Subscribe to Our Youtube Channel
Related Manuals for Delco Dominator Series
Summary of Contents for Delco Dominator Series
-
Page 1: Operators Manual
Pressure Washers and Accessories DOMINATOR SERIES PRESSURE WASHERS Operators Manual Delco Pressure Washers - LIT-DOM-DEL... - Page 2 Should you experience any difficulty with your Delco pressure washer, please contact your nearest Delco Distributor immediately. We are aware of your investment in an Delco pressure washer, therefore, our prime concern is that you be- come one of our “satisfied” owners. Please feel free to send us your comments and ideas.
- Page 3 Pressure Washer Limited Warranty 1. DELCO Cleaning Systems, LLC warrants its products for a period of one year from the date of pur- chase, against defects in material and/or workmanship. The warranty covers parts and labor, but ex- cludes transportation.
-
Page 4: Important Safety Precautions
IMPORTANT SAFETY PRECAUTIONS IMPORTANT: Please read the following instructions before installing and/or operating this equipment. DANGER THIS EQUIPMENT CAN BE HAZARDOUS TO OPERATOR SAFETY AND ONLY AUTHORIZED PERSONNEL WHO HAVE READ AND UNDERSTAND THE INSTALLATION AND OPERATION MANUAL SHOULD BE PERMITTED TO OPERATE THIS EQUIPMENT. DO NOT LEAVE WAND UNATTENDED WHILE EQUIPMENT IS RUNNING. - Page 5 14. Always cool down coil. DO NOT’S DO NOT - UNDER ANY CIRCUMSTANCES - POINT THE HIGH PRESSURE NOZZLE AT YOURSELF, OTHER PEOPLE, OR ANIMALS! 1. DO NOT use an undersized discharge nozzle. 2. DO NOT disconnect the pressure hoses or wand while the equipment is HOT, PRESSURIZED or RUNNING.
-
Page 6: Installation
INSTALLATION 1. LOCATION Avoid operating units in small areas or near ex haust fans. Adequate oxygen is needed for combustion or dangerous carbon monoxide will result. Stationary units should be installed in accordance with local plumbing and heating codes. 2. FUEL SUPPLY Oil Fired Units: Fill fuel tank with clean kerosene, No. -
Page 7: Operating The Machine
OPERATING THE MACHINE PRE-OPERATING INSTRUCTIONS 1. Connect the swivel end of the discharge hose to the cleaning gun. 2. Attach the hose to the machine outlet. 3. Check the fuel level in the fuel tank. Add fuel if required. It is best to keep fuel tank full during nonworking conditions. -
Page 8: Shut Down Instructions
SHUT DOWN INSTRUCTIONS 1. If the burner is on, set the switch to the OFF position 2. Run water through the pump until cool water flows from the cleaning gun. Failure to do this could result in increased coil scaling. 3. -
Page 9: Maintenance Of Components
MAINTENANCE OF COMPONENTS PUMPS 1. Refer to pump section in this manual for your model of equipment. 2. Change pump oil after the first 25 hours of use. Subsequent changes should be every 250 hours or 3 months, whichever comes first. A. - Page 10 6. FUEL PUMP: To bleed air out of fuel pump, open air bleed valve on side of fuel pump. Turn machine and burner ON. When fuel looks clear (NOT FOAMING), close air bleeding valve. Air is out of fuel lines and fuel pump. A.
- Page 11 To clean o soot, add Red Devil Soot Remover, using manufactures mixing instructions, or remove coil and clean thoroughly, or Call a Factory Authorized DELCO Dealer. DE-LIMING OR DE-SCALING OF COIL In hard water areas, or when using the wrong kind of soap, lime build-up inside the coil pipe will occur.
-
Page 12: Diagnosis And Maintenance
DIAGNOSIS AND MAINTENANCE PROBLEM PROBABLE CAUSE SOLUTION Low Pressure Worn nozzle Replace nozzle of proper size. Belt slippage. Tighten or replace; use correct belt. Air leak in inlet plumbing. Use PTFE liquid or tape. Pressure gauge inoperative or not Check pressure with new guage and replace as needed. registering accurately. - Page 13 NOTES:...
- Page 14 1111 E. Lake Francis Dr., Siloam Springs, AR 72761 • 800-BUY-DELCO...
Need help?
Do you have a question about the Dominator Series and is the answer not in the manual?
Questions and answers