Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Maxum 2400 SC
Summary of Contents for Maxum 2400 SC
- Page 3 This document discloses subject matter in which Maxum has proprietary rights. The information and design disclosed herein were originated by and are the property of Maxum. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therein, or to construct boats or any item from it, except by written permission from or written agreement with Maxum.
-
Page 4: Table Of Contents
CONTENTS Chapter 1: Welcome Aboard! Chapter 3: Propulsion & Related Systems Dimensions & Tank Capacities 1 Engine 20 Warranty Information 1 Bilge Blower System 20 Dealer Service 1 Fuel System 21 Fuel Fill & Vent 21 Qualified Maintenance 1 Fuel Filters 22 Engine &... - Page 5 Chapter 6: Plumbing Chapter 9: Convertible Seats, Beds, & Tables Bilge Pump 28 Sleeper Seats 42 Bilge Pump Testing 29 Operating Positions 42 Autofloat Switch 30 Lounge Positions 42 Freshwater System 31 Dinette to V-berth Conversion 43 Transom Shower 31 Chapter 10: Lights Freshwater System Winterization 32 Care &...
- Page 6 Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this supplement to call attention to potentially dan- gerous situations which could lead to either personal injury or product damage. Read all warnings carefully and fol- low all safety instructions.
-
Page 7: Chapter 1: Welcome Aboard
• Maxum offers a Limited Warranty on each new Maxum purchased through an authorized Maxum dealer. • A copy of the Limited Warranty was included in your owner’s packet. • If you did not get a copy of the Limited Warranty, please contact your Maxum dealer or call 360-435-8957 for a copy. -
Page 8: Engine & Accessory Guidelines & Literature
Refer to the engine manual for engine RPM ratings. The engine should reach, but not exceed its full rated RPM when full-throttle is applied. Immediately contact your local Maxum dealer if: • The engine cannot reach its full rated RPM when full-throttle is applied, or;... -
Page 9: Boating Experience
Chapter 1: Welcome Aboard! Boating Experience WARNING! CONTROL HAZARD! An experienced operator MUST be in control of your boat at ALL times. Do NOT operate your boat while under the influence of alcohol or drugs. If this is your first boat or if you are changing to a type of boat you are not familiar with, for your own comfort and safety, get handling and operating experience before assuming command of your boat. -
Page 10: Safety Standards
Chapter 1: Welcome Aboard! Safety Standards DANGER! FALLING and ROTATING PROPELLER HAZARD! • NEVER allow anyone to ride on parts of your boat NOT designed for such use. • Sitting on seat-backs, lounging on the forward deck, bow riding, gun- wale riding or occupying the transom platform while underway is especially hazardous and WILL cause personal injury or death. -
Page 11: Carbon Monoxide (Co)
Chapter 1: Welcome Aboard! Carbon Monoxide (CO) DANGER! • Carbon monoxide gas (CO) is colorless, odorless, tasteless, and extremely dangerous. • ALL engines, generators, and fuel burning appliances produce CO as exhaust. • Prolonged exposure to low concentrations or very quick exposure to high concentrations WILL cause BRAIN DAMAGE or DEATH. -
Page 12: Where & How Co Can Accumulate
Chapter 1: Welcome Aboard! Where & How CO Can Accumulate Stationary conditions that increase CO accumulations include: A. Using engine, generator, or other fuel burn- B. Mooring too close to another boat that is ing device when boat is moored in a con- using its engine, generator, or other fuel fined space. -
Page 13: Co Checklists
Chapter 1: Welcome Aboard! CO Checklists Trip Checklist Make sure you know where the exhaust outlets are located on your boat. Educate all passengers about the symptoms of CO poisoning and where CO may accumulate. When docked, or rafted with another boat, be aware of exhaust emissions from the other boat. Listen for any change in exhaust sound, which could mean an exhaust component failure. -
Page 14: More Information
Chapter 1: Welcome Aboard! More Information For more information about how you can prevent carbon monoxide poisoning on recreational boats and other ways to boat more safely, contact: United States Coast Guard National Marine Manufacturers American Boat & Yacht Council, Inc. Association (NMMA) (ABYC) Office of Boating Safety (G-OPB-3) -
Page 15: Warning Labels
Chapter 1: Welcome Aboard! Warning Labels 1703699 1703805 1704248 TURNING PROPELLER. FALLING FROM - TRANSOM SEAT CAN CAUSE INJURY OR DEATH. STAY OFF TRANSOM SEAT WHEN MOTOR IS RUNNING. 1753820 1703701 1753820... - Page 16 Chapter 1: Welcome Aboard! 1704247 1811368 1703698 1693520 1703581 1706140 1754283 1703805 1811367 1703700...
