Lang ECOF-C-CN Installation, Operation And Maintenance Instructions

Electric full size convection oven

Hide thumbs

Table Of Contents

Star Manufacturing International

Part Number: 2M-W490

Rev B

Installation,

Operation, and

Maintenance Instructions

Electric Full Size Convection Oven

Models:

ECOF-C-CN

ECOF-C2/3VCN

ECOF-C2/4VCN

ECOF-C380VCN

ECOF-C480VCN

ECOF-2/4CECN

10 Sunnen Drive

Phone: 314-781-2777 Fax: 314-781-2714

WWW.STAR-MFG.COM

St. Louis, MO 63143

June 17, 2008

Table of Contents

Summary of Contents for Lang ECOF-C-CN

Page 1: Maintenance Instructions
Installation, Operation, and Maintenance Instructions Electric Full Size Convection Oven Models: ECOF-C-CN ECOF-C2/3VCN ECOF-C2/4VCN ECOF-C380VCN ECOF-C480VCN ECOF-2/4CECN Star Manufacturing International 10 Sunnen Drive St. Louis, MO 63143 Part Number: 2M-W490 Phone: 314-781-2777 Fax: 314-781-2714 Rev B WWW.STAR-MFG.COM June 17, 2008...
Page 2 THE INFORMATION IN THIS MANUAL IS CRUCIAL AND MUST BE RETAINED FOR FUTURE REFERENCE. READ, UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND WARNINGS CONTAINED IN THIS MANUAL. DANGER POTENTIALLY HAZARDOUS SITUATION, WHICH, IF NOT AVOIDED, COULD RESULT IN DEATH. WARNING POTENTIALLY HAZARDOUS SITUATION, WHICH, IF NOT AVOIDED, COULD RESULT IN DEATH OR SERIOUS INJURY.
Page 3: Table Of Contents
Table of Contents Chapter Page Table Of Contents........................3 Read First ............................4 Equipment Description.........................6 Unpacking............................7 Installation............................8 Initial Start-Up ..........................11 Operation .............................12 Programming ..........................15 Maintenance & Cleaning Procedures ..................16 Troubleshooting ...........................17 Parts List............................19 Wiring Diagram ..........................20 UL FILE # E8138...
Page 4: Read First
THE UNIT IS EXTREMELY HEAVY. FOR SAFE HANDLING, INSTALLER CAUTION SHOULD OBTAIN HELP AS NEEDED, OR EMPLOY APPROPRIATE MATERIALS HANDLING EQUIPMENT (SUCH AS A FORKLIFT, DOLLY, OR PALLET JACK) TO REMOVE THE UNIT FROM THE SKID AND MOVE IT TO THE PLACE OF INSTALLATION.
Page 5 Service on this, or any other, LANG appliance must be performed by NOTICE qualified personnel only. Consult your LANG authorized service agent directory or call the factory at 1-800-807-9054, or WWW.STAR-MFG.COM for the service agent nearest you. WARNING BOTH HIGH AND LOW VOLTAGES ARE PRESENT INSIDE THIS APPLIANCE WHEN THE UNIT IS PLUGGED/WIRED INTO A LIVE RECEPTACLE.
Page 6: Equipment Description
Equipment Description Model No: ECOF-C Exterior Construction The oven exterior dimensions are 40” (101.6cm) Wide, 28” (71.12cm) High, 38” (96.52cm) Deep, and a 3.25” (8.26cm) handle extension on the door. The front, back, top, and sides are constructed of stainless steel with an aluminized bottom.
Page 7: Unpacking
Unpacking Receiving the Oven Upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier's agent. Concealed loss or damage means loss or damage, which does not become apparent until the merchandise has been unpacked.
Page 8: Installation
