Trane CLCF Climate Changer Manual page 20

Installation
Hot/chilled water coils and humidification system
The quality of the water used in humidifiers and coils is very important to ensure proper operation.
Note: If a steam humidification with high steam pressure is used, provide a proper condensate drain system on the
steam pipe condensate outlet or condensate drain system.
FWD
CAUTION! The use of incorrectly treated or untreated water in this equipment may result in scaling, erosion,
Power supply
corrosion, algae, or slime. The bacteria flora may contaminate the humidifiers and decrease the heat transfer to the
Capacities
coils. The services of a qualified water treatment specialist should be engaged to determine what treatment, if any, Cooling capacity on water (1)
Heating capacity on water (2)
is required. The manufacturer assumes no responsibility for equipment damage or failure that results from the use
Fan motor
of aggressive water, or saline, or brackish water. Please refer to the individual supplier's installation, operation, and
Fan power input (3)
maintenance manual for additional information.
Current amps (3)
Start-up amps
CAUTION! In all drain pipes is mandatory to install a siphon properly designed to allow correct water drainage.
Air flow
minimum
Figure 14 – Standard drain pan for coil sections
nominal
maximum
Main coil
Water entering/leaving connections
Electric heater (accessory for blower only)
Electric power supply
Heating capacity
Hot water coil (accessory for blower only)
Heating capacity (4)
G2 filter (filter box accessory)
Quantity
Dimensions ( LxWxth)
G4 filter (filter box accessory)
Quantity
Dimensions ( LxWxth)
Condensate pump (accessory)
Water flow - lift height
Not available for FWD30 and FWD45
Sound level (L/M/H speed)
1 = Drain pipe
Sound pressure level (5)
2 = Drain valve
Sound power level (5)
A = Negative pressure side
Unit dimensions
B = Positive pressure side
Width x Depth
Figure 15 – Water tank for evaporative humidifier sections
Height
Shipped unit dimensions
Width x Depth
Height
Weight
Colour
Recommended fuse size
Unit alone (aM/gI)
Unit with electric heater (gI)
(1) Conditions: Water entering/leaving temperature: 7/12 °C, Air inlet temperature 27/19°C DB/WB - Nominal air flow
(2) Conditions: Water entering/leaving temperature: 50/45 °C, Air inlet temperature 20°C DB - Nominal air flow
(3) At high speed with nominal air flow.
(4) Water entering/leaving temperature 90/70 °C, air inlet temperature 20 °C DB, Nominal air flow.
(5) A rectangular glass wool duct 1m50 long is placed on the blower.The measurement is taken in the room containing the blower unit.
Heat exchanger operating limits:
FWD:
*water temperature: max 100° C
*absolute service pressure: min 1 bar/max 11 bars
Accessories - Hot water coil:
*water temperature: min. +2° C/max. 100° C
*absolute service pressure: min 1 bar/max 11 bars
1 = Overflow pipe
2 = Drain valve
3 = Additional drain for cleaning
A = Negative pressure side
B = Positive pressure side
4 20
Technical Data
08
(V/Ph/Hz)
(kW) 5,2
(kW) 6,3
(type)
(kW) 0,23
(A) 1,1
(A) 3,2
(m /h) 490
3
(m /h) 820
3
(m /h) 980
3
(type)
(Dia) 3/4"
(V/Ph/Hz) 230/1/50
(kW) 2/4
(kW) 6,3
2
(mm) 386x221x8
-
(mm) -
(type)
(l/h - mm)
(dB(A)) 36/40/43
(dB(A)) 46/50/53
(mm) 890 x 600
(mm) 250
(mm) 933 x 644
(mm) 260
(kg) 32
(A) 8/16
(A) 16 (2kW),25 (4kW)
12 20
230/1/50
8,3 15
11,9 18,9
2 x direct drive centrifugal
0,46 0,65
2,2 3,1
5,5 9,3
980 1400
1650 2300
1970 2600
ISO R7 rotating female
3/4" 1 1/2"
230/1/50 or 400/3/50 400/3/50
8 10
12 17,4
2 2
486x271x8 586x321x8
2 2
486x264x48 586x314x48
Centrifugal
24 - 500
38/41/44 46/50/53
48/51/54 56/60/63
1090 x 710 1290 x 820
300 350
1133 x 754 1333 x 864
310 360
46 61
galvanised steel
8/16 8/16
40 (230V),3*16 (400V) 3*20
30 45
18,8 30,1
20,9 38,2
1,04 1,51
4,7 5,5
14,1 16,5
1800 2700
3000 4500
3600 5400
1 1/2" 1 1/2"
400/3/50 400/3/50
12 12
22,4 34,5
2 2
586*421*8 586*621*8
2 2
586*414*48 586*614*48
47/52/57 47/52/58
57/62/67 57/62/68
1290 x 970 1290 x 1090
450 650
1333 x 1008 1333*1133
460 660
76 118
8/25 8/25
3*25 3*25
UNT-PRC002-GB AH-SVX03C-GB