Safety; Scope; Signal Words And Labels; General Precautions - Reeves G2 Operation & Maintenance Manual

2 SAFETY

2.1 Scope

This chapter contains general information for the safe operation and maintenance requirements for the G2 / G2S Water
Heaters. The cautions and warnings point out known conditions that are potentially hazardous. However, no manual can
cover every possible situation. When in doubt, contact REEVES EMS, (Phone: 800-328-5563, fax: 301-698-1599 or
Email: info.reevesdecon.com). Before calling for assistance, please have the model number and serial number available.

2.2 Signal Words and Labels

Signal words and labels are used throughout this manual. The words and symbols convey the following advice:
Danger: Danger refers to immediate hazards that will result in severe personal injury or death.
Warning: Warning refers to a hazard or unsafe method or practice that may result in severe personal
injury or death.
Caution: Caution refers to a hazard or unsafe method or practice that may result in equipment damage or
personal injury.
Important: Important refers to a hazard or unsafe method or practice that can result in equipment
damage.

2.3 General Precautions

PLEASE REMEMBER SAFETY FIRST. If you are not sure of the instructions or procedures, contact REEVES EMS,
before continuing.
This manual emphasizes the safety precautions necessary during the operation and maintenance of your
Decontamination Water Heater. Each section has caution and warning messages. These messages are for your safety
and the safety of the equipment involved. If any of the cautions or warning is not readily understood, contact REEVES
EMS, before proceeding.
When an abnormal condition is observed and the procedures in the manual do not specifically cover the condition, work
shall be stopped. Contact REEVES EMS for assistance. An authorized REEVES EMS technician should give guidance
on the abnormal condition before any work can be continued.
The following safety precautions should be observed:
•
This unit must be grounded. Make sure the water heater is equipped with a GFCI built into the power supply
cord.
•
Always operate the water heater in a well ventilated area free of flammable vapors, combustible dust, gases, or
other combustible materials.
•
Never fill the burner fuel tank while the water heater is running or hot. Allow to cool a minimum of two minutes
before refueling.
•
Do Not modify the electrical plug. If the plug will not fit into the outlet, have a proper outlet installed by a qualified
electrician.
•
Do Not use extension cords with this water heater.
•
Do Not allow metal components of the water heater to come in contact with live electrical components.
•
Never operate this water heater in an enclosed area. Always make certain there is adequate ventilation (fresh
outside air) for breathing and combustion. This will prevent the buildup of dangerous carbon monoxide gases.
Beware of poorly ventilated areas or areas with exhaust fans which can cause poor air exchange.
95226-01
This document contains information proprietary to REEVES EMS, LLC and is intended solely for use by its customers. No portion of this document may
be reproduced for release to a third party without written consent from REEVES EMS, LLC
3
.
REEVES EMS, LLC