Detachments; Indoor Unit - Toshiba RAV-SM404SDT-E Service Manual

14-1. Indoor Unit

14-1-1. 4-Way Air Discharge Cassette Type
RAV-SM564UT-E, RAV-SM804UT-E, RAV-SM1104UT-E, RAV-SM1404UT-E, RAV-SM1604UT-E
No. Part name
Suction grille
1
Be sure to put on the gloves at
disassembling work; otherwise an injury
will be caused by a part, etc.
1. Detachment
2. Attachment
1. Detachment
Electric parts
2
cover
2. Attachment

14. DETACHMENTS

Procedure
XCAUTIONX
1) Stop operation of the air conditioner and
then turn off switch of the breaker.
2) Slide the 2 knobs of the suction grille
inward and then hang down the suction
grille.
3) Remove a strap connecting the panel
and the suction grille and then remove
the suction grille.
1) Hook the suction grille to the panel.
2) Attach strap of the suction grille to the
panel as before.
3) Close the suction grille, slide the knobs
outward and then fix the panel.
1) Carry out work of item 1. of 1 .
2) Remove the fixing screw A which fixes
the electric parts cover and loosen the
fixing screw B.
3) Pull down the electric parts cover,
remove pin of the bell mouth and then
slide it to the arrow direction in order to
open the claws and the electric parts box
cover.
1) Close the electric parts cover and slide it,
hook claw of the electric parts box, claw
of the electric parts box cover and the
Dharma doll hole, and then insert pin of
the bell mouth into hole of the electric
parts box cover.
2) Tighten the fixing screws A and B and
then fix the electric parts box cover.
3) Following to work of item 2 of
the suction grille as before.
Suction grille
Ceiling panel
Hook for
falling-preventive strap
Hole for
ceiling panel hook
Bell mouth pin
Fixing screw B Fixing screw B Fixing scre
Fixing screw A Fixing screw B Fixing scre
, mount
1
– 181 –
Revised 2: Jun., 2008
Remarks
Knobs of the
suction grille hook
Hinge
Claw of
electric parts box
Potbelly hole Potbelly hole otbelly hole
w B
(Dhar (Dharma doll hole) (Dharma doll hole) ma doll hole)
Sliding direction Sliding direction Sliding direction
Claw of electric Claw of electr Cla w of electric ic
par parts box cover parts bo ts box co x cover er
w B
Electric parts box cover Electric par Electr ic parts bo ts box co x cover er
Adjust
corner cap