Fuel Tank Removal; Carb Canister - E-Z-GO TXT FLEET Technician's Repair And Service Manual

Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notices, Cautions, Warnings and Dangers.
have become clogged. The filter should be replaced as
required. See 'Periodic Service Schedule' in Section 'A'.
The filter is marked with a flow direction arrow. Be sure
that the arrow points towards the fuel pump
To prevent possibility of injury from explosion
or fire, never attempt to repair a damaged or
leaking fuel tank. It must be replaced.

FUEL TANK REMOVAL

Tool List
Wrench, 5/16".............................................................. 1
Socket, 5/16" ............................................................... 1
Ratchet ........................................................................ 1
Drip Pan ...................................................................... 1
While wearing eye shield, disconnect the negative battery
wire with a wrapped wrench. Disconnect the fuel line (4)
at the fuel pickup and the line to the CARB canister (5), if
the vehicle is so equipped. Watch for gasoline leakage
from the fuel line, always use a drip pan and dispose of
spent fuel safely.
Remove the forward hex nut (6) and bolt. Remove the
rear nut (7) and bolt.
Remove the tank from the engine compartment
Installation is in reverse order.
6
Fig. 10 Fuel Tank Removal
Qty.
4
5
7
Repair and Service Manual

CARB CANISTER

Tool List
Flat Blade Screwdriver.................................................1
To remove the CARB canister (5) disconnect the hoses
(2 & 3) from the CARB canister and press the tabs (6) on
the mounting bracket and slide the canister upward to
clear the mounting bracket.
To install a CARB canister position the canister ears
above the mounting bracket and push against the
bracket and downward so that the canisters ears slide
into the channels on the bracket. Make sure that the
canister is seated completely and the retaining tabs are
clear of the canister ears then connect the hoses.
6
Fig. 11 CARB Canister
Fig. 12 CARB Hoses
FUEL SYSTEM
(Ref. Fig. 11)
5
1
2
Page H-7
Qty.