-
Page 17: Chapter 2: Locations
Chapter 2: Locations Exterior Views Hull Views... -
Page 18: Deck View
Chapter 2: Locations Deck View... -
Page 19: Helm
Chapter 2: Locations Helm NOTE: TYPICAL HELM LAYOUT SHOWN ACTUAL LAYOUT MAY VARY DEPENDING ON ENGINE AND ACCESSORY OPTIONS... -
Page 20: Component Locations
Chapter 2: Locations Component Locations 12-Volt DC Accessory Outlet: Located at the helm. 12-Volt DC Fuse Block: • Located behind the helm dash. • Access through the starboard aft wall hatch in the cabin. Battery(s): Located in the port aft corner of the engine room. - Page 21 Chapter 2: Locations Battery Switch (If Equipped): Located in the engine compartment. Bilge Pump: Located in the engine compartment bilge. Blower Switch: Located on the helm switch panel.
- Page 22 Chapter 2: Locations CO Monitor: Located on the aft starboard side of the ceiling in the cabin. Depth Finder Transducer: Located in the engine compart- ment bilge. Freshwater Fill Deck Fitting (marked WATER): Located on the port side of the deck.
- Page 23 Chapter 2: Locations Freshwater Pump: Located inside the cockpit floor hatch. Freshwater Pump Switch: Located on the helm switch panel. Freshwater Tank: Located inside the cockpit floor hatch.
- Page 24 Chapter 2: Locations Fuel Fill Deck Fitting (marked GAS): Located on the starboard aft corner of the deck. Fuel Tank: Located in the forward area of the engine compartment. Navigation Lights: • Red and green lights located on the forward deck. •...
- Page 25 Chapter 2: Locations Transom Shower: Located inside the transom storage hatch. Trim & Tilt Pump: Located in the engine compartment.
-
Page 26: Chapter 3: Propulsion & Related Systems
Chapter 3: Propulsion & Related Systems Engine Read the engine operation and maintenance manuals before starting or working on the engine. Bilge Blower System WARNING! FIRE and EXPLOSION HAZARD! Fuel vapors can explode! BEFORE starting the engine: 1. Check the bilge areas for fuel vapors or leaking fuel. If you see leaking fuel or smell fuel vapors: a. -
Page 27: Fuel System
Chapter 3: Propulsion & Related Systems Fuel System WARNING! FIRE, EXPLOSION, and OPEN FLAME HAZARD! • It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. • The fueling instructions in the Sport Boat Owner’s Manual and the fuel recommendations in the engine operation manual MUST be followed. -
Page 28: Fuel Filters
Chapter 3: Propulsion & Related Systems Fuel Filters • The fuel pickup tube, located inside the fuel tank, is equipped with a fine mesh screen filter. • Also, when supplied by the engine manufacturer, a fuel filter is installed on the engine. •... -
Page 29: Quick Oil Drain System
Chapter 3: Propulsion & Related Systems Quick Oil Drain System The quick oil drain hose assembly was attached to the engine oil pan at the factory. However, some minor assembly is still needed before you can use this system. NOTE: This is not the only method for changing your oil. Your selling dealer can recommend other methods. How to install the quick oil drain system: 1. -
Page 30: Fire Suppression System (If Equipped)
Chapter 3: Propulsion & Related Systems Fire Suppression System (If Equipped) • The fire suppression system is designed to extinguish engine compartment fires. • Before using your boat for the first time, read the fire sup- pression system’s instruction and maintenance manual and follow all warnings. -
Page 31: Chapter 4: Controls & Gauges
Chapter 4: Controls & Gauges Steering • Your boat features a power-assisted rack-and-pinion steering system. • For information about the power-assist fluid reservoir, refer to the engine operation and maintenance manual. • Boat steering is not self-centering. • Refer to the engine manual for more steering system details. Shift/Throttle Controls WARNING! LOSS OF CONTROL HAZARD! -
Page 32: Gauges
Chapter 4: Controls & Gauges Gauges Cleaning the Gauges CAUTION PRODUCT or PROPERTY DAMAGE HAZARD! • Use only mild soap and water to clean the gauge lenses and bezels. • Use of other cleaners, including common window cleaning solutions, may cause the lenses to crack. -
Page 33: Chapter 5: Navigation Equipment
