Dacor ERV3015 Installation Manual
Renaissance downdraft vent
Hide thumbs
Also See for ERV3015:
- Installation instructions manual (20 pages) ,
- Use and care manual (12 pages) ,
- Planning manual (3 pages)
Table of Contents
Advertisement
Quick Links
Part No. 107736 Rev. B
Renaissance
Models
ERV3015, ERV36-ER, ERV3615, ERV48,
ERV48-ER, PRV30, PRV36 and PRV46
Includes installation instructions for cabinet blower (Dacor model CABP3) which is
an option for models ERV3015 and ERV3615.
Use these downdraft vents only with approved Dacor
installation instructions for the particular appliance model being installed to
Installation Instructions
Downdraft Vent
®
determine suitability.
appliances. See the
®
Advertisement
Table of Contents
Related Manuals for Dacor ERV3015
Summary of Contents for Dacor ERV3015
-
Page 1: Installation Instructions
® Models ERV3015, ERV36-ER, ERV3615, ERV48, ERV48-ER, PRV30, PRV36 and PRV46 Includes installation instructions for cabinet blower (Dacor model CABP3) which is an option for models ERV3015 and ERV3615. Use these downdraft vents only with approved Dacor appliances. See the ®... -
Page 2: Table Of Contents
Dacor ® dealer or the Dacor Customer Service Team. style top cap. For use with approved For repairs to Dacor appliances under warranty call the Dacor Dacor cooktops and ranges. Distinctive Service line. Whenever you call, have the model ERV3615 = 36-inch wide downdraft vent with ERV and serial number of the appliance ready. -
Page 3: Important Safety Instructions
WARNING ating this or any other appliance. • Always contact the Dacor Customer Service Team Hazards or unsafe practices that COULD result in severe about problems and conditions that you don’t under- personal injury or death. -
Page 4: General Safety Precautions
• Observe all governing codes and ordinances during • Install or locate this appliance only in accordance planning and installation. Contact your local building with these installation instructions, the Dacor range/ department for further information. cooktop installation instructions and the blower instal- lation instructions. -
Page 5: Product Dimensions - Erv3015 And Erv3615
Product Specifications Product Dimensions - ERV3015 and ERV3615 Tolerances: ±1/16” (±1.6 mm) unless otherwise stated 2 3/16” (5.6 cm) Model A - top Cap B - Chassis 2 1/8 ” Number Width Width 5/16” (8 mm) Top cap with (5.4 cm) -
Page 6: Product Dimensions - Erv48 And Prv Series
Product Specifications Product Dimensions - ERV48 and PRV Series Tolerances: ±1/16” (±1.6 mm) unless otherwise stated 2 3/16" (5.6 cm) Model A - top Cap B - Chassis 2 1/8" 5/16” (8 mm) Top cap with (5.4 cm) Number Width Width thick stiffener vent down... -
Page 7: Product Dimensions - Erv36-Er And Erv48-Er
Product Specifications Product Dimensions - ERV36-ER and ERV48-ER 1/4" (6 mm) Model top Cap Chassis 5/16” (8 mm) Number Width (A) Width (B) thick stiffener across back 2 13/16" ERV36-ER 36” (91.4 cm) 33 3/8” (84.8 cm) (7.1 cm) ERV48-ER 48”... -
Page 8: Installation Specifications
Installation Specifications Planning the Installation General System Layout Backsplash The vent system consists of the downdraft vent itself and a single Dacor approved cabinet blower (models ERV3015 and ERV3615), remote blower or in-line blower (see facing page for examples). Countertop WARNING... - Page 9 Installation Specifications Backsplash Front of unit Cooktop Cabinet blower - option on ERV3015, and ERV3615 only Downdraft vent Blower wiring access hole Cabinet blower, Connection to option on cabinet blower ERV3015 and ERV3615 Wall only Floor Blower wiring Wall cap...
-
Page 10: Planning The Duct Work
(12.7 cm) on downdraft area and to assure optimal performance. You must install one of the Dacor blower models listed below for the downdraft vent to operate properly. See the blower installation instructions for directions. For model 1"... - Page 11 Installation Specifications 6 1/4" (15.9 cm) 1 1/8" (2.9 cm) Front of unit Motor cover 3” Rear Exhaust Knock Out (3 ¼ x 10) Vertical center line of rear exhaust knock out lines up with vertical center line of chassis ...
- Page 12 Installation Specifications Exhaust Locations and Dimensions for CABP3 Cabinet Blower Installations (ERV3015, ERV3615 only) Model Cooktop 12 1/8” 5 5/8” 1 3/4” ERV3015 (30.7 cm) (14.4 cm) (4.4 cm) 9 3/4” 8” 4 1/4” ERV3615 (24.8 cm) (20.3 cm) (10.8 cm)
- Page 13 Installation Specifications Calculating the Maximum Duct Run Length Duct Work Design Tips • For optimal performance, consult a qualified HVAC • Wherever possible, reduce the number of transitions specialist when designing the duct system. and turns to as few sharp angles as possible. Two staggered 45°...
-
Page 14: Installation Instructions
• Insulation foam (tape) Rear knock-out with metal cross overs Installation with CABP3 blower requires Dacor adapter kit shown # AERVCAB. Kit includes adapter, wiring diagram label (PN 106770), 3 wing nuts (PN 83035), 3 flat washers (PN 83008) and 6 lock washers (PN83340). -
Page 15: Installing The Downdraft Vent In The Cutout
Installation Instructions Installing the Downdraft Vent in Adapter Installation for CABP3 Blower: (optional, ERV3015 and ERV3615 only) the Cutout 1. Remove the front cover so that the AERVCAB cabinet blower adapter can be installed. To do so, remove and 1. Cut a hole in the cabinet to allow the duct work to pass... -
Page 16: Electrical Installation
Installation Instructions Cabinet Blower Installation: ILHSF or REMP Series Blower Installation (optional, ERV3015 and ERV3615 only) If using a ILHSF or REMP series blower, install it according to the blower installation instructions. 1. Locate the wiring diagram label included with the adapter kit. - Page 17 Installation Instructions Wires to power plug. Match wire colors to Pre-wired at factory. terminals as shown. Do not modify. Front of unit BLACK WHITE CABP3 cabinet blower Electrical connection Electrical access from downdraft vent, panel match Wire Colors GREEN Blower power wiring/conduit. Attach ground wire Connect other end of wires as shown...
-
Page 18: Verifying Proper Operation
Contact Dacor Distinctive Service at 793-0093 ex. 2822. Be sure to have all model and serial numbers from the product data labels for the downdraft vent and the blower available when you call. Dacor is not responsible for the cost of correcting problems caused by a faulty installation. -
Page 19: Wiring Diagram - All Models
Technical Data Wiring Diagram - All Models DOWN LIMIT SWITCH LIMIT SWITCH SNORKEL SWITCH BLUE CHASSIS GROUND STUD BLUE RELAY REMOTE POT BLOWER POWER GROUND SPEED CONTROL OUTPUT INPUT ORNG CABP3 Cabinet Blower Ratings CABP3 Blower Performance CABP3 Cabinet blower Airflow* Nominal 600 CFM Actual... - Page 20 Dacor ● 14425 Clark Avenue, City of Industry, CA 91745 ● Phone: (800) 793-0093 ● Fax: (626) 403-3130 ● www.dacor.com...
Need help?
Do you have a question about the ERV3015 and is the answer not in the manual?
Questions and answers