Club Car Precedent Stretch Owner's Manual page 18

Controls and Indicators – Electric Vehicles
WARNING
• The park brake will release automatically when either the accelerator or brake pedal is pressed. The
park brake has multiple locking positions and should be firmly pressed and locked to prevent the
vehicle from rolling.
BATTERY WARNING LIGHT
Precedent electric vehicles feature a dash-mounted warning light (3) that, when the vehicle is in operation, indicates
low battery voltage or, when the vehicle is being charged, indicates a charging problem (Figure 6). The battery
warning light is controlled by the onboard computer.
When the vehicle is in operation, the warning light is controlled by the onboard computer.
• Batteries' voltage drops below 48 volts when there is no load on the batteries (the vehicle is stopped and there
are no accessories on).
• Batteries have discharged to less than 25% of rated capacity.
If the warning light illuminates when the vehicle is operating, there will be enough power remaining to drive the vehicle
for approximately 30 minutes. However, the vehicle should be charged at the first opportunity. If the warning light
illuminates and the vehicle is unable to operate for 30 minutes, have your Club Car distributor/dealer check the
vehicle for a possible battery or electrical system problem.
When the batteries receive an incomplete charge because 1) the DC power cord is disconnected, 2) AC power to the
charger is interrupted, 3) automatic charger shut-off occurs after 16 hours of operation, 4) the charger malfunctions,
or 5) the wrong charger is used, the warning light will indicate as follows:
• The warning light will not illuminate if the charge is 90% or more complete. The onboard computer will retain in
memory the amount of charge needed to fully replenish the batteries and will complete the charge during the
next charge cycle.
• When the charger is unplugged, the warning light will illuminate and remain illuminated for 10 seconds if the charge
is less than 90% complete but the vehicle has enough power for approximately 30 minutes of operation. This will
alert the operator that the vehicle may be used, but that it must be charged to completion as soon as possible.
• The warning light will repeatedly illuminate for 10 seconds, with 4 second intervals if the charger times out at 16
hours and the batteries are not sufficiently charged. This indicates an abnormal charge cycle. The charger and
batteries should be checked by your Club Car distributor/dealer.
• The warning light will repeatedly illuminate for 10 seconds, with 4 second intervals during a charge cycle (DC plug is
still connected) if AC power to the charger is interrupted. The light will go out when AC power is restored.
LED Light: In addition to the warning light, there is an infrared LED in the dash light assembly, which transmits an
infrared signal from the onboard computer (OBC). This signal is received by the optional Communication Display
Module, which provides information on the condition of the vehicle and batteries.
TOW/RUN SWITCH
WARNING
• Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to
heed this warning could result in a battery explosion or severe personal injury.
• When the Tow/Run switch is in the TOW position, all motor braking functions, including walk away
braking, are disabled.
Page 16 Precedent Stretch Owner's Manual