Page 1
For U.S.A., Canada, Europe & Japan model Ver. 1 SERVICE MANUAL S-301 MODEL DVD HOME THEATER SYSTEM HOME THEATER SYSTEM (S-301) consists of DVD SURROUND RECEIVER (ADV-S301) and SUB WOOFER (DSW-S301) and SPEAKER SYSTEM (SC-S301) 注 意 サービスをおこなう前に、このサービスマニュアルを 必ずお読みください。本機は、火災、感電、けがなど に対する安全性を確保するために、さまざまな配慮を おこなっており、また法的には「電気用品安全法」に...
S-301 SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check.
Page 3
S-301 DISASSEMBLY 各部のはずしかた (Follow the procedure below in reverse order when (組み立てるときは、逆の順序でおこなってください。 ) reassembling.) 1. Loader Panel 1. ローダーパネルのはずしかた (1) Switch on, and press [ (OPEN/CLOSE)] button (1) 電源を入れ「 (OPEN/CLOSE)」ボタンを押して、 to open the Disc tray. ディスクトレイを開きます。 (2) Detach the Loader Panel by lifting.
Page 4
S-301 3. Top Cover 3. トップカバーのはずしかた (1) Remove 9 top screws, then detach Top Cover. (1) トップカバーを止めている上部のネジ 9 本をはず し、トップカバーを矢印の方向へはずします。 4. フロントパネルのはずしかた 4. Front Panel Ass’y (1) フロントパネルからの基板とシャーシを止めてい (1) Remove 3 Front panel screws, then detach P.W.B. るネジを 3 本はずします。...
Page 6
S-301 7. Traverse Unit Disassembly 7. トラバースユニットのはずしかた Caution: The optical pickup can be damaged easily 注意:光ピックアップは、人体に帯電した静電気等で by static electricity charged on human body. Take 静電破壊することがあります。光ピックアップ周辺を necessary anti-static measures when repairing 修理する際は、必要な静電対策を行ってください。 around the optical pickup. 7.1. Guide Clamp Bracket disassembly 7.1.
Page 8
S-301 DIAGNOSTICS OF OPTICAL PICKUP 光ピックアップの故障診断とトラバース AND REPLACING TRAVERSE UNIT ユニットの交換 Make failure diagnostics of the Optical Pickup as follows. 次の順序で故障診断を行ってください。 If the laser drive current (Iop) becomes more than 1.5 times of レーザー駆動電流 Iop 値が初期値の 1.5 倍以上になっている the initial value, the Optical Pickup should be replaced.
Page 9
S-301 1. Label Indication of SACD Mechanism. 1. SACD メカのラベル表示 Laser current consumption value ex) DVD mA, CD mA, CD 2. Note for Handling the Laser Pick-Up 2. レーザーピックアップの取扱注意 The protection for the damage of laser diode. レーザーダイオードの破壊防止。 If you want to change the optical device unit from any other 光素子ユニットを交換するときは、以下を遵守してくださ...
Page 10
S-301 4.1. DVD Laser current measurement 4.1. DVD レーザー電流測定 LD (DVD) LD (DVD) +5V-A2 +5V-A2 Oscilloscope Oscilloscope (1) Connect the oscilloscope to +5V-A2 of test point for (1) オシロスコープをテストポイント +5V-A2 (GND) と LD (DVD) ( 信号 ) へ接続します。 GND side and LD (DVD) of test point for signal side.
Page 11
S-301 Special operating procedures 特殊操作方法 1. Initialization 1. 初期化 This initializes the data for the function, volume, ※ ファンクション、VOL 及び DVD メカ (RL-874) 等の ※ DVD mechanism (RL-874), etc. データを初期化します。 (1) Check that the AC cord is disconnected from the (1) AC コードがコンセントより外れていることを確認...
Page 12
S-301 ADJUSTMENT 調整 1. SETTING 1. セッティング手順 (1) Connect the oscilloscope to the Y-signal, P -signal and (1) セットの ZONE2 COMPONENT OUT の端子(Y, P )をそれぞれオシロスコープ(終端抵抗:75Ω) -signal, P -signal and C -signal of ZONE2 COMPO- に接続します。 NENT OUT terminal and each terminate at 75 Ohms.
Page 13
S-301 2.4. Procedure 2.4. 手順 (1) Adjust the signal of COMPONENT OUT by the wave of (1) COMPONENT OUT の信号レベルをオシロスコープ上の oscilloscope. 波高値で調整します。 (a) Y 信号レベル (a) Target, Y-signal 調整個所 : 1U-3695-3 VR601 Point 1U-3695-3 VR601 調整値 : 714 ± 35mV Adjustment Value 714 ±...
Page 18
S-301 Name Pin Numbers Definition TSD0 Audio transmit serial data port 0. SEL_PLL0 Refer to the description and matrix for SEL_PLL2 pin 32. TSD1 Audio transmit serial data port 1. SEL_PLL1 Refer to the description and matrix for SEL_PLL2 pin 32.
Page 19
S-301 Name Pin Numbers Definition DSCK Output clock to DRAM. DCLK Clock input to PLL. YUV0 YUV pixel 2 output data. CAMIN2 Camera YUV 2. UDAC Video DAC output. Value F DAC V DAC Y DAC C DAC U DAC...