Chapter 5: Navigation Equipment Read the manuals for all navigation & communication equipment before using these systems. Compass NOTICE • Compass accuracy can be affected by many factors. • Have a trained technician calibrate your compass. • Make sure the technician gives you a deviation card which shows the corrections to apply in navigational calculations. -
Page 34: Chapter 6: Plumbing
Chapter 6: Plumbing Bilge Pump NOTICE Discharge of oil, oil waste, or fuel into navigable waters is prohibited by law. Violators are sub- ject to legal action by the local authorities. • Your boat has a bilge pump for pumping water out of the bilge. -
Page 35: Bilge Pump Testing
Chapter 6: Plumbing Bilge Pump Testing • The bilge pump is vital to the safety of your boat. • Test the bilge pump often. 1. Turn On the bilge pump switch at the helm. 2. Make sure that water in the bilge is pumped overboard. •... -
Page 36: Autofloat Switch
Chapter 6: Plumbing Autofloat Switch • The autofloat switch turns the bilge pump On when water rises above a preset level. • Test the autofloat switch often. Autofloat switch testing: AUTOFLOAT SWITCH 1. Lift the float switch test button to TESTING turn On the bilge pump. -
Page 37: Freshwater System
Chapter 6: Plumbing Freshwater System WARNING! • ONLY use safe drinking (potable) water in your boat’s freshwater system. • ONLY use FDA approved "drinking water safe" hoses when filling the freshwater tank. • NEVER use common garden hoses for drinking water. •... -
Page 38: Freshwater System Winterization
Chapter 6: Plumbing Freshwater System Winterization 1. Turn Off the water heater breaker switch. NOTE: Tag or Mark the water heater breaker switch to prevent it from being turned On while the water heater tank is empty. 2. Turn On the freshwater pump switch. 3. -
Page 39: Drain Systems
Chapter 6: Plumbing Drain Systems Deck Drains • Water on the deck is drained overboard through the deck drains. • Keep the deck drains free of debris. Gray Water Gravity Sink Drain The entertainment sink drain (if equipped) is above the waterline and is gravity drained overboard. Portable Toilet (If Equipped) NOTICE Check with local authorities about the legal use of marine head systems. -
Page 40: Chapter 7: Deck Equipment
Chapter 7: Deck Equipment Cleats & Bow/Stern Eyes WARNING! PERSONAL INJURY and/or PRODUCT or PROPERTY DAMAGE HAZARD! NEVER lift your boat using the bow/stern eyes or the cleats. Read the section on towing in the Sport Boat Owner’s Manual before: •... -
Page 41: Canvas & Vinyl Tops & Enclosures
Chapter 7: Deck Equipment Canvas & Vinyl Tops & Enclosures CAUTION PRODUCT or PROPERTY DAMAGE HAZARD! Take down and securely stow ALL canvas & vinyl BEFORE your boat is transported by road. NOTICE BEFORE cleaning and/or stowing your canvas or vinyl, read the sections later in this chapter, Canvas Care and Vinyl Care. -
Page 42: Aft Bimini Top
Chapter 7: Deck Equipment Aft Bimini Top 1. Insert the end eyes of the main bow (A) into the forward deck hinges (B) and secure them with the pins. 2. Zip four to six inches of the aft bimini top’s zippers to the forward bimini top. -
Page 43: Vinyl Curtains (If Equipped)
Chapter 7: Deck Equipment Vinyl Curtains (If Equipped) NOTICE When taking down the curtains, avoid socket/stud problems by using the following method to unfasten the curtain sockets from the studs on the bimini top and windshield frame: • Grasp the edge of the curtain just below each socket and roll the edge upwards. The socket should pop off easily. -
Page 44: Canvas Care
Chapter 7: Deck Equipment Canvas Care (see also ‘Clear Vinyl Care’ on next page) • After each use, especially in saltwater, rinse the canvas with cold freshwater. • Before stowing, let the canvas air-dry completely. • The canvas can be rolled or folded for stowage. Cleaning the Canvas CAUTION NEVER use detergents when washing the canvas. -
Page 45: Clear Vinyl Care
Chapter 7: Deck Equipment Clear Vinyl Care CAUTION • NEVER store the clear vinyl pieces wet, as this will cause a milky film to develop. • NEVER fold or crease the clear vinyl pieces as cracking will occur. • Clear vinyl is NOT intended for use when your boat is in storage or being moored. •... -
