Adjusting The Clutch Lever Free Play - Yamaha Star XVS13AA(C) 2011 Service Manual

7. Fill:
• Crankcase
(with the specified amount of the recom-
mended engine oil)
Engine oil quantity
Total amount
3.70 L (3.91 US qt, 3.26 Imp.qt)
Without oil filter cartridge re-
placement
3.20 L (3.38 US qt, 2.82 Imp.qt)
With oil filter cartridge replace-
ment
3.40 L (3.59 US qt, 2.99 Imp.qt)
8. Start the engine, warm it up for several min-
utes, and then turn it off.
9. Check:
• Engine
(for engine oil leaks)
10.Check:
• Engine oil level
Refer to "CHECKING THE ENGINE OIL
LEVEL" on page 3-11.
11.Check:
• Engine oil pressure
M MMM M MMM M M MMM M M MMM M
a. Slightly loosen the front cylinder oil check bolt
"1" and rear cylinder oil check bolt "2".
1
b. Start the engine and keep it idling until engine
oil starts to seep from the oil check bolts. If no
engine oil comes out after one minute, turn
the engine off so that it will not seize.
M MMM M M MMM M MMM
2
3-13
c. Check the engine oil passages, the oil filter
cartridge and the oil pump for damage or
leakage. Refer to "OIL PUMP" on page 5-80.
d. Start the engine after solving the problem(s)
and check the engine oil pressure again.
e. Remove the throttle body. Refer to "THROT-
TLE BODIES" on page 7-9.
f. Tighten the oil check bolts to specification.
Oil check bolt
15 Nm (1.5 m·kg, 11 ft·lb)
g. Install the throttle body. Refer to "THROTTLE
BODIES" on page 7-9.
L LLL L LLL L L LLL L L LLL L
EAS20870
ADJUSTING THE CLUTCH LEVER FREE
PLAY
1. Check:
• Clutch lever free play "a"
Out of specification → Adjust.
Clutch lever free play
5.0–10.0 mm (0.20–0.39 in)
a
2. Adjust:
• Clutch lever free play
M MMM M MMM M M MMM M M MMM M
Clutch lever free play adjusting bolt
a. Slide back the rubber cover. (For
XVS13AA(C)/XVS13CTA(C))
b. Loosen the locknut "1".
c. Turn the adjusting bolt "2" in direction "a" or
"b" until the specified clutch lever free play is
obtained.
Direction "a"
Clutch lever free play is increased.
Direction "b"
Clutch lever free play is decreased.
d. Tighten the locknut "1".
ENGINE
L LLL L L LLL L LLL
M MMM M M MMM M MMM