Page 20
S-301 Name Pin Numbers Definition ADVSS Analog ground for video DAC. YUV5 YUV pixel 5 output data. YDAC Video DAC output. Refer to description and matrix for UDAC pin 106. YUV6 YUV pixel 6 output data. VDAC Video DAC output. Refer to description and matrix for UDAC pin 106.
Page 21
S-301 Name Pin Numbers Definition Host data bus line 9. AUX2[1] Aux2 data I/O. HD10 Host data bus line 10. AUX2[2] Aux2 data I/O. HD11 Host data bus line 11. AUX2[3] Aux2 data I/O. IRQ. HD12 Host data bus line 12.
Page 22
S-301 Name Pin Numbers Definition HRD# Host read (active-low). DCI_ACK# DVD channel data valid (active-low). AUX4[6] Aux4 data I/O. HIOCS16# Device 16-bit data transfer (active-low). CAMCLK Camera port pixel clock input. AUX3[4] Aux3 data I/O. HCS1FX# Host select 1 (active-low).
S-301 FLI2310 (IC403: 1U-3692) Pin Diagram HSYNC1 PORT1 VSYNC1 PORT1 1 5 5 G/Y/Y OUT 7 FIELD ID1 PORT1 G/Y/Y OUT 6 IN CLK1 PORT1 G/Y/Y OUT 5 HSYNC2 PORT1 G/Y/Y OUT 4 VSYNC2 PORT1 G/Y/Y OUT 3 FIELD ID2 PORT1...
Page 24
S-301 Pin details Voltage Pull up/ No Pin Name I/O Type Tolerance Drive Pulldown Description Horizontal sync or reference -CTL1 of Port 1 HSYNC1 PORT1 Input Vertical sync or reference -CTL1 of Port 1 VSYNC1 PORT1 Input FIELD ID1 PORT1...
Page 25
S-301 Voltage Pull up/ No Pin Name I/O Type Tolerance Drive Pulldown Description 45 SCLK 8 mA 2-wire serial control bus clock 46 SDATA 8 mA 2-wire serial control bus data 47 RESET N Input Reset 48 VDD3 Power 3.3 V Power pin for IO...
Page 26
S-301 Voltage Pull up/ No Pin Name I/O Type Tolerance Drive Pulldown Description 89 VSS Ground Ground 90 TEST IN Test input-Connect to ground Input 91 SDRAM ADDR(10) 8 mA SDRAM address bus * Tristate O/P 92 SDRAM ADDR(9) 8 mA...
Page 27
S-301 Voltage Pull up/ No Pin Name I/O Type Tolerance Drive Pulldown Description 128 VDD7 3.3 V Power pin for IO Power 129 VSS Ground Ground 130 B/U/Pb OUT 2 8 mA Digital video output Blue/U/Pb Tristate O/P 131 B/U/Pb OUT 3...
Page 28
S-301 Voltage Pull up/ No Pin Name I/O Type Tolerance Drive Pulldown Description 172 DAC AVSSB Ground Analog Ground for B channel 173 DAC GOUT Output 34 mA Analog G/Y output 174 DAC AVDDG Power 3.3 V Analog power pin for G channel...
Page 30
S-301 16/4M DRAM ECC Core Memory Data manager Slicer Demodulation Video MPEG I/F CD-DSP (DDCD) Data-PLL VSTEM Serial ASP Serial I/F VSTEM Serial I/F Command CD-ROM DSP CLK/Mode Header Dec. Spindle Audio I/F Audio JTAG CMD/ MCU I/F Mecha Direction Data reg.
Page 31
S-301 Terminal Name Classification Function 31 SYSCK Clock Clock Monitor output. 32 DV & GND Digital 1.8V Power. (Internal logic system power) 33 XI Clock Crystal oscillation input. 34 XO Clock Crystal oscillation output. 35 DV & GND Digital Ground.
Page 33
S-301 Terminal Name Classification Function 150 RD14 DRAM I/F DRAM data input/output terminal 14. 151 RD13 DRAM I/F DRAM data input/output terminal 13. 152 RD12 DRAM I/F DRAM data input/output terminal 12. 153 RD11 DRAM I/F DRAM data input/output terminal 11.
Page 37
S-301 Pin Name Functions 1 VSC It fixed to ground.( for Core) 2 XMSLAT Latch input for µCOM serial communication. 3 MSCK Shift clock input for µCOM serial communication. 4 MSDATI Data input for µCOM serial communication. 5 VDC +2.5V Power for Core.
Page 38
S-301 Pin Name Functions 50 TESTO Output for TEST. (open) 51 TESTI Input for TEST. It fixed to “L” potential. 52 TESTI Input for TEST. It fixed to “L” potential. 53 TESTO Output for TEST. (open) 54 VDC +2.5V Power for CORE.
Page 39
S-301 Pin Name Functions 96 TESTI TEST input terminal. It fixed to “L” potential. 97 TESTI TEST input terminal. It fixed to “H” potential. 98 TESTO TEST output terminal. (open) 99 VDC +2.5V Power for CORE. 100 TESTI TEST input terminal. It fixed to “L” potential.
Page 40
S-301 Pin Name Functions 148 A11 Address output terminal for SDRAM. (MSB) 149 A10 Address output terminal for SDRAM. 150 VSC Ground for CORE. 151 A9 Address output terminal for SDRAM. 152 A8 Address output terminal for SDRAM. 153 VDC +2.5V Power for CORE.
