Related Manuals for Lang ECOH-PT
Summary of Contents for Lang ECOH-PT
- Page 1 ELECTRIC HALF SIZE COMPUTERIZED CONVECTION OVEN ECOH-PT, RCOH-PT Installation and Operation Instructions 2M-W495 Rev. C 2/6/12 IL1453 ECOH-PT...
- Page 2 CONTROL PANEL. NO USER-SERVICABLE PARTS INSIDE. REPAIRS SHOULD BE DONE BY AUTHORIZED SERVICE PERSONNEL ONLY. NOTICE Using any part other than genuine Lang factory supplied parts relieves the manufacturer of all liability. Lang reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment.
-
Page 3: Table Of Contents
PROBLEMS, QUESTIONS or CONCERNS Before you proceed consult you authorized Lang service agent directory Call the Lang Technical Service & Parts Department at 314-678-6315. TABLE OF CONTENTS Specifications ..........4 Equipment Description . -
Page 4: Specifications
711mm STAND OPTIONAL Front Side View Right Side View Top View ELECTRICAL SPECIFICATIONS VOLTS MOTOR AMPS 3PH/ AMPS WIRE WIRE Lang Model AMPS PHASE NEUT. KW TOT. 1 PH 1 PH 3 PH ECOH-PT2/3NT 220/380 50/60 10.9 ECOH-PT2/3MF 220/380 50/60 10.9... -
Page 5: Equipment Description
EQUIPMENT DESCRIPTION Exterior Construction The Top, Front, Back, and Sides are constructed of stainless steel with an aluminized bottom. The oven exterior dimensions are: 30” (76. cm) Wide, Controls Motor Cover 5.5” (74.3 cm) High, 6.5” (67.3 cm) Deep. Door Handle The oven door comes standard with a high temperature insulated window equipped with... -
Page 6: Unpacking
UNPACKING Receiving the Oven Upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier’s agent. Concealed loss or damage means it does not become apparent until the merchandise has been unpacked. -
Page 7: Installation
ECOH on each other as shown. These pins must be requested at the time of purchase, or call your Lang authorized service agent, or Lang parts department at 34-678-635, or a Lang Service Agent near you. -
Page 8: Electrical Connection
ONLY. In stacked situations each units needs to have separate cord & plug assemblies. Oven Voltage The Lang Model ECOH ovens can be operated on 08, 40-volt (single or three phase), or 480-volt (three phase only) source. The Amp draw, KW rating, and phasing can be found in specification section of this manual. -
Page 9: Reversing The Door
REVERSING THE DOOR . Disconnect oven from power. . Remove the top and bottom door hinge covers (4) by removing the two 0-3 Phillip head screws (8). 3. Remove the top door hinge bracket () from the oven by removing the two ¼-0 Phillip head screws (7). -
Page 10: Initial Start-Up
INITIAL START UP Pre-Power On After the oven is installed and connected to power, prior to turning on, verify the following • The door opens and closes freely • All racks are in the oven correctly • All packing materials have been removed from the inside of the oven Power On Once the oven has been turned on verify that the blower wheel... -
Page 11: General Operation & Programming
Alpha Numeric Display: Visual interface. Typical Operation Sequence ACTION RESULT Control panel comes on; display says Press the on switch. “LANG, Run Oven, Time Date Up & Down Button Program". Display will show a list of product to Select “Run Oven”. choose. -
Page 12: Loading
GENERAL OPERATION & PROGRAMMING CONT. Loading Here are some things to remember when loading your oven. • When loading and unloading the oven, stage products and racks so the oven door is opened for the least amount of time. • Be sure that racks are level within the oven. •... - Page 14 Platinum PROGRAMMING Platinum PROGRAMING When using the Platinum Control Panel follow these simple steps. Function Keys: Are active when selecting an op- tion that is displayed on the LCD Screen. LCD Screen Function Buttons: Cancel: During Program Mode it will take you to the next step, otherwise it will take you back to Function Keys...
