After Each Use; Battery Charging & Maintenance - Clarke MA50 15B CLARKE380B Instructions For Use Manual

AFTER EACH USE

After scrubbing, please proceed with below actions before storing the machine:
1. Remove the brush / pad-holder.
2. Empty the tanks as shown in the previous paragraph.
3. Perform the daily maintenance procedures. (see Maintenance section)
4. Store the machine in a clean and dry place, with the brush / pad-holder and the squeegee up.
5. If storing in an area that may reach freezing temperatures, be sure to drain all fl uids from the machine prior to storage. Any damage caused
by freezing will void the warranty.
MACHINE STORAGE
If the machine is not going to be used for more than 30-days, please proceed with below actions:
1. Perform the procedures shown in 'After Each Use' section above.
2. Disconnect the battery connector.
MAINTENANCE
The lifespan of the machine and its maximum operating safety are ensured by correct and regular maintenance. The following chart provides the
scheduled maintenance. The intervals shown may vary according to individual working conditions.
WARNING !
Maintenance procedures must be performed with the machine switched off and the batteries/battery charger cable disconnected.
Moreover, carefully read the instruction in the Safety chapter.
All maintenance procedures must be performed by qualifi ed personnel, or by an authorized Service Center.
This Manual describes only the most common maintenance procedures.
For additional maintenance procedures, contact your local Service Center.
SCHEDULED MAINTENANCE TABLE
Battery charging
Squeegee cleaning
Brush cleaning
Clean tank, vacuum screen & check top cover
gasket
Squeegee blade check and replacement
Inlet fi lter cleaning
Screw and nut tightening check
Lubricate rotary parts
Check brush motor carbon brushes
Check vacuum motor carbon brushes
(1) = After the fi rst 8 working hours.
(2) = This maintenance procedure must be performed by an authorized Service Center.
7/2014
INSTRUCTIONS FOR USE
After each use Weekly
56091128 - MA50 15B
Every six months Annually
（1）
（1）
（2）
（2）
ENGLISH - A
A - 7