Page 41
S-301 ADSP-21266SKSTZ-1C (IC906: 1U-3694) PIN 1 INDICATOR TOP VIEW ADSP-21266SKSTZ-1C Terminal Function LQFP LQFP LQFP LQFP Pin Name Pin # Pin Name Pin # Pin Name Pin # Pin Name Pin # DDINT DDINT DDEXT CLKCFG0 DDINT CLKCFG1 DDINT BOOTCFG0...
Page 42
S-301 M30627FHPGP (IC202: 1U-3694) Port Port Port Name Explanation Function setting VREF VREF Reference Voltage Input for A/D converter AVcc AVcc Positive power SIN4 FL_CS Chip Enable output to FLD SOUT4 FL_DA Serial Data output to FLD CLK4 FL_CK Serial Clock output to FLD...
Page 43
S-301 Port Port Port Name Explanation Function setting LD_CONT LD power control signal output. H:DVD L:CD USB_REQ Interrupt Request from USB Module. V_CONT DVD LOADER control signal output. (PWM) VOL JOG-B VOL encoder Pulse-B input VOL JOG-A VOL encoder Pulse-A input USB_CE Chip Enable output to USB Module.
Page 44
S-301 Port Port Port Name Explanation Function setting P122 Not Used: N. C. P121 DIR RST Reset output to DIR P120 CLATCH Latch Output to AD1837. VCC2 Positive power CODEC_RST Reset output to AD1837 TU_POWER TUNER Power ON/OFF output. H: Power ON STEREO "STEREO"...
Page 45
S-301 HY57V6432320DTP (IC404: 1U-3692) PIN CONFIGURATION DQ15 BLOCK DIAGRAM DQ14 DQ13 DQ12 Data Input Register DQ11 LDQM Bank Select DQ10 512K x 32 512K x 32 512K x 32 DQM0 DQM1 512K x 32 Column Decoder Latency & Burst Length...
Page 49
S-301 ADV7310 (IC302, 501: 1U-3692) VDD_IO S_BLANK SET 1 VREF COMP1 DAC A DAC B DAC C TOP VIEW AGND DAC D DGND DAC E DAC F COMP2 SET 2 EXT_LF RESET ADV7310 Terminal Function Pin No. Pin Name Function Digital power supply.
Page 52
S-301 Power Supply Pins Name Function Power for RF and serial port Power for servo GND for RF and serial port GND for servo Power for output buffer Reference Power for servo output Input Pins Name Function DVDRFP,DVDRFN RF signal input...
Page 53
S-301 Analog Pins Name Function RF AGC integration capacitor connecting terminal Differential phase tracking LPF terminal Differential phase tracking LPF terminal Lens shift offset cancel LPF terminal Lens shift offset cancel LPF terminal MIRR top hold terminal MIRR bottom hold terminal...
Page 54
S-301 M12L64164A (IC103: 1U-3692) DQ15 VssQ DQ14 DQ13 DQ12 DQ11 DQ10 LDQM UDQM A10/AP Terminal Function Pin No. Pin Name Function Description 1, 14, 27 Power (+3.3V) Power for input buffers and logic circuit inside DRAM. 2, 4, 5, 7, 8, 10,...
Page 57
S-301 16M SDRAM (IC603: 1U-3692) Terminal Function Pin No. Pin Name Symbol Function Power Supply/Ground Power and ground for the input buffer and the core logic Data Input/Output Data input/output are mutiplexed on the same pin Data Input/Output Data input/output are mutiplexed on the same pin...
Page 59
S-301 PIN DESCRIPTION Input Name Property Description voltage − − VDDL 2.5V Core power supply PCM output rate select 1 SEL1FS 3.3V L: 2fs/4fs, H: fs PCM output rate select 2 SEL4FS 3.3V L: 2fs, H: 4fs fs/2fs/4fs output and external data output select SELEXT 3.3V...
Page 60
S-301 Input Name Property Description voltage − DSIFL 3.3V DSD data input: front left-channel − DSIFR 3.3V DSD data input: front right-channel − DSICT 3.3V DSD data input: center channel − DSISW 3.3V DSD data input: subwoofer channel − DSISL 3.3V...
Page 62
S-301 Block Diagram OPOUT2 SVCC OPIN2+ OPIN1- OPIN1+ OPOUT1 VREF OPIN2- PVCC1 POWER SAVE IN1+ DO1+ 40 K DO1- IN1- 10 K DO2+ OUT1 10 K IN2+ DO2- 10 K IN2- DO3+ 10 K 10 K 10 K 10 K...
Page 63
S-301 Pin Number Pin Name Pin Function Descrition IN1+ CH1 op amp input (+) CH1 op amp input ( ) OUT1 CH1 op amp output IN2+ CH2 op amp input (+) CH2 op amp input ( ) Ground Ground OUT2...
Page 64
S-301 LC89057W (IC707: 1U-3694) EMPHA/UO AUDIO/VO XMODE Microcontroller RXOUT C bit, U bit 37 DO 36 RERR 24 SDIN 23 SLRCK Input Demodulation 22 SBCK Data Selector 21 RDATA & Selector 21 RDATA Lock Detect XMODE 20 RLRCK RX5/VI DGND...
Page 65
S-301 Pin Name Function XOUT X’tal osc. connecting output terminal X’tal osc. connection, external clock input terminal (24.576MHz or 12.288MHz) DVDD — Digital power DGND — Digital GND EMPHA/UO Emphasis information/U-data output/Chip address setting terminal AUDIO/VO Non-PCM detect/V-flag output/ Chip address setting terminal...
