Table of Contents
Advertisement
Quick Links
INSTALLATION AND USER INSTRUCTIONS
FOR THE GAS INDOOR CHARBROILER
THIS APPLIANCE WAS DESIGNED FOR EASE OF INSTALLATION AND OPERATION. HOWEVER, WE
RECOMMEND THAT YOU READ ALL SECTIONS OF THIS MANUAL BEFORE YOU BEGIN INSTALLA-
TION. INSTALLATION MUST BE PERFORMED BY AN APPROVED GAS INSTALLER OR GAS SERVICE
TECHNICIAN OR THE WARRANTY IS VOID. IN THE COMMONWEALTH OF MASSECHUSETTS A
LICENSED PLUMBER OR GAS FITTER CAPABLE OF REVIEWING AND PERFORMING THE MANU-
FACTURER'S INSTALLATION CHECKLIST SHOULD INSTALL THIS APPLIANCE. THE INSTALLATION
CHECKLIST IS INCLUDED AT THE REAR OF THIS BOOKLET.
DO NOT REMOVE PERMANANTLY AFFIXED LABELS, WARNINGS OR DATA PLATES FROM YOUR
APPLIANCE. THIS MAY VOID THE MANUFACTURER'S WARRANTY AND/OR HINDER EFFECTIVE
SERVICING AND MAINTENANCE.
THESE INSTRUCTIONS ARE TO REMAIN WITH THE APPLIANCE AND THE CONSUMER IS TO RETAIN
THEM FOR FUTURE REFERENCE.
WARNING: If the information in this manual is not followed exactly,
a fire or explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
© Copyright 2010Prizer –Painter Stoves Works
All specifications are subject to change without prior notification
FOR THE HOME
MODELS: PRZIDCB15, PRZIDCB30
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance
Do not touch or activate any electrical switch
Do not use any phone in your building
Immediately call your gas supplier from a neighbor's house
Follow the gas supplier's instructions
If you cannot reach your gas supplier, call the fire department
P/N 750301 Page 1
Advertisement
Table of Contents
Related Manuals for BlueStar PRZIDCB15
Summary of Contents for BlueStar PRZIDCB15
- Page 1 INSTALLATION AND USER INSTRUCTIONS FOR THE GAS INDOOR CHARBROILER FOR THE HOME MODELS: PRZIDCB15, PRZIDCB30 THIS APPLIANCE WAS DESIGNED FOR EASE OF INSTALLATION AND OPERATION. HOWEVER, WE RECOMMEND THAT YOU READ ALL SECTIONS OF THIS MANUAL BEFORE YOU BEGIN INSTALLA- TION.
-
Page 2: Introduction
Since 1880, we have been dedicated to quality! We believe that our success can only be measured by the continuing success of our customers. We achieve customer satisfaction by ensuring that each of our employees understands, meets and exceeds customer expectations. We establish and maintain an environment that encourages all employees to pursue continu- ous improvement in quality and productivity. -
Page 3: Welcome
You have purchased one of the finest appliances available for home use, which shows that you take cooking seriously. As the owner of a new BlueStar appliance you can look forward to years of cooking enjoyment. You will prepare meals with the speed and accuracy of a professional chef right in your own kitchen! All equipment is designed and manufactured to the highest quality standards in the industry spe- cifically to meet the needs of the world’s most demanding chefs: you. -
Page 4: Table Of Contents
TABLE OF CONTENTS Introduction ............................2 Welcome ..............................3 Table of Contents ........................... 4 Safety Instructions ..........................5 Site Preparation ............................6 15‖ Cut Out…………………………………………………………………………………….7 15‖ Clearances…………………………………………………………………………………8 15‖ Dimensions………………………………………………………………………………..9 30‖ Cut Out……………………………………………………………………………………10 30‖ Clearances………………………………….……………………………………………..11 30‖ Dimensions……………………………………………………………………………….12 Installation ............................. 13-16 Unpacking ..........................13 Backguard .......................... -
Page 5: Safety Instructions
SAFETY INSTRUCTIONS To avoid personal injury or property damage, 9. Additional care should be exercised if your please read and follow these important safety appliance is equipped with a high-shelf. Dur- precautions. ing heavy or continued use this shelf may be- come hot. -
Page 6: Site Preparation
SITE PREPARATION This appliance has been designed to be in- stalled directly against rear walls and side base cabinets. It cannot be installed di- rectly against tall side cabinets, side walls, tall appliances or base cabinets extending beyond 24 inches [610 mm]. Side trims must be at least 11/16 inch [17.5 mm] above the adjoining counter top sur- faces. -
Page 7: Cut Out
15 INCH INDOOR CHARBROILER CUTOUT DEPTH HEIGHT WIDTH CUTOUT WIDTH: 15" CUTOUT DEPTH: 24" CUTOUT HEIGHT: 7-7/8" All specifications are subject to change without prior notification P/N 750301 Page 7... -
Page 8: Clearances
15 INCH INDOOR CHARBROILER CLEARANCES All specifications are subject to change without prior notification P/N 750301 Page 8... -
Page 9: Dimensions
15 INCH INDOOR CHARBROILER DIMENSIONS FRONT VIEW All specifications are subject to change without prior notification P/N 750301 Page 9... -
Page 10: Cut Out
30 INCH INDOOR CHARBROILER CUTOUT DEPTH HEIGHT WIDTH CUTOUT WIDTH: 30" CUTOUT DEPTH: 24" CUTOUT HEIGHT: 7-7/8" All specifications are subject to change without prior notification P/N 750301 Page 10... -
Page 11: Clearances
30 INCH INDOOR CHARBROILER CLEARANCES All specifications are subject to change without prior notification P/N 750301 Page 11... -
Page 12: Dimensions
30 INCH INDOOR CHARBROILER DIMENSIONS All specifications are subject to change without prior notification P/N 750301 Page 12... -
Page 13: Installation
INSTALLATION Remove and unpack any accessories UNPACKING 1. Check the package for damage. If any shipped with your appliance. Make sure damage is visible you should mark the bill no hardware or accessories are left to be of lading you sign that there may be con- disposed of unintentionally. -