- Page 15 Platinum PROGRAMMING ◄ DISPLAY PRODUCT ® ENTER ACCESS CODE ◄ TIMER ONLY USE ▲▼ KEYS TO SELECT THEN PRESS ENTER ◄ MANUAL MODE ◄ SET TIME / DATE ◄ RECIPE MODE ◄ PROGRAM COMPUTER ◄ PROGRAMMING TIME DATE TEMP STATUS TIME DATE TEMP STATUS...
- Page 16 Platinum PROGRAMMING SELECT PRODUCT TEMP SELECT TIER COOK TIME SELECT COOKING CURVE 00:45:00 000% USE ▲▼ KEYS TO SELECT USE ▲▼ KEYS TO SELECT USE ▲▼ KEYS TO SELECT PIE A PIE A PIE A TIER TIER TIER TEMP: 30°F TIME: 00:45:00 TEMP: 30°F...
- Page 17 Platinum PROGRAMMING ◄ CREATE NEW PROGRAM CONTINUE TO NEXT TIER ® ◄ EDIT PRODUCT USE ▲▼ KEYS TO SELECT PIE A ◄ DELETE PROGRAM ◄ MANUAL MODE TIER TEMP: 30°F TIME: 00:45:00 ◄ RECIPE MODE FAN: HI RATE: 00% CCURVE: 80% ◄...
-
Page 18: Cleaning
MAINTENANCE • Oven interiors should be wiped down daily and thoroughly cleaned weekly using warm water and mild deter- gent. DO NOT use caustic cleaners. • The appliance should be thoroughly checked at six-monthly intervals by a qualified technician (heating unit, mechanical stability, corrosion...) with particular emphasis on all control and safety devices. -
Page 19: Troubleshooting
WARRANTIES. NOTICE Service on this or any other Lang appliance must be performed by qualified personnel only. Consult your Lang Authorized Service Agent Directory. You can call our toll free number 314-678-6315 or visit our website www.langworld.com for the service agent nearest you. BOTH HIGH AND LOW VOLTAGES ARE PRESENT INSIDE THIS APPLIANCE WHEN THE UNIT IS PLUGGED/WIRED INTO A LIVE RECEPTACLE. - Page 21 TOP ARRANGEMENT TOP SECTION WIRE DIAGRAMS REVISIONS MODEL DESIGNATION SEC-1 SEC-2 REV. DATE/ECO DESCRIPTION OF CHANGE 6000W WIRE TO DOOR SWITCH NO WAS NC; T7-T4 1667 1/17/2008 CCR30-A & CMR30-A UPDATED MODEL DESIG. TO STAR 5/6/2009 ADDED CONTACTOR #2, REVISED WIRING, CCR30-B &...
- Page 22 REV. DESCRIPTION DATE APPROVED 6485 WIRE TO POWER SWITCH NC WAS NO 1/17/2008 ADDED CONTACTOR #2, REVISED JP1 BOARD WIRING 7806 4/2/2009 TO MATCH PRODUCTION ADDED SNUBBER TO CONTACTOR #2, CHANGE XFMR 7947 5/20/2009 STEAM BACKUP WIRING, ADD XFMR NOTE, REV KW & AMP VALUES BACKUP RELAY SWITCH...
- Page 24 See Body Assembly Controller Assembly Door Assembly Panel Assembly ECOH Complete Assembly SK2320 Rev. B 6/1/2009...
-
Page 25: Parts List
2E-30500-09 TRM BLOCK 3 POLE SMALL 95 208V/VM, RCOHAP-240VM, RCOHAP-440VM, RCOHAP-480V/VM, RCOHAP-480V/480M, RCOHRAP-480V/480M, RCOHPT-440VM ECOH-AP-208V/VM, 240V/VM, 440M, 480V/VM, ECOH-AP2/3FA, 3E-30700-06 CONTC3POLE35A, 24VAC ECOH-AP208CF, ECOH-AP208DR, ECOH-PP208/240V, ECOH-PT- 208/240V ECOH-AP-208V/VM, 240V/VM, 440M, 480V/VM, ECOH-AP2/3FA, 2C-20102-08 SCRW PHD ST 8-32X.375 ECOH-AP208CF, ECOH-AP208DR, Q9-60101-767... -
Page 26: Parts List
Q9-EH-250 WELD SWITCH ARM ECOH, RCOH Q9-EH-350-W1 SWITCH PLUNGER - ASSY ECOH, RCOH Y9-70701-18 KNOB ASSY 450° ECOH-AP, ECOH-PT, ECOH-PP, RCOH-AP, RCOH-PT Q9-60102-112 SWITCH DOOR - ASSY EH 9Q-ECOH-PP-208V Q9-60101-765 ECOH-PT / EHS-PT CONTROL FRONT ECOH-PT, RCOH-PT Q9-60101-766 ECOH-PP / EHS-PP CONTROL FRONT... - Page 27 ECOH Body Assembly SK2325 Rev. A 1/9/2008...