Page 66
S-301 LH28F800BJE (IC907: 1U-3694) TA1270BF (IC501: 1U-3695) Y OFFSET C BUS PEDESTAL PEDESTAL DAC2 TEST CONTROL CLAMP CLAMP DAC1 SW GND HI: 20h/LOW: 24h SUB- DAC1 Y INPUT ADRS SW Y DL CONTRAST OFFSET PEDESTAL R-Y/R DAC Vcc (5V) CLAMP...
Page 67
S-301 CY7C1049CV-33-10ZC (IC908, 910: 1U-3694) Top View INPUT BUFFER 512K x 8 ARRAY POWER COLUMN DOWN DECODER AN8471SA (IC971: 1U-3692) Pin No. Pin Name Function Hall bias pin Hall element 3 input (-) Hall element 3 input (+) Hall element 2 input (-)
Page 70
S-301 Terminal Functions TERMINAL DESCRIPTIONS NAME PLRCK Left and right clock (f s ) input for PCM format operation. WDCK clock input in external DF mode. Connected to ground in DSD mode PBCK Bit clock input for PCM mode. Connected to GND for DSD mode...
Page 71
S-301 BH7868FS (IC305: 1U-3692) (IC301, 302: 1U-3695) 6MHz Vcc1 COUT 75Ω S-DCOUT S-DCOUT 6MHz 75Ω CVOUT Bias CVOUT MUTE1 MUTE1 6MHz CVIN Clamp 75Ω YOUT SEL (CV/MIX) YOUT SAG Clamp 12MHz BIAS Bias 75Ω Py/G OUT SEL (BIAS/CLAMP) Py/G OUT SAG...
Page 73
S-301 PCM1802 (IC803; 1U-3683) PCM1802 (TOP VIEW) MODE1 MODE0 FMT1 FMT0 AGND SCKI PDWN BYPAS DGND FSYNC DOUT LRCK block diagram 5 th Order Single-End V IN L /Differential Delta-Sigma LRCK Converter Modulator FSYNC Serial 1/64 ( 1/128) Interface V REF1...
Page 74
S-301 SM8701BM (IC113: 1U-3692) SM8701BM Terminal Function Pin Name Function Pin No. Control signal input. MLEN/R2 MCK/R1 MLEN/R2 In serial mode: latch enable signal In parallel mode: sampling rate select signal MDT/R0 Mode select signal. RSTN LOW: serial mode, HIGH: parallel mode ...
Page 75
S-301 SN74LV244APW (IC708, 719: 1U-3694) BU2090F (IC303: 1U-3681) SN74HCT244APW (IC205: 1U-3694) (IC504: 1U-3695) CONTROL CIRCUIT DATA 12-bit SHIFT REGISTER CLOCK 12-bt STRAGEREGISTER O U T P U TB U FFE R(O P E ND R AN ) SN74LV157APW (IC303: 1U-3692)
Page 76
S-301 SN74CBTLV325PWB (IC209: 1U-3694) (TOP VIEW) NJM2595 (IC507, 508: 1U-3695) BU4053BCF (IC510: 1U-3695) BU4052BCF (IC518: 1U-3695) YOUT COMMON Y XOUT COMMON X TC74VHC74FT (IC703: 1U-3694) SN74LVC3G04 (IC112: 1U-3693) LOGIC DIAGRAM (POSITIVE LOGIC)
Page 77
S-301 MIC2025 (IC102: 1U-3693) Pin Description Pin Number Pin Name Pin Function Switch Enable (Input): Active high ( 1) or active low ( 2). MIC2025/75 Fault Flag (Output): Active low, open drain output. Indicates overcurrent or thermal shutdown conditions. Overcurrent condition must exceed t in order to assert FLG.
S-301 CY2302 (IC115: 1U-3692) Block Diagram Pin Configuration External feedback connection to FBIN OUT1 or OUT2, not both FBIN OUT2 OUT1 ÷Q Phase Charge Configuration Options Detector Pump Reference Input FBIN OUT1 OUT2 OUT1 2 X REF Loop Filter OUT1...
Page 79
S-301 BD9781HFP (IC810: 1U-3695) EN/SYNC 5~35V ON/OFF L:OFF H:ON 1μF 220μF Vref SYNC SOFT START 24KΩ B D 9 7 8 1 H V F P ERROR AMP COMPARATOR DRIVER LATCH 33μH 10KΩ 150KΩ RESET Vref 330μF 4700μF CURRENT LIMIT 390KΩ...
Page 80
S-301 SN74LVC2G14 (IC113: 1U-3693) LOGIC DIAGRAM (POSITIVE LOGIC) STR-F6238S (IC902: 1U-3682: E3) STR-F6267S (IC902: 1U-3682: E2) DR V .R E G O.V .P Latch S tart R g2 R g3 R g1 R eg. FRONT DR V VIEW T .S .D.
Page 81
S-301 SI-8120E (IC901: 1U-3682) BA00BCOWFP (IC304: 1U-3681) KIA78R00API (IC208: 1U-3694) FRONT VIEW PIN FUNCTION 1. IN 1. CLT 2. OUT 2. Vcc 3. GND 3. N.C. 4. ADJUSTABLE 4. OUT 1 2 3 4 5. N.C. FIN:GND 1 2 3 4 5...
