Vermont Castings 0004050 Installation & Operating Manual
Stardance vent free gas heater
Hide thumbs
Also See for 0004050:
- Homeowner's installation and operating manual (28 pages) ,
- Owner's manual (24 pages)
Table of Contents
Advertisement
Quick Links
Installation & Operating Manual
Installation and Appliance Setup - Care and Operation
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Call your dealer for questions on Installation, Operation, or Service.
NOTICE: SAVE THESE INSTRUCTIONS
Stardance
Vent Free Gas Heater
®
Models: 0004050, 0004051
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
1
Vermont Castings • Stardance VF Installation Manual_R12 • 01/17
INSTALLER / CONSUMER
SAFETY INFORMATION
Please read this manual before installing and using
appliance.
WARNING: If the information in this manual is not followed
exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
—Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
—WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
This appliance may be installed in an aftermarket*
permanently located manufactured (mobile) home where
not prohibited by local codes.
This appliance is only for use with the type of gas indicated
on the rating plate.
This appliance is not convertible for use with other gases
unless a certified kit is used.
*Aftermarket: Completion of sale, not for purpose of resale,
from the manufacturer.
This is an unvented gas-fired heater. It uses air (Oxygen)
from the room in which it is installed. Provisions for
adequate combustion and ventilation air must be provided.
Refer to the Fresh Air Requirements section for further
information.
3-90-30005057
Advertisement
Table of Contents
Related Manuals for Vermont Castings 0004050
Summary of Contents for Vermont Castings 0004050
- Page 1 Provisions for adequate combustion and ventilation air must be provided. CONSUMER: Retain this manual for future reference. Refer to the Fresh Air Requirements section for further information. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057...
-
Page 2: Table Of Contents
Stardance® Vent-Free Gas Heater PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE. Thank you and congratulations on your purchase of a Vermont Castings stove. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. -
Page 3: Important Safety Information
105°F temperature rating. • in windy or drafty areas. 7. DO NOT place clothing or other flammable material on or near the appliance. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 4: Stove Dimensions
Valve Inlet 26³⁄₄" (680 mm) Valve Inlet 3" (76 mm) 14¹⁄₂" 25¹⁄₂" (368 mm) (648 mm) 15⁵⁄₈" (379 mm) Figure 1 - Stardance freestanding shell dimensions. 5004 UVS27 Freestanding specs 1/02 Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 5: Clearance Requirements
9-3/8” (241mm) 25” (635mm) 7-1/2” (191mm) 20” (508mm) FP599a 5-3/4” (146mm) 15” (381mm) stove mantel heights 9/27/99 djt 4” (102mm) 10” (254mm) 2-1/4” (57mm) 5” (127mm) 1” (25mm) 2” (51mm) Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 6: Gas Specifications
Cleaning solutions, paint, solvents, cigarette smoke, The installation of your Vermont Castings stove must conform candles, adhesives, new carpet or textiles, etc., all can create with local codes, or in the absence of local codes, with the fumes. -
Page 7: Vent Free Features
This heater must have fresh air for proper operation. If not, poor fuel combustion could result. Read the following instructions to insure proper fresh air for this and other fuel-burning appliances in your home. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 8: Assembly Procedures Unpack The Stove
Figure 3 - Correct position of fan skirt installation. diagrams, or failure to use only parts specifically ST345a approved with this heater may result in property damage pinnacle or personal injury. fan in place 12/18/03 Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 9: Install On/Off Switch
1. Install the wall thermostat in the desired location and run the wires to the stove location. Terminate these leads with 1/4” female connectors. 2. Connect the thermostat wires to the valve. (Figure 9) Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 10: Connect The Gas Supply Line
2. Install the rear log by placing it on the sheet metal shelf at the back of the firebox. (Figure 15) The log should touch the back wall of the firebox and be centered. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... - Page 11 1/30/02 djt Grille Screen Levelling Screws Figure 11 - Stardance logs in place. Figure 13 - Install the Top Plate and Grille. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 ST114a 3-90-30005057 top install 12/18/03 djt LG224...
-
Page 12: Operation Your First Fire
‘HI/LO’ adjustment knob located near the center of the gas control valve. (Figure 15) Figure 17 - Correct burner flame pattern. LG224 UVS27 logs in place 1/30/02 djt Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 13: Lighting Instructions
4. Push in gas control knob slightly and turn clockwise 2. Turn off all electric power to the fireplace if service is to “OFF”. Do not force. to be performed. 5. Close control access panel. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 14: Troubleshooting
Call local gas supplier. Adjust inlet supply correct settings. pressure to specification: NG; 5.5” w.c.- 14.0”w.c. LP; 11.0” w.c.-14.0”w.c. F. Other conditions that should be Call qualified gas technician. identified only by a qualified gas technician Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... - Page 15 Open a window or provide additional ventilation. (See Fresh Air Requirements) B. Incorrect inlet supply pressure. Call local gas supplier. Adjust inlet supply pressure to specification: NG; 5.5” w.c.-14.0”w.c. LP; 11.0” w.c.- 14.0”w.c. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057...
-
Page 16: Maintenance
Replace damaged glass or bi-weekly. only with an approved Vermont Castings Group ceramic glass panel. Follow the Cleaning Procedure instructions regarding This appliance should be inspected and thoroughly parts removal. -
Page 17: Replacement Parts
2a,b 7, 8 16a,b,c,d 14a,b Vermont Castings Group reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. 5057 Stardance VF parts Vermont Castings • Stardance VF Installation Manual_R12 • 01/17... -
Page 18: Optional Accessories
Then, you position the shelf and adjust the brackets so the shelf fits correctly. Finally, you tighten the screws. Refer to the instructions included with each warming shelf for complete installation procedures. Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057... -
Page 19: Warranty
LIMITED LIFETIME WARRANTY PRODUCT COVERED BY THIS WARRANTY All Vermont Castings gas stoves, gas inserts, and gas fireplaces equipped with an Insta-Flame Ceramic Burner, or standard steel tube burner. BASIC WARRANTY Vermont Castings Group (hereinafter referred to collectively as the •... - Page 20 352 Mountain House Road • Halifax, PA 17032 www.vermontcastings.com Vermont Castings • Stardance VF Installation Manual_R12 • 01/17 3-90-30005057...