Recharge Voltage Test; Alternator Check; Section 5: Electrical Checks - APRILIA RSV Mille 1000 1999 Technical Training Course

Aprilia Consumer Service Spa
Technical Service and Training
Release 4 july 99

SECTION 5: ELECTRICAL CHECKS

Refer to the key below when consulting this chapter:
Ar= orange
Az= light blue
B= blue
Bi= white
G= yellow
Gr= grey
M= brown
N= black
R= red
R= pink
V= green
Vi= purple
CHECK 1. RECHARGE VOLTAGE TEST
Check the electrolyte level
Check the battery voltage
Start the engine and take it up to 4000 rpm
Switch the light switch to dipped beam
test the DC voltage between the battery terminals with a tester
STANDARD VOLTAGE: 13 – 15 VOLTS
CHECK 2. ALTERNATOR CHECK
Disconnect the brown connector from the regulator
Start the engine and take it up to 4000 rpm
The voltage, measured as shown in the figure, must be not
less 60 Volts
The standard resistance of the generator coil is 0.1 – 1
Ohms.
Between cables and ground: infinite
This material is didactic and
may be changed following the technical
development of the product
G
G
G
G
Bi/R
Bi/R
R/B
V
V REG
V
30 A 30 A
+ -
V/Az
R/N