Page 97
S-301 NOTE FOR PARTS LIST 部品表について • Part indicated with the mark "nsp" are not always in stock and possibly to 1.nsp 印の部品は常時在庫していませんので供給に長時間を要すること take a long period of time for supplying, or in some case supplying of part があります。 may be refused.
Page 98
S-301 PARTS LIST OF P.W.B. UNIT *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 124
S-301 00D1U-3692A/B/C DVD MECHA P.W.B. UNIT ASS'Y Ref. No. Part No. Part Name Remarks Q'ty New SEMICONDUCTORS GROUP IC101 00D 262 3252 000 ES6138F(SC) +REF IC102 00D GEN 8047 DVD B/E FLASH ASS'Y MX29LV160BBTC-70G IC103 00D 262 3548 002 M12L64164A-7TG...
Page 125
S-301 Ref. No. Part No. Part Name Remarks Q'ty New TR509 00D 269 0192 902 KRC102S-RTK(10K-10K) +C for E2 TR510 00D 269 0184 907 KRA102S-RTK for E2 TR590,591 00D 269 0192 902 KRC102S-RTK(10K-10K) +C TR592 00D 269 0184 907 KRA102S-RTK...
Page 126
S-301 Ref. No. Part No. Part Name Remarks Q'ty New CAPACITORS GROUP C101 00D 257 0511 904 CK73F1H103ZT +1608 C102 00D 257 0512 903 CK73F1E104ZT +1608 C103 00D 257 0509 929 CK73B1H102KT +1608 C104 00D 254 4738 904 CE67W0J101MT(GV) C105-111...
Page 127
S-301 Ref. No. Part No. Part Name Remarks Q'ty New C194 00D 247 2018 903 RM73B--0R0KT +1608 for E3 C195 00D 257 0511 904 CK73F1H103ZT +1608 for E2, JP C195 00D 247 2018 903 RM73B--0R0KT +1608 for E3 C196 00D 254 4738 904...
Page 134
S-301 00D1U-3693A USB P.W.B. UNIT ASS'Y Ref. No. Part No. Part Name Remarks Q'ty New SEMICONDUCTORS GROUP IC101 00D 262 3523 001 BCOIC-DM850-CQL IC102 00D 262 3522 905 MIC2025-1YM IC111 00D 262 3524 903 SN74LVC1G373DBVR IC112 00D 262 3525 902...
Page 135
S-301 Ref. No. Part No. Part Name Remarks Q'ty New JK311 00D 204 8714 000 USB CONNECTOR(TOPYANG BLACK) W302 00D 205 1034 010 M3 SCREW TERMINAL X131 00D 399 1030 908 HC-49/U03C24.576MHZ...
Page 136
S-301 EXPLODED VIEW WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. 印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。 E2 only...
Page 137
S-301 PARTS LIST OF EXPLODED VIEW *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 138
S-301 Ref. No. Part No. Part Name Remarks Q'ty New 00D 146 2441 206 INNER PANEL ASSY 00D 113 2030 002 POWER KNOB ASSY 00D 113 2031 001 EJECT KNOB ASSY 00D 113 2032 000 FUNCTION KNOB ASSY 00D 113 2027 206...
Page 139
S-301 Ref. No. Part No. Part Name Remarks Q'ty New 00D 513 4101 003 CAUTION LABEL for E2 ★ 00D 203 5372 002 3P ZH-PH CON.CORD ★ 00D 203 8567 005 5P PH-PH CON.CORD for E3 ★ 00D 203 8568 004 5P PH-PH CON.CORD...
Page 141
S-301 PARTS LIST OF DVD MECHANISM UNIT *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 142
S-301 Ref. No. Part No. Part Name Remarks Q'ty New FEED MOTOR ASS'Y POLY.SLIT WASHER 2.1X4X0.25C FEED GEAR 3RD 00D 9KC 1G04 3 DAMPER SPECIAL SCREW (FRONT) SPECIAL SCREW (REAR) 00D 9KB 7P02 4 TRAY-SPRING-VXF 00D 9KC 1G04 2 RUBBER CUSHION TAPE W10X45 (NITTO NO.156)
Page 143
S-301 POINTS OF GREASING With Cemedine 575, glue 3 joint parts of Clamper-L and H hooks. (0.05mg each x 3) *As for greasing to the R rail groove and groove's side edge, apply grease to the outer face "intentionally". (Not only running a brush into the groove, use it with pressing to the outer face consciously.)
Page 144
S-301 DSW-S301 EXPLODED VIEW WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. 印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。...
Page 145
S-301 DSW-S301 PARTS LIST OF EXPLODED VIEW * 本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 146
S-301 Ref. No. Part No. Part Name Remarks Q'ty New 00D 461 1238 021 PEF SHEET(10X182) ★ 00D 461 1238 034 PEF SHEET(10X280) ★ 00D 513 4082 009 RATING LABEL(S301E3) for E3 ★ 00D 513 4083 008 RATING LABEL(S301E2) for E2 ★...
Page 147
S-301 SC-S301 EXPLODED VIEW for Lch for Rch for Lch for Lch for Rch for Rch...
Page 148
S-301 SC-S301 PARTS LIST OF EXPLODED VIEW * 本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 149
S-301 Ref. No. Part No. Part Name Remarks Q'ty 00D 949 0059 206 +P 3X8 TAP TYTE SCREW 70-078-308-06 00D 949 0059 303 +P 3X14 TAP TYTE SCREW 70-078-314-06 00D 949 0059 109 +B 4X8 TAP TYTE SCREW 70-073-408-06 00D 949 0060 402...
