Page 1
RX-E100RSL/RX-E100RSB SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-E100RSL RX-E100RSB Area Suffix RX-E100RSL U.K. Continental Europe Northern Europe AUDIO RX-E100RSB SLEEP TV DIRECT Continental Europe ANALOG/DIGITAL TAPE INPUT SOUND BASS+ CENTER Northern Europe BASS– REAR-L TEST BASS BOOST TREBLE+ REAR-R EFFECT TREBLE–...
Page 2
RX-E100RSL/RX-E100RSB 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only.
Page 3
RX-E100RSL/RX-E100RSB Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body. Remove the top cover from behind in the direction of Fig.1...
Page 4
RX-E100RSL/RX-E100RSB Removing each board connected to the rear side of the audio board (See Fig.5 to 7) Prior to performing the following procedure, remove the top cover and the rear panel. Cut off the tie band fixing the harness. CN111...
Page 5
RX-E100RSL/RX-E100RSB Removing the audio board (See Fig.8) Main board CN517 CN516 Prior to performing the following procedure, remove CN515 the top cover , the rear panel and the each board. power supply board CN411 Disconnect the card wire from connector CN411 on the audio board.
Page 6
RX-E100RSL/RX-E100RSB Removing the power supply board (See Fig.12) Power supply board Prior to performing the following procedure, remove CN204 the top cover. Disconnect the card wire from connector CN204 on PW201 the power supply board. PW203 CN707 Solder Disconnect the harness connected to connector...
Page 7
RX-E100RSL/RX-E100RSB Removing the system control board / Power switch power switch board (See Fig.14) board Prior to performing the following procedure, remove the top cover and the front panel assembly. Remove the two screws P attaching the power switch board.
Page 8
RX-E100RSL/RX-E100RSB Adjustment method Power amplifier section Adjustment of idling current Measurement terminal B451-B452(Lch) , B453-B454(Rch) Adjustment volume VR301(Lch) , VR302(Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
Page 10
RX-E100RSL/RX-E100RSB Pin function (2/2) AK4527(1/2) No Connect Pin name Function No internal bonding. Analog Input Format Select Pin "H" : Full-differential input, "L" : Single-ended input ADIF Chip Address 1 Pin Chip Address 0 Pin CAD1 DAC3 Lch Analog Output Pin...
Page 11
RX-E100RSL/RX-E100RSB UPD784215AGC103 (IC671) : UNIT CPU 1.Pin layout 2.Pin function Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock Connect to GND Connecting the crystal oscillator for system sub clock...
Page 12
RX-E100RSL/RX-E100RSB TC9446F-014 (IC631) : Digital signal processor for dolby digital (AC-3) / MPEG2 audio decode Pin No. Symbol Function Reset signal input terminal (L:reset H:Operation usually) Microcomputer interface mode selection input terminal (L:serial H:IC bus) MIMD Microcomputer interface chip select input terminal...
Page 14
RX-E100RSL/RX-E100RSB MN101C35DHR (IC401) : System controller Pin function (1/2) Symbol Function Pin No. TXD/SB00/P00 RXD/SBI0/P01 SBT0/P02 PROTECTOR INPUT SB01/P03 SBI1/P04 SBT1/P05 GND (TV LINK INPUT) BUZZER/P06 SLOW SW L INPUT POWER SUPPLY +5V 9,10 OSC1,2 OSC (8MHz) OPEN MMOD VREF-...
Page 15
RX-E100RSL/RX-E100RSB Pin function (2/2) Symbol Function Pin No. SBT2/P32 DSP MICON CLK DSP MICON READY DSP MICON RESET M61501 CLK M61501 DATA M61501 LATCH DGT17/P67 VIDEO SELECT 1 DGT14/P64 VIDEO SELECT 4 DGT13/P63 GRID 1 DGT10/P60 GRID 4 DGT9/P41 GRID 5...
Page 16
RX-E100RSL/RX-E100RSB BU2092 (IC642) : Port expander 1.Terminal Layout DATA CLOCK CONTROL CIRCUIT 2.Pin Function Symbol Function Pin No. Connect to GND DATA Serial Data input CLOCK Shift Clock of Data Latch Clock of Data 5~16 Q0~Q11 Parallel Data Output Latch Data...
Page 17
RX-E100RSL/RX-E100RSB NJM2246M (IC511,IC512,IC513) : Video switch Block diaglam Vout Vin3 INPUT CONTROL SIGNAL- OUTPUT SIGNAL CTL1 CTL2 OUTPUT SIGNAL Vin1 Vin2 AMP. L/ H Vin3 BIAS Vin1 CTL1 Vin2 CTL2 NJM2267M (IC516) : Video switch 1. Pin layout 2. Block diaglam...
Page 19
RX-E100RSL/RX-E100RSB VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.20951) 200105(V)
Page 20
RX-E100RSL/RX-E100RSB LVA10231-2 Block diagram LVA10009-1 TV AUDIO IN AUDIO OUT IC191 IC511 TV R/C,G,B,Y/V,YS OUT IC512 AM/FM DET TUNER IC102 RF101 TUNER L/R IC513 (R/C) IC514 (Y/V) MW RF&OSC LINK PLL CLK, IC121 VCR AUDIO IN T111 PLL DATA, PLLCE...
Page 24
RX-E100RSL/RX-E100RSB Audio signal input terminal section DSP signal TUNER signal TV Audio signal FRONT signal SUB WOOFER signal VCR Audio signal CENTER signal DVD Audio signal CN601 SURROUND signal CN511 CN501 CN502 R535 R536 CN504 CN514 D.GND RDS_DAVN RDS_SDA RDS_SCL...
