Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Maxum 4600 SCB
Summary of Contents for Maxum 4600 SCB
-
Page 2: Hull Identification Number
This document discloses subject matter in which Maxum has proprietary rights. The information and design disclosed herein were originated by and are the property of Maxum. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therein, or to construct boats or any item from it, except by written permission from or written agreement with Maxum. - Page 3 Maxum Sport Yacht! your new Maxum Sport Yacht! Thank you for choosing our product. Maxum is committed to the goal of Thank you for choosing our product. Maxum is committed to the goal of building the highest quality products in the marine industry and to provid- building the highest quality products in the marine industry and to provid- ing the finest after-the-sale support in the world.
-
Page 4: Table Of Contents
CONTENTS Chapter 1: Welcome Aboard! Lighting 15 Navigation and Interior Lights Dealer Service 15 Spotlight Boating Experience Appliances Engines/Accessories Guidelines 16 TV/Telephone Dockside Inlet (Option) Vacuum System (Option) Qualified Maintenance Propulsion Structural Limitations 16 Engines Safety Standards 16 Exhaust System Hazard Boxes &... - Page 5 Chapter 3: Electrical Routings AC Wiring Shore Power/Generator Harnesses Positive Battery Cable Routing DC Engine Harness Battery Ground Cable Routing Negative Battery Cable Routing Battery Isolator System Wiring Chapter 4: Wiring Schematics AC Electrical System DC Electrical System Gas Engine Electrical System Diesel Engine Electrical System Appendix A: Express Limited Warranty...
-
Page 7: Chapter 1: Welcome Aboard
To maintain the integrity and safety of your yacht, only qualified personnel should perform maintenance on, or in any way modify: The steering system, propulsion system, engine control system, fuel system, environmental control system, electrical system or navigational system. 4600 SCB Owner’s Manual Supplement... -
Page 8: Structural Limitations
This box calls attention to installation, operation or maintenance information, which is impor- tant to proper operation but is not hazard related. EXPLOSION OPEN FLAME ELECTRICAL PERSONAL INJURY ROTATING HAZARD! HAZARD! HAZARD! HAZARD! & FALLING HAZARD! PROPELLER HAZARD! 4600 SCB Owner’s Manual Supplement... -
Page 9: Special Care For Moored Boats
2000E/2001E. The barrier coating should be covered with several coats of anti-fouling paint. • Many states regulate the chemical content of bottom paints in order to meet environmental standards. Check with your local dealer about recommended bottom paints, and about the laws in effect in your area. 4600 SCB Owner’s Manual Supplement... -
Page 10: Chapter 2: Components/Systems
• When lifting any boat ALWAYS use a spreader bar. The spreader bar must be equal to the width of the boat at the lifting point. • Lift slings may slip on the hull. Avoid serious injury or death by securing the slings together before lifting. 4600 SCB Owner’s Manual Supplement... -
Page 11: Hull Exterior Hardware & Drains
SHOWER THRU-HULL THRU-HULL SUMP DRAIN WASTE SIPHON THRU-HULL GALLEY TRANSOM STORAGE VENT SINK DRAIN DRAIN THRU-HULL THRU-HULL FORWARD BILGE PUMP DRAIN THRU-HULL TRANSOM VIEW BOARDING LADDER TRIM TAB (TYPICAL PORT & STARBOARD) SACRIFICIAL ANODE KEEL 4600 SCB Owner’s Manual Supplement... -
Page 12: Command Bridge Layout
DATA REPEATER VHF RADIO (TYPICAL) (TYPICAL) PANEL (OPTION) (OPTION) DOCKING COURTESY ANCHOR LIGHTS LIGHTS LIGHTS TRIM TAB BLOWER ACCESSORY WINDLASS (OPTION) SWITCHES SWITCHES SWITCH HORN BILGE PUMP BATTERY INSTRUMENT NAVIGATION SWITCHES PARALLEL LIGHTS LIGHTS SWITCH 4600 SCB Owner’s Manual Supplement... -
Page 13: Deck Hardware
• Use extreme caution when using the davit in rough weather or rough sea conditions as the load may start swinging. • Only operate the davit when it is securely locked in the upright position. 4600 SCB Owner’s Manual Supplement... -
Page 14: Deck Fill Fittings & Pump-Out Locations
• Minimize the danger of fire and explosion by not exposing batteries to open flame or sparks. It is also important that no one smoke anywhere near the batteries. 4600 SCB Owner’s Manual Supplement... -
Page 15: Dc Electrical System
The starboard engine/house battery switch must be ON to start the starboard engine. After starting your boat’s engines, the battery switches must be kept STBD. ON until the engines and/or optional generator is turned OFF. 4600 SCB Owner’s Manual Supplement... -
Page 16: Battery Charger
Warranty replacements will not be made on elements or tank damaged in this manner. The tank is full if water flows from the tap when the hot water is turned on in the galley. 4600 SCB Owner’s Manual Supplement... -
Page 17: Shore Power
Some dockside installations may be rated less than 30 amps, therefore, you may need to pur- chase lower amp adapters. Whenever a lower amp adapter is used, however, there will be a corresponding drop in supplied power from the dockside system. 4600 SCB Owner’s Manual Supplement... -
Page 18: Generator Power (Option)
• NEVER operate the generator starter for more than 30 seconds. If the generator does not start, wait at least 30 seconds before another start attempt is made. • After starting the generator, wait for the generator to stabilize before activating component breakers on the AC panel. 4600 SCB Owner’s Manual Supplement... - Page 19 GENERATOR SEACOCK FUEL FILTER & EXHAUST ROUTINGS SIPHON BREAK TO EXHAUST THRU-HULL GENERATOR DETAILED VIEW OF FUEL FILTER ROUTING FUEL SHUT-OFF VALVE FUEL FILTER EXHAUST FUEL HOSE RETURN EXHAUST MUFFLER TO GENERATOR STARBOARD TANK WITHDRAWAL 4600 SCB Owner’s Manual Supplement...