Installation THIS APPLIANCE MUST BE GROUNDED AT THE TERMINAL PROVIDED. DANGER FAILURE TO GROUND THE APPLIANCE COULD RESULT IN ELECTROCUTION AND DEATH. WARNING INSTALLATION OF THE UNIT MUST BE DONE BY PERSONNEL QUALIFIED TO WORK WITH ELECTRICITY AND PLUMBING. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO EQUIPMENT.
Page 9 Installation cont’d Leg Pad Adapter Identify the front and rear leg adapters (the front adapters have two threaded inserts and the rear has four). Leg to Adapter Installation: Install the leg’s threaded stud through the hole in the adapter labeled “C” with the bent flange of the adapter facing away from the leg.
Page 10: Electrical Connection
Installation cont’d Ventilation and Clearances Standard minimum clearance from combustible construction is as follows. 4” from side 4” from back 6” from floor These ovens may be set directly, without legs, on a curbed base or non- combustible floor. If the oven is set without legs on a non-combustible floor or a curbed base, maintain a 4-inch back clearance.
Page 11: Initial Start-Up
Initial Start Up Pre-Power On After the oven is installed and connected to power, prior to turning on, verify the following: The doors open and close freely. All racks are in the oven correctly. All packing materials have been removed from the inside of the oven.
Page 12: Operation
Operation Control Panel Light Switch Power Switch Status Display Shelf Timers Pace Timers Temperature Button Minute Timers Program Enable Buttons UL FILE # E8138...
Page 13: Control Panel
Operation cont’d General Convection ovens constantly circulate air over and around the product. This strips away the thin layer of moisture and cool air from around the product allowing heat to penetrate more quickly. Always weigh your product. This will give you a more consistent size, color and quality. Check the product near the end of the initial cooking.
Page 14 Operation cont’d Status Display The Status Display informs the operator of the oven’s status. Stands for PREHEAT. The oven is on and adjusting to the Preht preprogrammed temperature (350°F). The oven has reached the preset temperature and is waiting for Ready product to be loaded into the oven.
Page 15: Programming
Programming Pace Timers The pace timers can be set at any time. Press and hold the “PACE” button for three seconds. The display will read out the set time then begin to flash. Press the “1” minute button to increase the time, or the “2” minute button to decrease the time. Once the corrected time is set, press and hold the “PACE”...
Page 16: Maintenance & Cleaning Procedures
Maintenance & Cleaning WARNING KEEP WATER AND SOLUTIONS OUT OF CONTROLS. NEVER SPRAY OR HOSE CONTROL CONSOLE, ELECTRICAL CONNECTIONS, ETC. MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS CAUTION MEMBRANES AND CLOTHING. PRECAUTIONS SHOULD BE TAKEN TO WEAR RUBBER GLOVES, GOGGLES OR FACE SHIELD AND PROTECTIVE CLOTHING.
Page 17: Troubleshooting
Troubleshooting Symptoms What follows is a chart of Symptoms and Possible Causes to aid in diagnosing faults with the oven. Refer to the Symptoms column to locate the type of failure then to the Possible Cause for the items to be checked. To test for a possible causes refer to the TEST section and locate the Possible Cause then refer to test to identify test procedures.
