Service Instructions - Joyner Go-kart JNSZ650DS Owner's Manual

H. Starting And Operating Instructions
a. Before starting the engine, be sure that the driver is seated properly in the Go-Kart
and tighten the seatbelt.
b. Testing the Go-Kart in a open place at the beginning to learn how to start, turn and
stop.
c. Operate the Go-Kart slowly until you are familiar with it.
d. The turning radius of this Go-Kart is small and agile, so the centrifugal force is very
high when turning at high speed. Slow down to a more controllable speed when turning
to prevent the Go-Kart from rolling over.
e. To prevent vehicle from rolling over, be sure to only turn the vehicle at a slow more
controllable speed.
A． Service Air Cleaner
Service air cleaner every 80 hours
NOTE: Service more often under dusty
conditions.
a. Remove filter cover(See Fig. 8)
b. Check the filter cover and the air filter,
if the filter cover and the air filter is dusty,
please clear the filter cover and
replace with a new air filter.
B. Engine Lubrication
Engine oil replacement
You must change the oil in the crankcase after the first 5 hours of operating of your
new engine and after 10 hours of use thereafter. That will insure proper lubrication of
internal parts and prevent costly repairs due to excessive wear.
Figure 10

SERVICE INSTRUCTIONS

Figure 9
Figure 11
20