Kohler KDI 3404TCR-SCR Owner's Manual page 57

INFORMATION ABOUT WARRANTY
4.
You are responsible for initiating the warranty process. The ARB & US EPA suggests that you present your
off-road & Marine engine to a Kohler Co. dealer as soon as a problem exists. The warranty repairs should be
completed by the dealer as expeditiously as possible.
5. COVERAGE
Kohler Co. will repair or replace emission control system parts, components and sub-assemblies found to be
defective with respect to materials or workmanship at no cost to you including engine exhaust system related
diagnosis, labor and parts, provided that no un-authorized modification of any kind has been executed on the
engine, and its parts, components and sub-assemblies.
The choice and responsibility of the decision to repair or replace an emission control system defect will be solely that
of Kohler Co. Emission control system parts/ components covered by the Federal and California Emission Control
Systems Limited Warranty are listed below
engine is defective, the part will be repaired or replaced by Kohler Co.
Fuel injector(s)
Injection pump(s)
Exhaust manifold
Intake manifold
Exhaust gas recirculation (EGR) tube
Crankcase ventilation valve
Parts/components that are scheduled to be replaced as part of the required maintenance schedule will be covered
under the warranty provisions for a period of time up to the first scheduled replacement point for the subject parts/
components. Subsequent damage to other engine components as a direct result of a warrantable failure an exhaust
emission part/ component will be covered under the warranty provisions described herein.
6. MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all receipts
and records covering the performance of regular maintenance be retained in case questions arise. If the engine is
resold during the warranty period, the maintenance records should be transferred to each subsequent owner. Kohler
Co. may not deny warranty repairs solely because of the lack of repair, maintenance or failure to keep maintenance
records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any
repair establishment or individual; however, warranty repairs must be performed by a Kohler authorized service
center.
7. CALIFORNIA AND FEDERAL EMISSION CONTROLWARRANTY STATEMENT, OFF-ROAD & MARINE
DIESEL ENGINES (USA ONLY)
The California air resources board (carb), U.S. environmental protection agency (EPA), and Kohler Co. are pleased to
explain the emission control system warranty on your [current model year – {2+ current model year}] off-road
compression ignition and marine (diesel) engine. In California ("the state") and US EPA regulated region, new heavy-
duty off-road & marine engines must be designed, built and equipped to meet the state's and US EPA anti-smog
standards. The warranty period shall begin on the date the engine or equipment is delivered to an ultimate purchaser.
Kohler Co. must warrant the emission control system on your engine for the periods of time listed in the section
below, provided there has been no abuse, neglect or improper maintenance of your engine.
Your emission control system may include parts such as the fuel injection system and the air-induction system. Also
included maybe hoses, belts, connectors and other emission related assemblies.
Electronic control unit (ECU) if equipped
Sensors associated with ECU operation
Emission control information labels
Turbocharger (if equipped)
Fuel limiting device
Aftertreatment Systems if equipped and other components when present
8
57
EN