Page 150
S-301 PACKING VIEW DVD SURROUNDRECIEVER ADV-S301 ACCESSORY BOX ASSY SPEAKER SYSTEM SCS301SRM SUB WOOFER 106 107 108 MASTER CARTON PARTS LIST OF PACKING & ACCESSORIES *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions.
Page 151
S-301 Ref. No. Part No. Part Name Remarks Q'ty 00D 503 1511 107 CUSHION (L) for ADV-S301 00D 503 1512 106 CUSHION (R) for ADV-S301 00D 511 4337 004 SETUP GUIDE 00D 501 2304 029 ACCESSORY BOX 00D GEN 6958...
Page 152
S-301 WIRING DIAGRAM (1) S301 DSW S301 SC S301 SC S301 ADV S301 ITEM PART NO. PART NAME 00D2046794006 25P D-SUB CABLE 00D2032439003 SP CABLE ASSY (2) DSW-S301 ADV S301 CX251 TERMINAL UNIT IN/OUT UNIT 1U-3683A-3 1U-3683A-2 CX031 CX042 CX111...
Page 153
S-301 (2) ADV-S301 DSW S101 CY251 LOCAL POWER UNIT 1U-3695A-1(E3) TUNER 1U-3695B-1(E2) PACK 1U-3695C-1(J) CONVERT UNIT CY072(E2) CX162 CX141 CX162 1U-3695A-3(E3) (Board to (Board to (Board to 1U-3695B-3(E2) CX051(E3) Board) Board) Board) 1U-3695C-3(J) I/F BOARD UNIT 1U-3695A-2(E3) CY033 1U-3695B-2(E2) 1U-3695C-2(J)
Page 154
S-301 ITEM PART NO. PART NAME 00D2035372002 3P ZH-PH CON.CORD 00D2040599003 6P PH-PH CON.CORD E2 ONLY 00D2048567005 5P PH-PH CON.CORD E3 ONLY 00D0090265004 17P FFC CABLE 00D2040570022 6P PH-PH SHIELD CORD 00D2042996002 7P PH-PH CON.CORD E3 ONLY 00D0090236020 15P FFC CABLE 00D2042997001 10P ZH-PH CON.CORD...
Page 155
S-301 WAVEFORMS 1U-3692 ● DVD PLAY Disc: TDV-520A CD PLAY DISC DETECT (CD) ③FSCON ⑥TE ②FE ⑦TSCON ①RFAC VC16 ⑧T+ ⑯PI ⑨T- ⑰MIRR DVD PLAY (INNER) CD PLAY Disc: TCD-784 ⑩DMO ⑪FG ①RFAC VC16 ⑫A3 CD PLAY (INNER) DVD LOADING PLAY ②FE...
Page 156
S-301 NOTE FOR SCHEMATIC DIAGRAM 配線図について WARNING: ! 印の部品は安全を維持するために重要な部品です。 Parts marked with this symbol ! have critical characteristics. 従って交換時は必ず指定の部品を使用してください。 Use ONLY replacement parts recommended by the manufactur- 注) CAUTION: (1) 指定なき抵抗値は Ω、k は kΩ、M は MΩ を示す。 Before returning the unit to the customer, make sure you make µ...
Page 157
S-301 SCHEMATIC DIAGRAMS (1/50) SLD- SLD+ SIGNAL LINE SCHEMATIC DIAGRAMS (1/50) 1U-3692 DVD/VIDEO UNIT (1/7) (E3 model only)
Page 158
S-301 SCHEMATIC DIAGRAMS (2/50) SLD- SLD+ SIGNAL LINE SCHEMATIC DIAGRAMS (2/50) 1U-3692 DVD/VIDEO UNIT (1/7) (E2 model only)
Page 159
S-301 SCHEMATIC DIAGRAMS (3/50) SLD- SLD+ SIGNAL LINE SCHEMATIC DIAGRAMS (3/50) 1U-3692 DVD/VIDEO UNIT (1/7) (JP model only)
Page 160
S-301 SCHEMATIC DIAGRAMS (4/50) SIGNAL LINE SCHEMATIC DIAGRAMS (4/50) 1U-3692 DVD/VIDEO UNIT (2/7) (E3 model only)
Page 161
S-301 SCHEMATIC DIAGRAMS (5/50) SIGNAL LINE SCHEMATIC DIAGRAMS (5/50) 1U-3692 DVD/VIDEO UNIT (2/7) (E2 model only)
Page 162
S-301 SCHEMATIC DIAGRAMS (6/50) SIGNAL LINE SCHEMATIC DIAGRAMS (6/50) 1U-3692 DVD/VIDEO UNIT (2/7) (JP model only)
Page 163
S-301 SCHEMATIC DIAGRAMS (7/50) SIGNAL LINE SCHEMATIC DIAGRAMS (7/50) 1U-3692 DVD/VIDEO UNIT (3/7) (E3 model only)
Page 164
S-301 SCHEMATIC DIAGRAMS (8/50) SIGNAL LINE SCHEMATIC DIAGRAMS (8/50) 1U-3692 DVD/VIDEO UNIT (3/7) (E2 model only)
Page 165
S-301 SCHEMATIC DIAGRAMS (9/50) SIGNAL LINE SCHEMATIC DIAGRAMS (9/50) 1U-3692 DVD/VIDEO UNIT (3/7) (JP model only)
Page 166
S-301 SCHEMATIC DIAGRAMS (10/50) SCHEMATIC DIAGRAMS (10/50) 1U-3692 DVD/VIDEO UNIT (4/7) (E3 model only)
Page 167
S-301 SCHEMATIC DIAGRAMS (11/50) SCHEMATIC DIAGRAMS (11/50) 1U-3692 DVD/VIDEO UNIT (4/7) (E2 model only)
Page 168
S-301 SCHEMATIC DIAGRAMS (12/50) SCHEMATIC DIAGRAMS (12/50) 1U-3692 DVD/VIDEO UNIT (4/7) (JP model only)