Page 14: Backguard
INSTALLATION and slip the tongue into place. A minimum of BACKGUARD All charbroilers require a backguard. The six sheet metal screws (more depending on IDCB30 gives you the option of using an is- width) are to be installed, three on each end land trim;... -
Page 15: Gas Connections
INSTALLATION factory installed regulator be removed or GAS CONNECTIONS This appliance must be installed by an ap- by-passed. proved installer or a gas technician 8. The factory installed pressure regulator 1. The installation of this appliance must will withstand an input pressure of ½ PSI conform with all applicable local codes. -
Page 16: Electrical Connections
INSTALLATION 15. Air shutter adjustments are preset at the factory. These adjustments may need to be redone and/or fine tuned by the in- WARNING staller. These adjustments are normal. This appliance is equipped with a three- They are the responsibility of the quali- pronged grounding plug for your protec- fied installer and are not covered by tion against shock hazard and should be... -
Page 17: Operation
CHARBROILER OPERATION inch charbroiler, there are two burners and BEFORE YOU TURN IT ON…. As part of the installation, protective plas- two control knobs. This control knob is tic wrappers on stainless steel surfaces both a gas valve and an electric switch. should be removed. -
Page 18: Rotisserie
CLEANING used to clean these parts. Be sure to fol- BODY All stainless steel and painted parts should low the manufacturer’s instructions for be cleaned regularly with hot soapy water. use. Commercially available stainless steel Ensure the cleaning chemical does not cleaners may be used on stainless steel. -
Page 19: Griddle Plates
OPERATION When the griddle is lit turn the heat set- Use a spatula to push debris toward the ting back to ―LOW‖. grease trap. After a short while, as the griddle heats, it likely will discolor with the heat. Colors ROTISSERIE range through different shades of blue and black. -
Page 20: Care And Maintenance
CARE AND MAINTENANCE AIR SHUTTER ADJUSTMENTS Air shutter adjustments are preset at the fac- tory. These adjustments may need to be re- done and/or fine tuned by the installer. These adjustments are normal. They are the responsibility of the qualified installer and are not covered by your warranty. -
Page 21: Troubleshooting
TROUBLESHOOTING PROBLEM SOLUTION Burner won’t light Ensure appliance is plugged in. Ensure circuit is not tripped or fuse blown. Ensure gas is turned on. LAZY flame—floating, larger in size than Air shutter adjustment. normal LIFTING flame—well defined with visible Air shutter adjustment. inner core, noisy, gap between burner and flame All specifications are subject to change without prior notification... -
Page 22: Warranty
WARRANTY WHAT IS COVERED? Prizer-Painter provides the following limited warranties to the original retail purchasers of Products sold and installed in the continental United States and Canada on or after February 22, 2002: Initial Seven (7) Day Limited Warranty. Prizer-Painter warrants that all cosmetic components of its Products will, under normal use and service, be free from defects in materials and workmanship for a pe- riod of seven (7) calendar days from the date of delivery (the "Warranty Period") to the original retail pur- chaser. - Page 23 WARRANTY WHAT IS NOT COVERED? This Limited Warranty is the sole and exclusive warranty provided for the Product and extends only to original retail purchasers in the continental United States and Canada. This Limited Warranty is not trans- ferable to any subsequent purchasers or users. If any implied warranties arise under any applicable law (including, but not limited to, implied warranties of merchantability and fitness for particular purpose), then the duration of those implied warranties will last only as long as the express warranties stated above.
-
Page 24: Performance Checklist
PERFORMANCE CHECKLIST This checklist has been developed to assure proper installation of your appliance To validate your warranty you must mail or fax this form and a copy of your receipt to: Warranty Department, Prizer-Painter, 600 Arlington Street, Reading, PA 19611, Fax (610) 376-2596 Customer Information (Please Print) Product Information (Please Print) Name:________________________________________ Model No: ________________________________... - Page 25 Fold Here ——————————————————————————————————————————————— Affix Postage ____________________________ Here _______________________________ _______________________________ Prizer-Painter Stove Works, Inc. 600 Arlington Street Reading, PA 19611 **Performance Checklist Enclosed** ——————————————————————————————————————————————— Fold Here All specifications are subject to change without prior notification P/N 750301 Page 25...
-
Page 26: Mail In Performance Checklist
PERFORMANCE CHECKLIST This checklist has been developed to assure proper installation of your appliance To validate your warranty you must mail or fax this form and a copy of your receipt to: Warranty Department, Prizer-Painter, 600 Arlington Street, Reading, PA 19611, Fax (610) 376-2596 Customer Information (Please Print) Product Information (Please Print) Name:________________________________________ Model No: ________________________________...
Need help?
Do you have a question about the PRZIDCB15 and is the answer not in the manual?
Questions and answers