-
Page 20: Inverter Power (Option)
• When the boat is moving, submerged objects will not be seen until they are already under the boat. Bottom depths may change too quickly to allow time for the boat operator to react. If you suspect shallow water or submerged objects, operate the boat at very slow speeds. 4600 SCB Owner’s Manual Supplement... -
Page 21: Autopilot (Option)
During use and afterwards, DO NOT touch or let clothing or other flammable material come in contact with heated units (or areas near the units) until they have had suffi- cient time to cool. 4600 SCB Owner’s Manual Supplement... -
Page 22: Tv/Telephone Dockside Inlet (Option)
GAS ENGINE EXHAUST SYSTEM, TOP VIEW MUFFLER 4"D. EXHAUST HOSE (TYPICAL) T-FITTING EXHAUST THRU-HULL 5"D. X 45° FIBERGLASS PORT EXHAUST ELBOW ELBOW (TYPICAL) MUFFLER (TYPICAL) 90° ELBOW 5"D. EXHAUST EXHAUST HOSE (TYPICAL) THRU-HULL EXHAUST TUBE, 6"O.D. X 5" (TYPICAL) 4600 SCB Owner’s Manual Supplement... -
Page 23: Engine Cooling System
• DO NOT obstruct or modify the ventilation system. Shaft Log Packless Sealing System The shaft seal, which is part of the shaft log packless sealing system, is a maintenance-free, watertight seal that doesn’t require packing or adjustments. 4600 SCB Owner’s Manual Supplement... -
Page 24: Shaft-Transmission Alignment
6. Stagger the ends of each ring around the shaft and insure that the ring are at the bottom in the sleeve. 7. Tighten the packing gland nuts until resistance is felt. CAUTION! PRODUCT DAMAGE HAZARD! DO NOT over tighten the packing gland nuts. 4600 SCB Owner’s Manual Supplement... -
Page 25: Controls
SERVO SERVO SERVO 13 - STBD. SHIFTER SERVO TO RESERVOIR 14 - C/B STBD. SHIFTER TO RESERVOIR 15 - C/B STBD. SHIFTER TO L/H STBD. SHIFTER 16 - L/H STBD. SHIFTER TO STBD. SHIFTER SERVO 4600 SCB Owner’s Manual Supplement... -
Page 26: Trim Tabs
If no problems are found, check the bilge pump housing for clogging debris as follows: 4600 SCB Owner’s Manual Supplement... -
Page 27: Autofloat Switches
BILGE PUMP SHOULD TURN ON CAUTION! When test is completed on a float switch, you must push the test button all the way down to the auto position to turn the switch back into auto mode! 4600 SCB Owner’s Manual Supplement... -
Page 28: Fuel System
If STBD. FUEL TANK the valve is stuck or clogged, shut down the engine and replace it. Except in an emergency, NEVER operate the engines without the anti-siphon valve. 4600 SCB Owner’s Manual Supplement... -
Page 29: Fuel Management Board
FUEL SHUT-OFF VALVE FUEL SHUT-OFF VALVE FUEL SHUT-OFF VALVE FUEL SHUT-OFF VALVE FUEL FUEL FILTER FILTER PORT STBD. ENGINE ENGINE GEN. PORT STBD. FUEL SHUT-OFF VALVE GEN. ENGINE ENGINE FUEL FUEL FILTER FILTER FUEL SHUT-OFF VALVE 4600 SCB Owner’s Manual Supplement... -
Page 30: Fuel Transfer Pump (Diesel Only)
FRESHWATER ACCUMULATOR FRESHWATER TANK TANK TANK an even flow of water. PORT TOILET (VACUFLUSH OPTION) STARBOARD TOILET (VACUFLUSH OPTION) STARBOARD HEAD SINK FRESHWATER SYSTEM STARBOARD ROUTING - FORWARD HEAD SHOWER 4600 SCB Owner’s Manual Supplement... -
Page 31: Water Heater
RELIEF VALVE replaced. After replacing the pressure relief valve, empty all of the water from the hose before storing your yacht. 2. Reconnect the hose to the water heater. 4600 SCB Owner’s Manual Supplement... -
Page 32: Transom Shower
Engine, generator and optional air conditioning system. Raw water strainers are located near raw water intake valves (seacocks) and should be checked every time you use your yacht for leaks/or debris. If debris is found, clean the strainer as follows: 4600 SCB Owner’s Manual Supplement... -