Page 169
S-301 SCHEMATIC DIAGRAMS (13/50) SCHEMATIC DIAGRAMS (13/50) 1U-3692 DVD/VIDEO UNIT (5/7) (E3 model only)
Page 170
S-301 SCHEMATIC DIAGRAMS (14/50) SCHEMATIC DIAGRAMS (14/50) 1U-3692 DVD/VIDEO UNIT (5/7) (E2 model only)
Page 171
S-301 SCHEMATIC DIAGRAMS (15/50) SCHEMATIC DIAGRAMS (15/50) 1U-3692 DVD/VIDEO UNIT (5/7) (JP model only)
Page 173
S-301 SCHEMATIC DIAGRAMS (17/50) SCHEMATIC DIAGRAMS (17/50) 1U-3692 DVD/VIDEO UNIT (7/7) (E3 model only)
Page 174
S-301 SCHEMATIC DIAGRAMS (18/50) SCHEMATIC DIAGRAMS (18/50) 1U-3692 DVD/VIDEO UNIT (7/7) (E2 model only)
Page 175
S-301 SCHEMATIC DIAGRAMS (19/50) SCHEMATIC DIAGRAMS (19/50) 1U-3692 DVD/VIDEO UNIT (7/7) (JP model only)
Page 176
S-301 SCHEMATIC DIAGRAMS (20/50) SIGNAL LINE SCHEMATIC DIAGRAMS (20/50) 1U-3693 USB UNIT (1/2)
Page 177
S-301 SCHEMATIC DIAGRAMS (21/50) SIGNAL LINE SCHEMATIC DIAGRAMS (21/50) 1U-3693 USB UNIT (2/2)
Page 178
S-301 SCHEMATIC DIAGRAMS (22/50) SIGNAL LINE SCHEMATIC DIAGRAMS (22/50) 1U-3694 AUDIO UNIT (1/5) (E3 model only)
Page 179
S-301 SCHEMATIC DIAGRAMS (23/50) SIGNAL LINE SCHEMATIC DIAGRAMS (23/50) 1U-3694 AUDIO UNIT (1/5) (E2 model only)
Page 180
S-301 SCHEMATIC DIAGRAMS (24/50) SIGNAL LINE SCHEMATIC DIAGRAMS (24/50) 1U-3694 AUDIO UNIT (1/5) (JP model only)
Page 181
S-301 SCHEMATIC DIAGRAMS (25/50) SIGNAL LINE SCHEMATIC DIAGRAMS (25/50) 1U-3694 AUDIO UNIT (2/5)
Page 182
S-301 SCHEMATIC DIAGRAMS (26/50) SIGNAL LINE SCHEMATIC DIAGRAMS (26/50) 1U-3694 AUDIO UNIT (3/5) (E3 model only)
Page 183
S-301 SCHEMATIC DIAGRAMS (27/50) SIGNAL LINE SCHEMATIC DIAGRAMS (27/50) 1U-3694 AUDIO UNIT (3/5) (E2 model only)
Page 184
S-301 SCHEMATIC DIAGRAMS (28/50) SIGNAL LINE SCHEMATIC DIAGRAMS (28/50) 1U-3694 AUDIO UNIT (3/5) (JP model only)
Page 185
S-301 SCHEMATIC DIAGRAMS (29/50) SIGNAL LINE SCHEMATIC DIAGRAMS (29/50) 1U-3694 AUDIO UNIT (4/5) (E3 model only)
Page 186
S-301 SCHEMATIC DIAGRAMS (30/50) SIGNAL LINE SCHEMATIC DIAGRAMS (30/50) 1U-3694 AUDIO UNIT (4/5) (E2 model only)
Page 187
S-301 SCHEMATIC DIAGRAMS (31/50) SIGNAL LINE SCHEMATIC DIAGRAMS (31/50) 1U-3694 AUDIO UNIT (4/5) (JP model only)
Page 188
S-301 SCHEMATIC DIAGRAMS (32/50) SIGNAL LINE SCHEMATIC DIAGRAMS (32/50) 1U-3694 AUDIO UNIT (5/5)
Page 189
S-301 SCHEMATIC DIAGRAMS (33/50) SCHEMATIC DIAGRAMS (33/50) 1U-3695-3 CONVERT UNIT (1/2) (E3 model only)
Page 190
S-301 SCHEMATIC DIAGRAMS (34/50) SCHEMATIC DIAGRAMS (34/50) 1U-3695-3 CONVERT UNIT (1/2) (E2 model only)
Page 191
S-301 SCHEMATIC DIAGRAMS (35/50) SCHEMATIC DIAGRAMS (35/50) 1U-3695-3 CONVERT UNIT (1/2) (JP model only)
Page 192
S-301 SCHEMATIC DIAGRAMS (36/50) SIGNAL LINE SCHEMATIC DIAGRAMS (36/50) 1U-3695-3 CONVERT UNIT (2/2) (E3 model only)
Page 193
S-301 SCHEMATIC DIAGRAMS (37/50) SIGNAL LINE SCHEMATIC DIAGRAMS (37/50) 1U-3695-3 CONVERT UNIT (2/2) (E2 model only)
Page 194
S-301 SCHEMATIC DIAGRAMS (38/50) SIGNAL LINE SCHEMATIC DIAGRAMS (38/50) 1U-3695-3 CONVERT UNIT (2/2) (JP model only)
Page 195
S-301 SCHEMATIC DIAGRAMS (39/50) SIGNAL LINE SCHEMATIC DIAGRAMS (39/50) 1U-3695-1 LOCAL POWER UNIT (E3 model only)
Page 196
S-301 SCHEMATIC DIAGRAMS (40/50) SIGNAL LINE SCHEMATIC DIAGRAMS (40/50) 1U-3695-1 LOCAL POWER UNIT (E2 model only)
Page 197
S-301 SCHEMATIC DIAGRAMS (41/50) SIGNAL LINE SCHEMATIC DIAGRAMS (41/50) 1U-3695-1 LOCAL POWER UNIT (JP model only)
Page 198
S-301 SCHEMATIC DIAGRAMS (42/50) SIGNAL LINE SCHEMATIC DIAGRAMS (42/50) 1U-3695-2 I/F BOARD UNIT...
