Titan Speeflo users. longest packing life. Titan pumps are proven performers for all types of jobs. There • Wiper seal on lower packings keeps abrasive materials are models for virtually any application, including architectural, from hardening on cylinder wall.
8. Fill the Wet-Cup 1/2 full with Titan’s Lubrisolv, supplied by the factory. This extends packing life. 9. Strain all paints with Titan’s 5 gallon Nylon strainer, Part No. 160-500 or 1 gallon Nylon strainer, Part No. 160- 100 to assure trouble-free operation and freedom from frequent cleaning of inlet screen and gun strainer.
Operation at very high cycle rates (i.e. greater than 60) will require a higher AirCare™ injection rate. IMPORTaNT: use only Titan aircare™ Part No. 311-011 lubricant. use of any detergent-type lubricants will cause a serious problem with the pump and void the warranty.
Store preorifice and tips in clean place. clogged material. 4. If the gun is equipped with a Titan TAC 5™ Assembly, see Technical Data Manual 150:99 for instructions. 5. Release the gun trigger lock and spray briefly into a waste container to flush out any clogged particles.
Air motors should be served with moisure free air and for this, an may contaminate the paint material and is not recommended. airline filter / moisture separator, such as Titan Part No. 141-057 is recommended. Very cold and humid air conditions combined...
The 742 Series Air Motor should be served with moisture-free O-ring (30). air. A water trap, Titan Part #141-057, is recommended. For use 10. Install new O-rings (14) on valve sleeve (13). Grease under very cold and humid conditions a moisture separator and valve sleeve and install into cylinder head (5) so large an automatic oiler may be necessary to avoid icing.
Page 19
140-556 Fluid Pump Service Information Service Kits IMPORTaNT: use of non-Titan manufactured service parts 140-052 Pump service kit, minor may void warranty. ITEM PaRT The 140 Series Pump should receive a routine servicing after DEScRIPTION QTy. approximately 1200 hours of use. A 140-052 Minor Pump Kit should be installed at this time.
Page 21
155-052 Packing set, leather on one stroke or another. The use of Titan Lubrisolv Part # 155-053 Packing set, leather/poly. 310-200 is recommended as an upper packing lubricant. DO...
Page 23
NOTE: It is not necessary to overtighten foot valve and on one stroke or another. The use of Titan Lubrisolv Part # cylinder into pump block. O-ring seals perform 310-200 is recommended as an upper packing lubricant.
Page 25
(16) leakage from the top packing, or if pump strokes become faster on one stroke or another. The use of Titan Lubrisolv Part # 310-200 is recommended as an upper packing lubricant. DO NOTE: It is not necessary to overtighten foot valve and NOT SUBSTITUTE oil, water or solvent for an upper packing cylinder into pump block.
Page 27
NOTE: Ball cage pin (12a) to be in lower position unless leakage from the top packing, or if pump strokes become faster pump is to be used for heavy block filler or on one stroke or another. The use of Titan Lubrisolv Part # roofing materials. 310-200 is recommended as an upper packing lubricant. DO NOT SUBSTITUTE oil, water or solvent for an upper packing 10.
Page 36
(3) with a socket screwdriver, then the valve stem can be threaded out of the valve body. IMPORTaNT: all non-moving threads must be assembled with Loctite sealant, Titan part # 426-051. 944-050 Bleed valve Service Kit ITEM...
Key accessories and Service Kits These items may be purchased separately from your local Titan distributor. Part No. Description 103-800 Siphon hose assembly with rock catcher 3/4” x 3’ 103-806 Siphon hose assembly with rock catcher 3/4” x 6’...
Titan Warranty for the commander™ airless Sprayers Titan Tool, Inc., (“Titan”) warrants that at the time of delivery to the original purchaser for use (“End User”), the equipment covered by this warranty is free from defects in material and workmanship. With the exception of any special, limited, or extended warranty published by Titan, Titan’s obligation under this warranty is limited to replacing or repairing without charge those parts which, to Titan’s...