Step 3: Unpacking, Moving And Placing The Range - Thermador PRSG304 Installation Instructions Manual

STEP 3: UNPACKING, MOVING AND PLACING THE RANGE

CAUTION:
Proper equipment and
adequate manpower must
be used in moving the range
to avoid damage to the unit
or the floor. The unit is
heavy and rests on adjust-
able steel legs.
• The range has an approximate
shipping weight as shown in
Chart A. It is recommended that
the door(s), grates, burner caps,
front kick panel and oven racks be
removed to facilitate handling.
This will reduce the weight as
shown in Chart A and allow the
range to pass through 30" door-
ways. See Chart B and Fig. 2a and
2b. Do not remove the grill or
griddle assemblies.
• Remove the outer carton and
packing material from the ship-
ping base. Remove the front kick
panel (see Fig. 4) by removing two
screws at the top and pulling
forward. The dual-fuel ranges are
held to the skid by four bolts, the
front two are behind the kick
panel (see Fig. 4) and the rear two
are located on the bottom flange
of the range back (see Fig. 5a).
The all gas ranges are held in
place by 3 bolts, two as shown in
Fig. 4 and one at the rear as
shown in Fig. 5b. After removing
the bolts the range must be lifted
and removed from the skid.
• To remove the door, open the
door to the fully open position.
Close the hinge latches (See Fig.
6) by rotating towards the oven.
The door can then be removed by
gently lifting and pulling the door,
with the hinges up and out of the
frame. Do not lift the range by
the door handle(s).
Chart A
Shipping Weight
Weight without
packing materials
After removing door(s), 215 lbs.
burner caps, front kick
panel and oven racks
Chart B
Doorway Width Required 28-7/8"
(Unit Assembled)
Doorway Width Required 27-3/4"
(Oven Door(s) Removed)
FIG. 4 All Ranges – Removal of
Kick Panel and Two Front
Shipping Screws
Front
Kick
Panel
FIG. 5b All-Gas Ranges –
Removal of Rear Shipping
Screw
Page 8
30" Range 36 " Range
335 lbs. 444 lbs.
285 lbs. 390 lbs.
295 lbs.
30" Range 36" Range
30-7/8"
29-1/2"
FIG. 5a Dual-Fuel Ranges –
Removal of Two Rear Shipping
Screws
Left Rear
Shipping
Screw
FIG. 6 All Ranges –
Door Removal
48" Range
584 lbs.
524 lbs.
395 lbs.
48" Range
30-7/8"
29-1/2"
➛
Hinge
Latch