E-Z-GO TXT FLEET Technician's Repair And Service Manual page 163

Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notices, Cautions, Warnings and Dangers
Condition
POOR LOW SPEED
PERFORMANCE
POOR MIDRANGE OR HIGH SPEED
PERFORMANCE
ENGINE OVERHEATING
Possible Cause
Plugged gas tank vent
Choke on
Carburetor float level incorrect
Clutches not shifting out
Fuel pump faulty
Insufficient fuel level
Air leak at carburetor gasket
Spark plug fouled
Weak spark
Incorrect valve lash
Belt slipping
Faulty accelerator adjustment
Faulty governor adjustment
Spark plug fouled
Weak spark
Carburetor float not level
Incorrect or plugged main jet
Dirty air filter
Brake dragging
Low compression
Governor not adjusted properly
Faulty accelerator adjustment
Faulty governor adjustment
Foreign matter in cylinder fins and blower
housing
Damaged blower housing or fins
Damaged or plugged muffler
Inadequate oil supply
Heavy loads
Incorrect Fuel
Repair and Service Manual
TROUBLESHOOTING
Correction
Clean or repair
Push choke in
Check/Replace float
Replace clutch/clutches
Repair or replace
Add fuel
Repair component
Clean or replace
Check magneto
Check and adjust
Check belt & clutch surfaces
Replace belt or clean clutches
Check and adjust
Check and adjust
Clean or replace
Check magneto
Adjust
Check size for appropriate altitude. Clean
Clean or replace
Perform brake maintenance
Check engine
Adjust
Check and adjust
Check and adjust
Clean
Replace
Repair or replace
Check oil system, inspect oil pump,
change oil, fill to correct level
Lighten load
Use correct seasonal blend fuel. Do not
use old fuel
Page R-3