RX-E100RSL/RX-E100RSB PARTS LIST [ RX-E100RSL ] [ RX-E100RSB ] * All printed circuit boards and its assemblies are not available as service parts. RX-E100RSL Area suffix B ------------------------------- U.K. E ----------- Continental Europe EN ------------ Northern Europe RX-E100RSB Area suffix...
Page 36
RX-E100RSL/RX-E100RSB Exploded view of general assembly and parts list Block No. Power/Fuse DSP board board Speaker board Power trans board Relay Signal input board board Tuner board Main board Relay board Audio board Power supply board Switch board System control...
Page 37
RX-E100RSL/RX-E100RSB Parts list (General assembly) Parts list (General assembly) Block No. M1MM Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10482-001A FRONT PANEL QYSBSGY3008M SPECIAL SCREW SCART 2 VJD5429-002SS...
Page 38
RX-E100RSL/RX-E100RSB Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 818 QETN1CM-107Z E CAPACITOR 100MF 20% 16V...
Page 39
RX-E100RSL/RX-E100RSB (Power amp board) Electrical parts list Block No. 01 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area D 307 1SS133-T2 SI DIODE Q 319 KTA1268/GL/-T TRANSISTOR D 308 1SS133-T2 SI DIODE Q 320...
Page 40
RX-E100RSL/RX-E100RSB Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area R 836 QRE141J-101Y C RESISTOR 100 5% 1/4W R 323 QRJ146J-100X UNF C RESISTOR 10 5% 1/4W...
Page 41
RX-E100RSL/RX-E100RSB (Main & System control board) Electrical parts list Block No. 02 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area BK401 LV32554-001A FL HOLDER(L) CN513 QGB2510K1-12 CONNECTOR BK402 LV32555-001A FL HOLDER(R) CN514 QGB2510K1-04 CONNECTOR...
Page 42
RX-E100RSL/RX-E100RSB Electrical parts list (Main & System control board) Block No. 02 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area Q 413 DTA114EKA-X D TRANSISTOR R 448 NRSA63J-152X MG RESISTOR Q 702 KTC3200/GL/-T TRANSISTOR...
Page 43
RX-E100RSL/RX-E100RSB Electrical parts list (Main & System control board) Block No. 02 Item Remarks Parts number Parts name Area R 728 NRSA63J-472X MG RESISTOR R 729 NRSA63J-223X MG RESISTOR R 730 NRSA63J-153X MG RESISTOR R 731 NRSA63J-223X MG RESISTOR R 732...
Page 44
RX-E100RSL/RX-E100RSB Electrical parts list (Audio signal input board) Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 501 NCS31HJ-331X C CAPACITOR C 591 NCS31HJ-220X C CAPACITOR C 502 NCS31HJ-331X C CAPACITOR...
Page 45
RX-E100RSL/RX-E100RSB (Audio signal input board) Electrical parts list Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area D 517 MTZJ13C-T2 Z DIODE Q 525 DTA114EKA-X D TRANSISTOR D 518 MTZJ13C-T2 Z DIODE...
Page 46
RX-E100RSL/RX-E100RSB Electrical parts list (Audio signal input board) Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area R 549 NRSA63J-103X MG RESISTOR R1523 NRSA63J-331X MG RESISTOR R 550 NRSA63J-103X MG RESISTOR R1524...
Page 47
RX-E100RSL/RX-E100RSB Electrical parts list (DSP board) Block No. 04 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 601 NCB31HK-221X C CAPACITOR C2515 NCS31HJ-121X C CAPACITOR C 602 NCB31HK-221X C CAPACITOR C2516 NCS31HJ-121X C CAPACITOR...
Page 48
RX-E100RSL/RX-E100RSB Electrical parts list (DSP board) Block No. 04 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area IC690 BA15218F-XE R 679 NRSA63J-822X MG RESISTOR IC691 BA15218F-XE R 680 NRSA63J-822X MG RESISTOR J 601 QNN0347-001...
Page 49
RX-E100RSL/RX-E100RSB Electrical parts list (DSP board) Block No. 04 Item Remarks Parts number Parts name Area R2566 NRSA63J-302X MG RESISTOR R2567 NRSA63J-103X MG RESISTOR R2568 NRSA63J-103X MG RESISTOR R2575 NRSA63J-102X MG RESISTOR R2576 NRSA63J-102X MG RESISTOR R2577 NRSA63J-104X MG RESISTOR...
Page 50
RX-E100RSL/RX-E100RSB Electrical parts list (Tuner board) Block No. 05 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area AT101 QNB0014-001 ANT TERMINAL Q 102 2SC535/BC/-T TRANSISTOR BK 1 LV31618-001A SHIELD BKT Q 103 2SC461/BC/-T TRANSISTOR...
Page 51
RX-E100RSL/RX-E100RSB Packing materials and accessories parts list Block No. Block No. Ver.E/EN A2 A8 Ver.B A2 A8 3-18...
Page 52
RX-E100RSL/RX-E100RSB Parts list (Packing) Block No. M2MM Item Parts number Parts name Q'ty Description Area E, EN LV20978-006A CARTON BOX RX-E100RSL E, EN LV20978-007A CARTON BOX RX-E100RSB LV20978-001A CARTON BOX RX-E100RSL LV20963-001A CUSHION(FRONT) LV20964-001A CUSHION(REAR) LV32804-001A PACKING SHEET QPC06507015P POLY BAG...