Table of Contents
Advertisement
The electrolyte should be between
lower and upper marks. If level is low,
remove battery from vehicle to add
distilled water.
Battery
Removal
Disconnect negative BLACK cable first
then positive cable.
WARNING
Always respect this order for dis-
assembly; disconnect BLACK neg-
ative cable first. Electrolyte or fuel
vapors can be present in engine
compartment and a spark may ig-
nite them and possibly cause per-
sonal injuries.
Remove the holding straps.
Pull out vent tube from frame.
Remove battery from vehicle being
careful not to tilt it so that electrolyte
flows out of vent tube.
WARNING
Electrolyte is poisonous and dan-
gerous. Avoid contact with eyes,
skin and clothing. Wear protective
eyeglasses and a suitable pair of
non-absorbent gloves when re-
moving the battery by hand.
CAUTION: Should any electrolyte
spillage occur, immediately wash
off with a solution of baking soda
and water.
Refilling
Place battery on a level surface.
Unscrew caps and add distilled water
up to upper mark as required. Do not
overfill.
V01G03Y
1. Upper mark
Properly retighten caps.
Installation
Reinstall battery in vehicle. Fasten bat-
tery and make sure to reinstall the
vent tube.
WARNING
Connect positive RED cable first
then negative cable. Always con-
nect RED positive cable first.
NOTE: Place the positive RED cable
between holding straps and battery.
1
V01G05Y
1. Cable between battery and strap
1
45
Hide quick links:
Advertisement
Table of Contents
