Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Maxum 2700 SCR Sun Cruiser
Summary of Contents for Maxum 2700 SCR Sun Cruiser
-
Page 2: Engine Serial Number
This document discloses subject matter in which Maxum has proprietary rights. The information and design disclosed herein were originated by and are the property of Maxum. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therin, or to construct boats or any item from it, except by written permission from or written agreement with Maxum. - Page 3 Congratulations and welcome aboard your new Maxum Sun Cruiser! Thank you for choosing our product. Maxum is committed to the goal of building the highest quality products in the marine industry and to provid- ing the finest after-the-sale support in the world.
-
Page 4: Table Of Contents
CONTENTS Chapter 1: Welcome Aboard! Audio & Visual Equipment Navigation and Interior Lights Dealer Service Appliances Boating Experience 13 Alcohol/Electric Stove Engine & Accessories Guidelines Propulsion Safety Standards 14 Engine Structural Limitations 14 Engine Room Ventilation System Fuel System Qualified Maintenance 15 Fuel Quality Special Care For Moored Boats 15 Fuel Fill Location... - Page 5 Chapter 3: Electrical Routings Hull Wire Harness Routings Deck Wire Harness Routings Battery Cable Routings Bonding Harness Routings Wiring Schematics 29 DC Electrical System 30 AC Electrical System, Single Shore Power 31 AC Electrical System, Dual Shore Power (Air Cond. Option) Appendix A: Limited Warranty...
-
Page 7: Chapter 1: Welcome Aboard
The engine and accessories installed on your boat come with their own operation and maintenance manuals. Read and understand these manuals before operating the engines and accessories. NOTICE When storing your boat please refer to your engine’s operation and maintenance manuals. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 8: Safety Standards
• Many states regulate the chemical content of bottom paints in order to meet environmental standards. Check with your local dealer about recommended bottom paints, and about the laws in effect in your area. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 9: Hazard Warning Symbols
This symbol calls attention to installation, operation or maintenance information, which is important to proper operation but is not hazard related. EXPLOSION OPEN FLAME ELECTRICAL PERSONAL INJURY ROTATING HAZARD! HAZARD! HAZARD! HAZARD! & FALLING HAZARD! PROPELLER HAZARD! • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 10: Chapter 2: Features & Systems
DECK DRAIN DRAIN PORT HULLSIDE BOW EYE GALLEY COCKPIT WATER HEATER SINK DRAIN SINK DRAIN DRAIN TRANSOM STERN EYE TRIM TAB GARBOARD SACRIFICIAL MACERATOR RETRACTABLE (TYPICAL) (TYPICAL) DRAIN ANODE DRAIN (OPTION) BOARDING LADDER • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 11: Deck Hardware
ANCHOR DRAIN WINDLASS STBD. AFT DECK HARDWARE STBD. DECK CLEAT (TYPICAL) FUEL FILL FITTING WATER TANK FILL FITTING DECK CLEAT SWIMSTEP TRANSOM BOARDING LADDER WASTE TANK (TYPICAL) STORAGE HANDLE PUMP OUT FITTING • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 12: Helm And Instrument Panel
CUP HOLDER SWITCH PANEL GRAB HANDLE TILT STEERING ACCESSORY SWITCH ACCESS STEPS TO FOREDECK HORN TRIM TAB SWITCH IGNITION SWITCH 12 VOLT VHF RADIO BLOWER CIRCUIT BREAKER 12 VOLT ADAPTER SWITCH PANEL ADAPTER • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 13: Cockpit Features And Hardware
• When lifting any boat, always use a spreader bar. The spreader bar must be equal to the width of the boat at the lifting point. • Lift slings may slip on the hull. Avoid serious injury or death by securing the slings together before lifting. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 14: Electrical System
Since the batteries on your boat were dealer-installed, the battery switch positions listed on the next page may vary. Make sure you’ve had a full explanation of battery switch operation from your selling dealer. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 15: 12 Volt Dc System
Battery "2" "BOTH" "2" Power Batteries "BOTH" Both Batteries Both Batteries Provide Charges Batteries will NOT Provide Starting Accessory Power (not advised "BOTH" Charge Properly POSITION Power unless engine is running) Batteries • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 16: Shore Power/120 Volt Ac System
AIR COND. SHORE POWER PORT SIDE (OPTION ONLY) INLETS OF DECK TYPICAL AC POWER PANEL • 2700 SCR Sun Cruiser Owner’s Manual Supplement... - Page 17 1 and line 2 which corresponds to line 1 and line 2 shore power inlets. The system is designed so that each line works independent of each other. • AC Voltage can be read on the AC panel’s voltmeter. • 2700 SCR Sun Cruiser Owner’s Manual Supplement...