Page 18 Troubleshooting cont’d Service on this, or any other, LANG appliance must be performed by NOTICE qualified personnel only. Consult your LANG authorized service agent directory or call the factory at 1-800-807-9054, or WWW.STAR-MFG.COM for the service agent nearest you. WARNING...
Page 19 Detail Can Assembly Detail Control Panel Assy ECOF Main Assembly SK2366 4/21/2008...
Page 20: Parts List
PARTS LIST June 17, 2008 Model No: ECOF-C Main Assembly Commercial Cinnabon Full Size Electric Convection Oven Part Number Number Description 2C-20102-04 SCRW PHD ST 8-32X.5 PLTD ECOF Q9-ECCO-230-1 TOP PANEL ASSEMBLY ECOF Q9-ECCO-176-2 BODY SPOTWELD STD. ECOF 2P-70901-06 PLGBTNBLKPLSTC 5/8DP625 ECOF Q9-ECCO-176-4 STM VALVE COVER...
Page 21 PARTS LIST June 17, 2008 Model No: ECOF-C Main Assembly Commercial Cinnabon Full Size Electric Convection Oven Part Number Description Number Q9-ECCOPLMDR-C PANEL ECCO 208/240V ECOF-C-CN Q9-ECCOPLMDR-G PANEL ECCO 220/380V ECOF-C2/3VCN Q9-ECCOPLMDR-H PNELECCOCINNABONCE220/380 ECOF-2/4CECN Q9-ECCOPLMDR-J PANEL ECCO 240/415V ECOF-C2/4VCN Q9-ECCOPLMDR-K...
Page 22 ECOF-C Cinnabon Controller Panel SK2363 4/2/2008...
Page 23 PARTS LIST June 17, 2008 Model No: ECOF-C Cinnabon Control Panel Assembly Full Size Electric Convection Oven Part Number Description Number Q9-ECCOPLMDR-C PANEL ECCO 208/240V ECOF-C-CN Q9-ECCOPLMDR-G PANEL ECCO 220/380V ECOF-C2/3VCN Q9-ECCOPLMDR-H PNELECCOCINNABONCE220/380 ECOF-2/4CECN Q9-ECCOPLMDR-J PANEL ECCO 240/415V ECOF-C2/4VCN Q9-ECCOPLMDR-K...
Page 24 PARTS LIST June 17, 2008 Model No: ECOF-C Cinnabon Control Panel Assembly Full Size Electric Convection Oven Part Number Description Number Q9-ECCO-225-1 CIRCUIT BREAKER HOLDER ECCOPLMDR-H Q9-ECCO-226 FUSE MOUNT C 208-240V ECCOPLMDR-C, ECCOPLMDR-G, ECCOPLMDR-J Q9-ECCO-226-1 FUSE MOUNT C 480V ECCOPLMDR-K, ECCOPLMDR-U 2C-20102-06 SCRW PHD ST 6-32X3/8 PLTD ECCOPLMDR-C, ECCOPLMDR-G,...
Page 25 PARTS LIST June 17, 2008 Model No: ECOF-C Cinnabon Control Panel Assembly Full Size Electric Convection Oven Part Number Description Number 2K-70801-03 SNAP BUSH 3/8 SB375-4 BLK ECCOPLMDR-C, ECCOPLMDR-G, ECCOPLMDR-H ECCOPLMDR-J, ECCOPLMDR-U 2K-70801-03 SNAP BUSH 3/8 SB375-4 BLK ECCOPLMDR-K 2C-20301-15 NUT HEX 10-32 PLTD ECCOPLMDR-C, ECCOPLMDR-G, ECCOPLMDR-H, ECCOPLMDR-J,...
Page 26 Suggested Marine Parts Stocking 28 33 34 15 22 13 Detail ECOF: CAN & MOTOR ASSEMLBY SK2367 Rev. A 6/03/08...
Page 27 SCRW SM PLT 10 X .5 PHLSL ECOF-C-CN 2K-70801-01 SNAP BUSH 7/16 SB437-5 ECOF 2K-70801-04 SNAP BUSH 3/4 SB750-10 ECOF 2U-30200-12 MTR 1/3HP 115/208-240 1PH ECOF-C-CN, ECOF-C2/3VCN, ECOF-C2/ 4VCN, ECOF-2/4CECN 2U-30200-60 MTR 1/3HP380V1PH50HX2SP ECOF-C380VCN 2U-30200-03 MTR 1/3HP 480V 3PH 60HZ ECOF-C480VCN 2C-20118-01 SCRW CARRAGE PLT 5/16X.75...
Page 28 Wiring Diagram 208/240 UL FILE # E8138...
Page 29 Wiring Diagram 380/400 UL FILE # E8138...
Page 30 Wiring Diagram 480 UL FILE # E8138...
Page 31 & & " " " " " "...

This manual is also suitable for:

Ecof-c2/3vc Ecof-c2/4vcn Ecof-c380vcn Ecof-c480vcn Ecof-2/4cecn

Lang ECOF-C-CN Installation, Operation And Maintenance Instructions

Table of Contents

Maintenance Instructions

Related Manuals for Lang ECOF-C-CN

Summary of Contents for Lang ECOF-C-CN

This manual is also suitable for:

Table of Contents