Operation; Important Safety Instructions; Model Descriptions - Hatco TQ-10 series Operating Instructions Manual

IMPORTANT SAFETY INSTRUCTIONS

WARNINGS
Allow a minimum of 25 mm (1") clearance along
the sides. Allow a clearance of 305 mm (12") along the front
and rear discharge to ensure proper operation and safety.
To prevent any injury or damage do not pull unit
by power cord.
To prevent any injury, discontinue use if power cord
is frayed or worn.
This appliance is not of jet-proof construction. Do not use
jet-clean-spray to clean this appliance.
If service is required on this unit, contact your Authorized
Hatco Service Agent, or contact the Hatco Service
Department at 800-558-0607 or 414-671-6350;
fax 800-690-2966 or International fax 414-671-3976.
This product has no "user" serviceable parts. To avoid
damage to the unit or injury to personnel, use only
Authorized Hatco Service Agents and Genuine Hatco Parts
when service is required.
Genuine Hatco Replacement Parts are specified to operate
safely in the environments in which they are used. Some
aftermarket or generic replacement parts do not have
the characteristics that will allow them to operate safely
in Hatco equipment. It is essential to use Hatco Replacement
Parts when repairing Hatco equipment. Failure to use Hatco
Replacement Parts may subject operators of the equipment
to hazardous electrical voltage, resulting in electrical
shock or burn.

MODEL DESCRIPTIONS

ALL MODELS
All Toast-Qwik Electric Conveyor Toasters are fast, reliable
and versatile, toasting 300 to 1200 slices of bread product per hour
depending on the specific model. The front or rear discharge lets
the operator place Toast-Qwik toaster where it is most convenient.
Every Toast-Qwik toaster includes a toast collector pan, toast feed
ramp, removable crumb tray and factory attached 1829 mm (6')
cord and plug.
TQ-10 MODEL
The TQ-10 model allows for toasting of bread products up
to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide. Capacity
is up to 300 slices per hour for bread or bun products. The TQ-10
comes equipped with 102 mm (4") adjustable legs.
TQ-15 MODEL
The TQ-15 model allows for toasting of moist or dense bread
products up to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide.
Capacity is up to 240 slices per hour for bread or bun products.
The TQ-15 comes equipped with 102 mm (4") adjustable legs
POWER SAVE MODE WITH INDICATOR
LIGHT
All TQ-400, TQ-800 and TQ-1200 series toasters have a Power
Save mode. During the Power Save mode the indicator light
on the control panel will flash. While the light is flashing the toaster
is operating at 50% power. Full power can be restored within
5 minutes by pushing any button or adjusting any control knob.
COLORGUARD SYSTEM
All TQ-400, TQ-800 and TQ-1200 series toasters use a patented
ColorGuard Sensing System that monitors and automatically adjusts
conveyor speed during high usage periods to assure toast
.
color uniformity
Form No. TQ2CEM-0903
Some exterior surfaces on the unit will get hot. Use caution
when touching these areas to avoid injury.
To avoid damage to the unit or injury to personnel always
operate toaster with crumb tray installed.
To avoid any injury, do not remove the crumb tray
for cleaning until toaster is cool.
Unit is not weatherproof. For safe and proper operation
the unit must be located indoors where the ambient air
temperature is a minimum of 70°F (21°C) and a maximum
of 85°F (29°C).
Do not locate the toaster in an area subject to excessive
temperatures or grease from grills, fryers, etc. Excessive
temperatures could cause damage to the unit. Do not place
toaster in an area that restricts air flow around the front
or rear of the unit. Do not place toaster in direct discharge
path of air conditioning vent or makeup air vent.
Use only non-abrasive cleaners. Abrasive cleaners could
scratch the finish of your Toast-Qwik toaster marring its
appearance and making it susceptible to soil accumulation.
TQ-400 MODEL
The TQ-400 model allows for toasting of bread products
up to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide. Capacity
is up to 350 slices per hour for bread or bun products.
TQ-405 MODEL
The TQ-405 model allows for toasting of moist or dense bread
products up to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide.
Capacity is up to 240 slices per hour for bread or bun products.
TQ-400BA MODEL
The TQ-400BA model allows for quick single-sided toasting
of sliced bagels or bun products up to 38 mm (1-1/2") thick
and 245 mm (9-5/8") wide. Most products can be toasted in as little
as 45 seconds. Capacity is up to 400 bagel halves per hour. Toasts
cut side facing up.
TQ-800 MODEL
The TQ-800 model allows for toasting of bread products up
.
to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide. Capacity
is up to 800 slices per hour for bread or bun products.
TQ-805 MODEL
The TQ-805 model allows for toasting of moist or dense bread
products up to 38 mm (1-1/2") thick and 245 mm (9-5/8") wide.
Capacity is up to 550 slices per hour for bread or bun products.
TQ-800H MODEL
The TQ-800H model has a 76 mm (3") wide opening allowing
for toasting of bread products up to 70 mm (2-3/4") thick
and 245 mm (9-5/8") wide. Capacity is up to 800 slices per hour
for bread or bun products.
5
CAUTIONS
CAUTIONS