Page 199
S-301 SCHEMATIC DIAGRAMS (43/50 ) SIGNAL LINE SCHEMATIC DIAGRAMS (43/50) 1U-3681-1 DISPLAY CENTER UNIT 1U-3681-2 DISPLAY RIGHT UNIT 1U-3681-3 DISPLAY LEFT1 UNIT 1U-3681-4 DISPLAY LEFT2 UNIT 1U-3681-5 DISPLAY H/P OUT UNIT 1U-3681-8 DISPLAY AUX UNIT...
Page 200
S-301 SCHEMATIC DIAGRAMS (44/50) SIGNAL LINE SCHEMATIC DIAGRAMS (44/50) 1U-3681-11 iPOD in UNIT...
Page 201
S-301 SCHEMATIC DIAGRAMS (45/50) SCHEMATIC DIAGRAMS (45/50) 1U-3682-1 SMPS UNIT (E3 model only)
Page 202
S-301 SCHEMATIC DIAGRAMS (46/50) SCHEMATIC DIAGRAMS (46/50) 1U-3682-1 SMPS UNIT (E2 model only)
Page 203
S-301 SCHEMATIC DIAGRAMS (47/50) SCHEMATIC DIAGRAMS (47/50) 1U-3682-1 SMPS UNIT (JP model only)
Page 204
S-301 SCHEMATIC DIAGRAMS (48/50) SIGNAL LINE SCHEMATIC DIAGRAMS (48/50) 1U-3683A-2 IN/OUT UNIT 1U-3683A-3 TERMINAL UNIT...
Page 205
S-301 SCHEMATIC DIAGRAMS (49/50) SIGNAL LINE SCHEMATIC DIAGRAMS (49/50) 1U-3683A-1 AMP UNIT (1/2)
Page 206
S-301 SCHEMATIC DIAGRAMS (50/50) SIGNAL LINE SCHEMATIC DIAGRAMS (50/50) 1U-3683A-1 AMP UNIT (2/2)
Page 207
S-301 DOCUMENTS FOR WEEE Details of Recycle Parts * You have to remove the parts that marked “WEEE Mark ◆ ” when the recycling processing. (Europe model only) Recycle Parts for ADV-S301 WEEE Ref. No. Part Name Material Q'ty Mark...
Page 208
S-301 WEEE Ref. No. Part Name Material Q'ty Mark EMI G.(SHSG015100) Complex EARTH SHEET Aluminum tape SUPPORT SHEET EARTH PLATE (FRONT) STEEL EARTH PLATE (REAR) STEEL SPACER AUX EARTH PLATE STEEL 15P FFC CABLE Complex 17P FFC CABLE Complex 21P FFC CABLE...
Page 209
S-301 WEEE Ref. No. Part Name Material Q'ty Mark FERRITE CORE Complex EARTH BRACKET STEEL POWER TRANS Complex POWER TRANS Complex CE68W2G331M35(KMM) Complex ◆ FERRITE CRAMP081610N Complex 4P EH-EH CON.CORD Complex 7P EH-EH CON.CORD Complex 10P EH-EH CON.CORD Complex 4P VH-VH CON.CORD Complex 2P VH CON.CORD...
Page 210
S-301 Exploded view of ADV-S301 You have to remove the parts that marked "WEEE mark " when the recycling processing. (Europe model only) E2 only...
Page 211
S-301 Exploded view of DSW-S301 You have to remove the parts that marked "WEEE mark " when the recycling processing. (Europe model only)
Page 212
S-301 Exploded view of SC-S301 You have to remove the parts that marked "WEEE mark " when the recycling processing. (Europe model only) for Lch for Rch for Lch for Lch for Rch for Rch...
Page 213
S-301 Details of Recycle parts for Power transformer Part No.38 : POWER TRANS Material STEEL STEEL COPPER WIRE COPPER WIRE COPPER COPPER Part No.39 : POWER TRANS Material STEEL COPPER COPPER COPPER...