Long-Term Storage - Shindaiwa DGK25F Owner's And Operator's Manual

CAUTION : FIRE
 Do not carry flammable items (such as fuel, gas and paint) or items that are
highly combustible near the generator as the muffler, exhaust gas and other
parts become extremely hot.
 Position this generator 3 ft. (1 m) or more from walls or other hindrances, and
on a level surface.
CAUTION : INJURY
 Do not operate the generator if it has been modified or any parts have been
removed.
 Position the generator on a level stable surface so that it cannot slide or
move in any manner.
 Before starting operation, always be sure to turn off all switches of equipment
being used and all breakers to OFF.
Clean Every 250 hours
Accumulation of carbon (soot, unburned fuel) in the exhaust system could cause only a
system derates or an engine fault occurs. To eliminate soot and unburned fuel, run the unit
at more than 70% of the rated output for about half an hour, until the exhaust gas become
mostly colorless. The carbon will be easier to be accumulated when the unit runs at less
than 30% of rated output.
< Note >
 When the unit runs at rated power suddenly, accumulation of carbon in the exhaust system might
cause back fire incident. Operate the generator starting from 50% of the rated output and then
increase load gradually after confirming exhaust gas become colorless. Do not carry flammable
items that are highly combustible near the generator.

11. Long-Term Storage

WARNING : INJURY
 Always be sure to stop the engine and remove the starter key when
performing inspection or maintenance.
CAUTION : FIRE
 Always be sure to wipe up any spilled fuel or oil.
 Allow the generator to cool before covering with the protective cover.
CAUTION : BURNS
 Do not touch the engine and surrounding components immediately after
stopping the engine as they are still extremely hot.
44