- Page 28 PARTS LIST JUNE 12, 2010, Rev C Model No: ECOH & RCOH, AP, PP & PT BODY PANELS Commercial & Marine Half Size Economy Convection Oven Part Qty Number Description Number Q9-60102-136 BODY TOP EH & HRDW Q9-60102-1361 BODY BACK EH & HRDW Q9-EH-119-2 FIREWALL - ASSY Q9-EH-135 SAFETY STAT BOX 2T-30401-09 STAT FXD 500° DEG OPEN Q9-EH-136 SAFETY STAT COVER 2K-70801-04 SNAP BUSH 3/4 SB750-10 BLK 2C-20103-02...
- Page 29 MARINE APPLICATION ECOH, RCOH Door Assembly SK2321 10/2/2007...
- Page 30 PARTS LIST June 17, 2010, Rev C Model No: ECOH & RCOH, AP, PP & PT DOOR ASSEMBLY Commercial & Marine Half Size Economy Convection Oven Part Qty Number Description Number 2R-50800-12 DOOR T HANDLE 11 1/2 LNG Q9-60102-1362 OUTER DOOR EH NO/LOGO 2Q-71301-04 WINDOW ASSY 9-5/8X16-5/8 2H-60106-17 INSULATION KIT EHS DOOR - Q9-EH-267 HINGE COVER Q9-EH-266 HINGE BOTTOM 2C-20109-15 SCRW PHD MS SS 10-32X1/2 2P-70201-01...
- Page 31 ECOH-PP Purple Plus Controller ECOH-PT & RCOH-PT Platinum Controller SK2324 Rev. A 6/21/2010...
- Page 32 Model No: ECOH & RCOH, PP & PT CONTROL ASSEMBLY Commercial & Marine Half Size Economy Convection Oven Part Qty Number Description Number 2M-60301-117 SWITCH LBL EH 4X20 ECOH-PP 2M-60301-118 SWITCH LBL EH PLATINUM ECOH-PT, RCOHPT Q9-60101-7665 ECOH-PP / EHS-PP CNTRL FRNT W/PROTO ECOH-PP Q9-EH-516-1 CONTORL PANEL - EH-PT ECOH-PT-208V 2A-20504-01 SPACER NYLON #6 1/4 X 7/8 ECOH-PP 2A-20504-02 SPACER NYLON #6 1/4 X 1” ECOH-PT, RCOH-PT...
- Page 33 ECOH PP/PT Controller Panel SK2323 Rev. A 7/6/2010...
- Page 34 June 16, 2011, Rev C Model No: ECOH & RCOH, PP & PT CONTROL PANEL ASSEMBLY Commercial & Marine Half Size Economy Convection Oven Part Qty Number Description Number Q9-EH-495 COMPUTER CONTROL SLIDE ECOH-PP, ECOH-PT, RCOH-PT Q9-EH-495-1 SLIDE CLIP A ECOH-PP, ECOH-PT, RCOH-PT Q9-EH-505 COMPONENT MOUNT C,P,PP ECOH-PP, ECOH-PT, RCOH-PT 2E-30700-06 CONTC3POLE35A24VAC50/60HZ ECOH-PP, ECOH-PT, RCOH-PT 2J-31110-W1 USB PNL MNT CABLE TO SOCKET...
- Page 36 STAR INTERNATIONAL HOLDINGS INC. COMPANY Star - Holman - Lang - Wells - Bloomfield - Toastmaster 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (314) 678-6303 www.star-mfg.com...