-
Page 18: Navigation & Communication Equipment
All audio and visual equipment installed on your boat have separate instruction sheets or manuals that explain their operating procedures in detail. NOTICE AM radio reception may be impaired anytime the engines are running. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 19: Navigation And Interior Lights
• DO NOT operate the stove while underway. CAUTION! SYSTEM DAMAGE HAZARD! To prevent overheating, which can destroy the electric burner elements, never attempt to use both alcohol and electric burners simultaneously. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 20: Propulsion
• The fueling instructions in the owner’s manual and the fuel recommendations in the engine operation manual MUST be followed. CAUTION! Avoid the storage or handling of gear near the fuel lines, fittings and tank. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 21: Fuel Quality
If the valve is stuck or clogged, shut down the engine and replace it. Except in a crisis, never operate the engines without the anti-siphon valve. NOTICE Discharge of fuel into navigable waters is prohibited by law. Violators are subject to legal action by the local authorities. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 22: Power Trim And Tilt
(see"Autofloat Switches"on the next page). The bilge pumps can also be controlled by switches on the dash. BILGE PUMP SYSTEMS AND ROUTINGS FWD. BILGE AFT BILGE PUMP SYSTEM PUMP SYSTEM AFT BILGE PUMP DRAIN FWD. BILGE HOSE PUMP DRAIN ENGINE FLOAT BILGE COMPARTMENT SWITCH PUMP FWD. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 23: Autofloat Switches
MUST push the test button all the way FLOAT UP - TEST MODE FLOAT DOWN - AUTO MODE down to return the switch back to auto mode! BILGE PUMP SHOULD TURN OFF BILGE PUMP SHOULD TURN ON • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 24: Freshwater Systems
The tank is full if water flows from the tap when the hot water is turned on in the galley. • The water heater should be drained and the power turned OFF when the possibility of freezing exists. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 25: Raw Water Systems
• You can determine the content level of the holding tank by looking at the tank (located on the starboard side of the bilge). We advise emptying the holding tank at every opportunity. NOTICE Check with local authorities for regulations regarding the legal use of marine head systems. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 26: Manual Flush Head System
VENT FITTING WASTE WASTE PUMP- HOLDING OUT FITTING TANK SWIM STEP WASTE PUMP- OUT FITTING MACERATOR OPTION STBD. MACERATOR MACERATOR TO MARINE RAWWATER TO DISCHARGE Y-VALVE TRANSOM DISCHARGE PUMP HEAD INTAKE SEACOCK SEACOCK • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 27: Vacuflush Marine Head System (Option)
Disconnect and drain all lines to the unit. Remove the screws from the mounting feet (E) and drain the system. Reinstall the screw in the mounting feet and reconnect the system. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 28: Air Conditioning System (Option)
VENTILATION FOR ACCESS TO AIR COND. UNIT AIR COND. UNIT CAUTI ON! SYSTEM DAMAGE HAZARD! The air conditioning system’s seawater intake seacock must remain OPEN anytime the air conditioning unit is in use. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 29: Deck Equipment
ANCHOR WINDLASS CAUTION! PRODUCT DAMAGE HAZARD! Do not pull the boat to the anchor using the windlass or continue to operate the windlass if it has stalled or is overloaded. • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 30: Canvas Top Installation
No adjustments to the bow jaw slides (I) should need to be made as they are preset during manufacturing. Before attempting to adjust the jawslide positions, obtain the correct measurements from your selling dealer. ( I ) • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 31: Labels
FUEL WARNING LABEL OIL DISCHARGE LABEL SWIMSTEP BOARDING LADDER WARNING LABEL OPERATE BLOWER FOREDECK EMERGENCY SHUT DOWN AC PANEL, HIGH BEFORE STARTING WARNING AND QUALIFIED OPERATOR HIGH VOLTAGE WARNING LABELS WARNING • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 32: Chapter 3: Electrical Routings
SWITCH PUMP SWITCH TANK TRIM PUMP ENGINE GROUND ENGINE PLUG BONDING BUSSBAR GROUND MACERATOR (OPTION) GROUND BUSSBAR BILGE BLOWER TRIM VACUFLUSH TO DASH HEAD 12 VOLT REFRIGERATOR PUMP TILT (OPTION) OUTLET RECEPTACLE • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 33: Deck Wire Harness Routings
(OPTIONAL) ARCH SHIFTER TO DASH COURTESY TO BOW LIGHT GROUND GROUND BREAK OUT LIGHT LIGHT COURTESY TO BATTERY SPEAKER AFT BERTH NOTE; ALL VIEWS ARE OF LIGHTS SWITCH LIGHT UNDERSIDE OF DECK • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 34: Battery Cable Routings
STBD. TRIM TILT PUMP TO DASH Bonding Harness Routings STBD. GROUND MACERATOR AIR COND. AIR COND. AIR COND. HEAD PICKUP AIR COND. BUSSBAR (OPTION) PICKUP STRAINER PUMP UNIT (OPTION) (OPTION) (OPTION) (OPTION) • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 35: Wiring Schematics
• Some boats may come equipped with silver (-) and copper (+) colored speaker wires or red/ black (-) and red/white (+) port speaker wire colors; green/black (-) and green/white (+) starboard speaker wire colors. DC Electrical System • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 36: Ac Electrical System, Single Shore Power
Chapter 3: Electrical Routings AC Electrical System, Single Shore Power • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 37: Ac Electrical System, Dual Shore Power (Air Cond. Option)
Chapter 3: Electrical Routings AC Electrical System, Dual Shore Power (Air Cond. Option) • 2700 SCR Sun Cruiser Owner’s Manual Supplement... -
Page 38: Appendix A: Limited Warranty
LIMITED WARRANTY AND ALLOW US AN OPPORTUNITY TO RESOLVE THE MATTER. We require that you return your boat, at your expense, to your selling dealer or, if necessary, to the Maxum factory. You will be responsible for all transportation, haulouts and other expenses incurred in returning the boat for warranty service. - Page 40 Part Number 1709065 • • • Maxum Marine P.O. Box 6050 Arlington, WA 98223-6050 360-435-6534...