Introduction; Safety - Toro 07213 Operator's Manual

Change Front Differential Oil
Cleaning Hydraulic Strainer
Adjusting Brake Pedal . . . . . . . . . . . . . . . . . . . . .
Adjusting Clutch Pedal . . . . . . . . . . . . . . . . . . . . .
Adjusting Parking Brake
Adjusting Shift Cables . . . . . . . . . . . . . . . . . . . . .
Adjusting High-low Cable
Adjusting Differential Lock Cable
Inspect Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspect Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Wheel Toe-in . . . . . . . . . . . . . . . . . . . . . . .
Inspect Constant Velocity Boot
Emergency Box Raising
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting Procedure
Battery Storage . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Schematics . . . . . . . . . . . . . . . . . . . . . .
Electrical Schematics . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty

Introduction

Read this manual carefully to learn how to operate and
maintain your product properly. The information in this
manual can help you and others avoid injury and product
damage. Although Toro designs and produces safe
products, you are responsible for operating the product
properly and safely.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Toro
Distributor or Toro Customer Service and have the model
and serial numbers of your product ready. These numbers
are stamped into a plate located on the right frame member
under dash.
Write the product model and serial numbers in the space
below:
Model No:
Serial No.
This manual identifies potential hazards and has special
safety messages that help you and others avoid personal
injury and even death. Danger, Warning, and Caution are
signal words used to identify the level of hazard. However,
regardless of the hazard, be extremely careful.
Danger signals an extreme hazard that will cause serious
injury or death if you do not follow the recommended
precautions.
. . . . . . . . . . . . . . . . 49
. . . . . . . . . . . . . . . . . 50
50
51
. . . . . . . . . . . . . . . . . . . 51
52
. . . . . . . . . . . . . . . . . . 52
. . . . . . . . . . . . 52
52
52
52
. . . . . . . . . . . . . . 53
. . . . . . . . . . . . . . . . . . . . 53
53
. . . . . . . . . . . . . . . . . . . 53
54
54
55
57
. . 60
Warning signals a hazard that may cause serious injury or
death if you do not follow the recommended precautions.
Caution signals a hazard that may cause minor or moderate
injury if you do not follow the recommended precautions.
This manual uses two other words to highlight information.
Important
calls attention to special mechanical
information and Note: emphasizes general information
worthy of special attention.

Safety

The TORO WORKMAN
ANSI B56.8a-1994.
Supervisors, operators and service persons should be
familiar with the following standards and publications:
(The material may be obtained from the address shown).
Flammable and Combustible Liquids Code:
ANSI/NFPA 30
National Fire Protection Association:
ANSI/NFPA #505; Powered Industrial Trucks
ADDRESS:
National Fire Prevention Association
Barrymarch Park
Quincy, Massachusetts 02269 U.S.A
ANSI/ASME B56.8 Personal Burden Carriers
ADDRESS:
American National Standards Institute, Inc.
1430 Broadway
New York, New York 10018 U.S.A.
ANSI/UL 558; Internal Combustion Engine Powered
Industrial Trucks
ADDRESS:
American National Standards Institute, Inc.
1430 Broadway
New York, New York 10018 U.S.A.
OR
Underwriters Laboratories
333 Pfingsten Road
Northbrook, Illinois 60062 U.S.A.
3
meets the requirements of