Page 46: Chapter 8: Appliances & Entertainment Systems
Chapter 8: Appliances & Entertainment Systems NOTICE ALWAYS keep an approved ABC-type fire extinguisher in galley area. • The separate instruction sheets or manuals for all appliances and entertainment systems contain detailed informa- tion and important safeguards. • Read these instruction sheets and manuals before using your boat’s appliances and entertainment systems. •... -
Page 47: Alcohol Stove (If Equipped)
Chapter 8: Appliances & Entertainment Systems Alcohol Stove (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! • The alcohol stove is a source of dangerous carbon monoxide gas (CO). • BEFORE using the alcohol stove, Open doors and windows to make sure there is enough fresh air for ventilation. -
Page 48: Chapter 9: Convertible Seats, Beds, & Tables
Chapter 9: Convertible Seats, Beds, & Tables WARNING! FALLING and PRODUCT DAMAGE HAZARD! NEVER allow anyone to step-on or stand-on a sleeper seat in the lounge position. Sleeper Seats • The sleeper seats can be adjusted fore and aft in the upright, operating position. •... -
Page 49: Dinette To V-Berth Conversion
Chapter 9: Convertible Seats, Beds, & Tables Dinette to V-berth Conversion 1. Remove the table (A) and the table leg (B). 2. Place the forward filler board (C) so that it fits securely on the edge lips at the front of the v-berth seats. 3. -
Page 50: Chapter 10: Lights
Chapter 10: Lights Care & Maintenance All of the lights installed on your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1. There may be a blown fuse - replace the fuse. 2. -
Page 51: Chapter 11: Electrical System
Chapter 11: Electrical System DANGER! EXTREME FIRE, SHOCK and EXPLOSION HAZARD! • To minimize the risks of fire and explosion, NEVER install knife switches or other arcing devices in the fuel compartment. • NEVER substitute automotive parts for marine parts. Marine electrical, ignition, and fuel system parts were designed and manufactured to comply with rules and laws that minimize the risks of fire and explosion. -
Page 52: 12-Volt Dc System
Chapter 11: Electrical System 12-Volt DC System Batteries • The batteries supply electricity for lights, 12-volt accessories, and engine starting. • The Electrical section of Chapter 8 in the Sport Boat Owner’s Manual provides battery care and maintenance instructions. Battery Switch (If Equipped with Two Batteries) CAUTION SHOCK and ELECTRICAL SYSTEM DAMAGE HAZARD! When the engine is running, NEVER turn Off the battery switch or disconnect the bat-... -
Page 53: Fuses
Chapter 11: Electrical System Fuses • Fuses for the accessories are on the fuse blocks. For the location of the fuse blocks, see the Component Locations section in Chapter 2 of this supplement. • Fuses for the engine control and gauges are on the engine, see the engine operation manual. -
Page 54: Electrical Routings
Chapter 11: Electrical System Electrical Routings 12-Volt DC Deck Harnesses... -
Page 55: 12-Volt Dc Hull Harness
Chapter 11: Electrical System 12-Volt DC Hull Harness... -
Page 56: Important Records
Important Records Selling Dealer Plumbing Name Of Dealership Freshwater Tank Capacity Waste Holding Tank Capacity Address Key Numbers Phone/FAX/E-mail Ignition Other Sales Manager Service Manager Electronics Engine Manufacturer Model Name/Number Serial Number Manufacturer Model Name/Number Engine Serial Number Manufacturer Model Name/Number Serial Number Propeller Manufacturer... -
Page 57: Float Plan
Float Plan Before going boating, fill out a copy of this float plan (or similar) and leave it with a reliable person whom you can depend on to contact the Coast Guard or other rescue organization, if you do not return as scheduled. Description of Boat Full Name Registration/Documentation Number... - Page 58 Float Plan Survival Equipment Trip Expectations Marine Radio (Yes/No) Type Frequencies Departing From Number of PFDs Flares (Yes/No) Mirror (Yes/No) Departure Date Departure Time Smoke Signals (Yes/No) Flashlight (Yes/No) Food (Yes/No) Stopover 1 Water (Yes/No) Anchor (Yes/No) Raft/Dinghy (Yes/No) Arrive No Later Than: Date Arrive No Later Than: Time Paddles (Yes/No) EPIRB (Yes/No)