Related Manuals for Ramblewood Green GC2-48N
Summary of Contents for Ramblewood Green GC2-48N
-
Page 1: User Guide
User Guide Gas Cooktop MODEL: GC2-48N GC2-48P GC1-28N GC1-28P GC2-43P GC2-43N GC2-43PB (Battery Ignition) -
Page 2: Important Safety Instructions
YOUR SAFETY AND THE SAFETY OF OTHERS ARE VERY IMPORTATNT. BEFORE USE, PLEASE READ AND FOLLOW ALL SAFETY RULES AND OPERATING INSTRUCTIONS. AND SAVE FOR LOCAL GAS AND ELECTRICAL INSPECTOR’S USE. WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. - Page 3 This cooktop is equipped with a three-prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded receptacle. Do not cut of remove the grounding prong from this plug. Disconnect the electrical supply before servicing the cooktop. ...
-
Page 4: Installation
INSTALLATION Installation and service must be conducted by qualified / licensed technician, in accordance with national & local regulation. Failure to comply will void the product warranty. Always disconnect the appliance power before installation & maintenance. These cooktops are designed to be dropped into counter top measuring >24 inches in depth. - Page 5 INSTALLATION IN KITCHEN CABINET WITH DOOR (Fig.2) It is recommended that a 30 mm clearance be left between the cooker top and the fixture surface (Fig.2). Note: The adjacent furniture and all materials used in installation must be able to withstand a minimum of 85°C above the ambient temperature.
- Page 6 kitchen furniture are particularly prone to heat damage or discoloration at temperatures below 85°C. DISCHARGING PRODUCTS OF COMBUSTION Extractor hoods connected directly to the outside should be provided, to allow the products of combustion of the cooktop to be discharged (fig.3), (fig.4).
- Page 7 Position the cooktop in the recess and secure by means of the brackets as shown in fig.6 (for 3 or 4 cm thick work top). BUILT-IN DIMENSION MODEL CUT OUT DIMEN- SION (Inch) GC2-48N 10.5"x18.9" (WxD) GC2-48P 10.5"x18.9" (WxD) GC1-28N 10.5"x18.9" (WxD) GC1-28P 10.5"x18.9"...
-
Page 8: Connect The Cooktop To Gas
CONNECT THE COOKTOP TO GAS Shut off the main gas supply valve before disconnecting the old cooktop and leave it off until the new hook-up has been completed. Don’t forget to relight the pilot on other gas appliances when you turn the gas back on. Never use an old connector when installing a new cooktop. - Page 9 ADAPTING THE COOKTOP FOR DIFFERENT TYPES OF GAS To adapt the cooktop to a different type of gas than th at for which it was designed, (see the sticker under the hob or on the package), the burner nozzles must be changed, as follows: Remove the pan supports and slide the burners out of the cooktop.
- Page 10 Turn the knob to minimum level The adjustment screw is located in the center of the shaft (fig.9). Please remove/pull out the control knob to access it. Using a screwdriver with max. Diameter 3 mm, turn the screw inside the tap until the ...
- Page 11 piping. When using test pressure of 1/2 psig or less to test the gas supply system, simply isolate the cooktop from the gas supply system by closing the individual shut-off valve. ELECTRICAL CONNECTION (certain models) 120volt, 60 Hertz, properly grounded dedicated circuit protected by a 15-amp or 20-amp circuit breaker or time-delay fuse.
-
Page 12: Installing The Battery
DO NOT, UNDER ANY CIRCUMSTANCES, CUT OR REMOVE THE THIRD (GROUND) PRONG FROM THIS POER CORD. Temporary Method (Adapter plugs not permitted Canada) CAUTION: Attaching adapter ground terminal to the wall receptacle cover screw does not ground the appliance unless the cover screw is metal, not insulated, and the wall receptacle is grounded through the house wiring. -
Page 14: How To Use The Cooktop
HOW TO USE THE COOKTOP GAS BURNERS Gas flow to the burners is adjusted by turning the knobs which control the valves. Turning the knob so that the indicator line points to the symbols printed on the panel achieves the following functions: When knob is rotated to the maximum position it will permit the rapid boiling of liquids, ... - Page 15 diameters of the burners. Avoid having flames extending out from underneath the pans (refer to the table). A smaller diameter pot or pan placed on a larger burner does not necessarily mean that the boiling conditions are reach quicker. Table of recommended pans Burner Ø...
-
Page 16: Cleaning And Maintenance
Cleaning and Maintenance Cleaning IMPORTANT: Before any operation of cleaning and maintenance disconnect the appliance from the electrical supply. It’s advisable to clean when the appliance is cold and especially for cleaning the enameled parts. Avoid leaving alkaline or acidic substances (lemon juice, vinegar, etc.) on the surfaces. ... - Page 17 TRIPLE RING BURNER The triple ring burner must be correctly positioned (seen fig.7); the burner rib must be entering in their ligament as shown by the arrow. The burner correctly positioned must not be able to rotate (fig.8). Then position the cap A and the ring B (fig.8).
- Page 18 PROBLEM DEBUG It may occur that the cooktop does not function or does not function properly. Before calling customer service for assistance, let’s see what can be done. First of all, check to see that there are no interruptions in the gas and electrical supplies, and, in particular, that the gas valves for the mains are open.
-
Page 19: Product Features
INSTRUCTION FOR GAS REGULATOR 1. Product Features: This product is a low-pressure pipeline regulator valve, built-in regulator for gas products THIS REGULATOR IS SET TO Natural Gas (NG) USE. If user wants to set to LIQUEFIED PETROLEUM GAS (LPG) use, it needs to be set manually, detail see below instruction. - Page 20 Under all circumstances please have licensed plumber / technician to support the installation If you find an abnormality of the regulator valve, stop use it and contact your dealer. Do not attempt to modify this pressure regulator without consensus from Ramblewood Green. Contact in America Ramblewood Green Email:sales@ramblewoodhk.com...