Joyner Go-kart JNSZ650DS Owner's Manual page 22

Figure 12
a. With the engine warm, put the vehicle on the level ground.
b. Shut down the engine, put a collecting oil plate under the engine oil outlet. Loosen
the oil outlet plug in the warm engine. Let the engine oil out fully (see Fig. 10).
c. Tighten the engine oil outlet plug.
d. Remove the oil filler cap (see Fig. 11), fill oil (SE 15W/40 or SF 15W/40) about
2.8 liters to the engine.
e. Pull out the engine oil dip stick (see Fig. 12), confirm the corrective oil level in the
crankcase (see Fig. 13).
SERVICE INSTRUCTIONS
Check engine oil and recharge
a. If the color of engine oil changes, you need to replace the engine oil. Replace the
engine oil as above.
b. Check the engine oil level, change if necessary from d as above.
C. Transmission lubrication
You must change the oil in the transmission after the first 5 hours of operating of your
new engine and after 10 hours of use thereafter. That will insure proper lubrication of
internal parts and prevent costly repairs due to excessive wear.
Figure 14
a. Put the vehicle on the level ground.
b. Shut down the engine, put a collecting oil plate under the transmission oil outlet.
Loosen the oil outlet plug in the warm engine. Let the transmission oil out fully (see
Fig. 15).
c. Remove the iron dust plug, this plug has a magnet on it. Iron dust caused by moving
Figure 13
Figure 15
21