-tank capacity.
24
(Unit: L)
Fuel
Fuel Strainer
Inlet
Tank Cap
Fuel Cover