Periodic Inspection And Adjustment - Yamaha F15A Service Manual

INSP
ADJ

PERIODIC INSPECTION AND ADJUSTMENT

MAINTENANCE INTERVAL CHART.............................................................3-1
PERIODIC SERVICE.......................................................................................3-2
INSPECTION AND ADJUSTMENT COWLING.......................................3-2
Water separator drain hole ...............................................................3-2
FUEL SYSTEM .........................................................................................3-2
Fuel line ..............................................................................................3-2
Fuel filter replacement ......................................................................3-2
CONTROL SYSTEM.................................................................................3-3
Throttle cables adjustment (MH/EH models) ..................................3-3
Remote control throttle cable adjustment (E models) ...................3-4
Throttle link lever adjustment ..........................................................3-5
Remote control shift cable adjustment (E models) ........................3-6
Shift cable adjustment (FT9.9DMH, FT9.9DEH).......................................3-7
Engine idling speed adjustment (For USA).....................................3-8
Engine idling speed is adjustment (except for USA)......................3-8
Start-in-gear protection device adjustment (MH models) ...........3-10
POWER UNIT .........................................................................................3-11
Engine oil level ................................................................................3-11
Engine oil replacement ...................................................................3-11
Timing belt .......................................................................................3-12
Valve clearance ................................................................................3-12
Ignition timing check.......................................................................3-14
LOWER UNIT .........................................................................................3-15
Gear oil .............................................................................................3-15
Lower unit leakage check................................................................3-16
Trim tab check (for S-transom model) ...........................................3-16
GENERAL ...............................................................................................3-16
Anode ...............................................................................................3-16
Battery (EH/E models) .....................................................................3-17
Spark plugs ......................................................................................3-18
Compression pressure measurement ...........................................3-19
Lubrication points............................................................................3-21
CHAPTER 3
E