Using The Charger; Charger Maintenance; Operating The Vehicle - Ezgo TXT Fleet Electric Owner's Manual

Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
To prevent a physical hazard that could result in an electrical shock or electrocution, be sure that
the charger plug is not damaged and is inserted fully into a grounded receptacle.
The power (AC) cord is equipped with a grounded plug. Do not attempt to pull out, cut or bend
The charging (DC) cord is equipped with a polarized connector that fits into a
matching receptacle on the vehicle. The receptacle is located on the driver
side of the vehicle just below the seat bottom.

USING THE CHARGER

The charger may remain plugged into the AC outlet when not in use. To
charge the vehicle, refer to the instruction labels on the charger. Insert the
polarized DC plug completely into the vehicle receptacle. The charger will
automatically start a few seconds after the plug is in place. The charger will
automatically stop when the batteries are fully charged and the DC plug can
be removed to permit use of the vehicle.

CHARGER MAINTENANCE

1. For flooded lead-acid batteries, regularly check the water levels of each battery cell after charging and add dis-
tilled water as required to the level specified by the battery manufacturer. Follow the safety instructions recom-
mended by the battery manufacturer.
2. Make sure the charger connections to the battery terminals are tight and clean. Check for any deformations or
cracks in the plastic parts. Check the charger harness for chaffing and rubbing. Inspect all wiring for fraying,
loose terminals, chaffing, corrosion or deterioration of the insulation.
3. Keep the cooling fins free of dirt and debris, do not expose the charger to oil, dirt, mud or to direct heavy water
spray when cleaning equipment.
4. Inspect the plug of the battery charger and the vehicle receptacle housing for dirt or debris. Clean the DC con-
nector monthly or more often if needed.

OPERATING THE VEHICLE

Improper use of the vehicle or the lack of proper maintenance may result in damage or decreased
Read the following warnings before attempting to operate the vehicle.
To reduce the possibility of severe injury or death resulting from loss of vehicle control, the fol-
When driving vehicle, consider the terrain, traffic conditions and the environmental factors which
Use extra care and reduced speed when driving on poor surfaces, such as loose dirt, wet grass,
OPERATING PROCEDURES
the ground post.
lowing warnings must be observed:
effect the terrain and the ability to control the vehicle.
performance.
gravel, etc.
Charger Receptacle
21