Page 33: Raw Water Washdown
OPEN before energizing the component/system. Raw Water Washdown The raw water TO RAW WATER WASHDOWN FAUCET washdown faucet is located on the forward deck port-side tub. VIEW OF FOREDECK RAW WATER WASHDOWN FAUCET 4600 SCB Owner’s Manual Supplement... -
Page 34: Standard Marine Head System
(SEACOCK) Macerator Delete Head System (Option) WASTE FROM STARBOARD HEAD Since this optional system does not contain a macera- tor, the holding tank is plumbed to a fitting on the deck for dockside pump-out only. 4600 SCB Owner’s Manual Supplement... -
Page 35: Vacuflush Head System (Option)
• The raw water pickup strainer should be checked periodically for debris according to the directions given in the Raw Water Strainer section of this supplement. CAUTION! SYSTEM DAMAGE HAZARD! The air conditioning system’s seacock must be OPENED before turning on an air conditioning unit and must remain open during operation. 4600 SCB Owner’s Manual Supplement... - Page 36 TO FORWARD AIR CONDITION UNIT DETAILED VIEW TO AFT AIR CONDITION UNIT STRAINER FORWARD ENGINE BULKHEAD TO FORWARD AIR CONDITION UNIT TO STBD. AIR CONDITION UNIT TO AFT AIR CONDITION UNIT STBD. SEACOCK WATER PUMP 4600 SCB Owner’s Manual Supplement...
-
Page 37: Chapter 3: Electrical Routings
AFT SALON RECEPTACLE S h o r e P o w e r /G e n er a t o r H ar n e s se s FROM GENERATOR TO AC PANEL FROM SHORE POWER INLETS 4600 SCB Owner’s Manual Supplement... -
Page 38: Positive Battery Cable Routing
TO UPPER STATION ACCESSORY TO PORT ENGINE TO PORT ENGINE BATTERY STARTER FROM BATTERY SWITCH PANEL JUMPER TO HOUSE BATTERY TO STARBOARD ENGINE BATTERY TO LOWER STATION (OPTION) ACCESSORY TO STARBOARD ENGINE STARTER TO UPPER STATION ACCESSORY 4600 SCB Owner’s Manual Supplement... -
Page 39: Dc Engine Harness
B a t te r y G r o u n d C ab l e R o u t in g TO DC PANEL TO PORT ENGINE GROUND INVERTER (OPTION) BATTERY TO STARBOARD ENGINE GROUND INVERTER (OPTION) TO STARBOARD ENGINE BATTERY TO BUSS BAR PORT ENGINE BATTERY INVERTER (OPTION) SWITCH 4600 SCB Owner’s Manual Supplement... -
Page 40: Negative Battery Cable Routing
Ba t te r y I s o la t or S y s te m Wi r in g PORT ENGINE ALTERNATOR PORT ENGINE BATTERY STARBOARD STARBOARD ENGINE ENGINE BATTERY ALTERNATOR INVERTER BATTERY ISOLATOR (OPTION) 4600 SCB Owner’s Manual Supplement... -
Page 41: Chapter 4: Wiring Schematics
Chapter 4: Wiring Schematics AC E l e ct r ic a l S y s te m 4600 SCB Owner’s Manual Supplement... -
Page 42: Dc Electrical System
Chapter 4: Wiring Schematics DC E l e ct r i ca l S y s t em 4600 SCB Owner’s Manual Supplement... -
Page 43: Gas Engine Electrical System
Chapter 4: Wiring Schematics Ga s E n g in e E l e ct r i ca l S y s t em 4600 SCB Owner’s Manual Supplement... -
Page 44: Diesel Engine Electrical System
Chapter 4: Wiring Schematics Di e se l E n g i n e E l ec t r ic a l S y st e m 4600 SCB Owner’s Manual Supplement... -
Page 45: Appendix A: Express Limited Warranty
TION OF THIS WRITTEN WARRANTY. Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you. Maxum specifically does not authorize any person to extend the time or scope of this warranty or to create or assume for Maxum any other obligation or liability with respect to Maxum Sport Yachts. - Page 46 Owner’s Notes...
- Page 48 Part Number 1706511 Rev. A Maxum Marine • P.O. Box 6050 • Arlington, WA 98223-6050 • 360-435-6534...