Vermont Castings stardance 0004050 Owner's Manual page 10

Vent free
Table of Contents

Advertisement

Stardance® Vent-Free Gas Heater
2. Hold the burner at the right hand side and lift to clear
the right burner leg. Then pull to the right to clear the
injectors on the left hand side.
3. Turn burner upside down and remove air shutter.
Turn air shutter upside down and replace on burner.
(Fig. 11)
4. Replace burner. Slide the burner in at an angle
with left side lower than the right side. Slide the left
side onto the injectors, making sure the burner leg
remains at a 90° angle to the base. (Fig. 12) Lower
the right hand side down in to place. Make sure
the burner is as far left as possible and the injector
shoulders are inside the burner.
Air Shutter as Shipped from Factory
Air Shutter Turned Upside Down
Fig. 11 Remove air shutter, turn upside down and replace.
90°
Fig. 12 Be sure injector orifices remain at 90° to the base.
5. Replace rear, left and right log bracket assembly and
replace logs.
ST353a
injector orifice
replace
3/21/00
10
Bottom of Burner Pan
Left Burner Leg
ST667
RNVOD
Injector Orifices
air shutter
converting
from NG to Lp
6/4/01 djt
djt
6. Slide the catalyst through the grille opening. Set
catalyst on top of firebox. Secure with two (2) screws
and washers. (Fig. 13)
7. Shoulder bolts provided in catalyst kit must be in-
stalled on top of firebox. Use nut to secure in place.
(Fig. 13)
8. Install glass frame assembly by resting the bottom
edge of the frame on support brackets below the
front opening of the firebox. Rotate the top edge of
the assembly toward the firebox, and center it. Fas-
ten by "rotating" the cams over the top left and right
edges of the frame. (Fig. 14)
Shoulder
Bolts
NOTE: Shown with top
removed for clarification.
Fig. 13 Install shoulder bolts and set catalytic combustor in
place.
ST667
NOTE: Shown with top
removed for clarification.
Fig. 14 Rotate cams into place to hold glass frame assembly
in place.
ST353a
Catalytic Combustor
ST709
UVS pin
top install
1/29/02 djt
ST709
ST711
30005057

Hide quick links:

Advertisement

Table of Contents
loading

This manual is also suitable for:

Stardance0004051

Table of Contents