Page 1
RX-7010RBK/RX-7012RSL SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-7010RBK RX-7012RSL Area Suffix Continental Europe Northern Europe CATV/DBS AUDIO DVD MUILTI FM/AM TV/DBS TAPE/CDR PHONO − BASS − TREBLE SURROUND ANALOG/DIGITAL SLEEP ON/OFF MODE INPUT BASS BOOST EFFECT + CENTER – MENU TEST + REAR•L –...
Page 2
RX-7010RBK/RX-7012RSL 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only.
Page 3
RX-7010RBK/RX-7012RSL Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body. Remove the top cover from behind in the direction of Fig.1...
Page 4
RX-7010RBK/RX-7012RSL Removing each board connected to the rear side of the audio board CN411 Tie band CN412 (See Fig.5 to 8) Prior to performing the following procedure, remove the top cover and the rear panel. Audio board Tie band Cut off the tie band fixing the harness.
Page 5
RX-7010RBK/RX-7012RSL Removing the audio board (See Fig.9) Relay board CN385 Prior to performing the following procedure, remove the top cover and the rear panel. power supply Disconnect the card wire from connector CN402 on board the audio board. CN473 CN291 Disconnect the relay board from the audio board and the power supply board.
Page 6
RX-7010RBK/RX-7012RSL Removing the power transformer (See Fig.13) Prior to performing the following procedures, remove the top cover. Power Power transformer Unsolder the two harnesses connected to the power supply board board transformer. FW201 Disconnect the harness from connector CN251 and...
Page 7
RX-7010RBK/RX-7012RSL Removing the system control board / Operation switch panel Front panel assembly power switch board (See Fig.16 to 18) Prior to performing the following procedure, remove the top cover and the front panel assembly. Pull out the volume knob on the front side of the front panel and remove the nut attaching the system control board.
Page 8
RX-7010RBK/RX-7012RSL Adjustment method Tuner section 1.Tuner range 87.5MHz~108.0MHz AM (MW) 522kHz~1629kHz (LW) 144kHz~ 288kHz Power amplifier section Adjustment of idling current Measurement location TP301(Lch) , TP302(Rch) Adjustment part VR301(Lch) , VR302(Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
Page 9
RX-7010RBK/RX-7012RSL Description of major ICs SAA6588 (IC191) : RDS detector 2.Pin Function 1.Terminal Layout Symbol Function Multi-path rectifier output Non connect Test control input pin SCOUT Oscillator output OSCO OSCO Vref Oscillator input OSCI OSCI Digital ground (0V) VSSD Digital power supply (5V)
Page 15
RX-7010RBK/RX-7012RSL 2.Pin Function Pin No. Symbol Descriptions SURROUND SURROUND control terminal BASS BOOST BASS BOOST control terminal INPUT-ATT Input attenuator control terminal MUTING control terminal MUTING AVDD Analog positive power supply terminal SUB Woofer volume signal input terminal SWIN A.GND...
Page 16
RX-7010RBK/RX-7012RSL MN101C35DHK1 (IC701) : System controller Pin function (1/2) Symbol Function Pin No. TXD/SB00/P00 VOL.JOG IN_1 RXD/SBI0/P01 VOL.JOG IN_2 SBT0/P02 DATA (PLL) SB01/P03 (PLL) SBI1/P04 (PLL) SBT1/P05 VIDEO S/C DVD BUZZER/P06 VIDEO S/C VCR Power supply +5V 9,10 OSC1,2 OSC (8MHz)
Page 17
RX-7010RBK/RX-7012RSL Pin function (2/2) Symbol Function Pin No. (DSP) SBT2/P32 READY (DSP) RESET (DSP) RELAY S RELAY C RELAY L/R 1 RELAY L/R 2 DGT17/P67 RELAY HEADPHONE DGT16/P66 FL GRID SIGNAL CONTROL OUT FL SEGMENT SIGNAL CONTROL OUT No Connect...
Page 18
RX-7010RBK/RX-7012RSL TC9446F-014 (IC631) : Digital signal processor for dolby digital (AC-3) / MPEG2 audio decode Pin No. Symbol Function Reset signal input terminal (L:reset H:Operation usually) MIMD Microcomputer interface mode selection input terminal (L:serial H:IC bus) Microcomputer interface chip select input terminal...
Page 19
RX-7010RBK/RX-7012RSL UPD784215AGC103 (IC671) : UNIT CPU 1.Pin layout 2.Pin function Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock Connect to GND Connecting the crystal oscillator for system sub clock...
Page 20
RX-7010RBK/RX-7012RSL VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.20938) 200104(V)
Page 21
RX-7010RBK/RX-7012RSL PARTS LIST [ RX-7010RBK ] [ RX-7012RSL ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix E ----------- Continental Europe EN ------------ Northern Europe - Contents - Exploded view of general assembly and parts list...
Page 23
RX-7010RBK/RX-7012RSL Exploded view of general assembly and parts list Block No. Power trans board Speaker Power trans board board Power/Fuse board Relay board Main board Audio board power switch board Power supply board System control board...
Page 24
RX-7010RBK/RX-7012RSL Parts list (General assembly) Block No. M1MM Parts list (General assembly) Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10457-004A FRONT PANEL RX-7012RSL QYSBSG3006Z T.SCREW H.S-C.B LV10457-003A FRONT PANEL...
Page 25
RX-7010RBK/RX-7012RSL Block No. 01 Electrical parts list (Power amp board) Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 811 QCS31HJ-100Z C CAPACITOR 10PF 5% 50V...
Page 26
RX-7010RBK/RX-7012RSL Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area D 219 1SR139-400-T4 DIODE Q 308 KTC3200/GL/-T TRANSISTOR D 220 1SR139-400-T4 DIODE Q 309 2SD637/QR/ TRANSISTOR...
Page 27
RX-7010RBK/RX-7012RSL Electrical parts list Block No. 01 (Power amp board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area R 312 QRJ146J-391X UNF C RESISTOR 390 5% 1/4W R 803 QRE141J-563Y C RESISTOR 56K 5% 1/4W...
Page 28
RX-7010RBK/RX-7012RSL Electrical parts list (Power amp board) Block No. 01 Item Remarks Parts number Parts name Area R 915 QRJ146J-331X UNF C RESISTOR 330 5% 1/4W R 921 QRJ146J-100X UNF C RESISTOR 10 5% 1/4W R 923 QRJ146J-100X UNF C RESISTOR...
Page 29
RX-7010RBK/RX-7012RSL (Main board) Electrical parts list Block No. 02 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 400 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V C1301 QFZ9076-104Z MM CAPACITOR .10MF C 401 QETN1HM-475Z E CAPACITOR 4.7MF 20% 50V...
Page 30
RX-7010RBK/RX-7012RSL Electrical parts list Block No. 02 (Main board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area IC402 TC9164AN R 441 QRE141J-104Y C RESISTOR 100K 5% 1/4W IC403 BA15218N R 442 QRE141J-104Y C RESISTOR...
Page 31
RX-7010RBK/RX-7012RSL Electrical parts list (Main board) Block No. 02 Item Remarks Parts number Parts name Area R1362 QRE141J-472Y C RESISTOR 4.7K 5% 1/4W R1363 QRE141J-472Y C RESISTOR 4.7K 5% 1/4W R1364 QRE141J-223Y C RESISTOR 22K 5% 1/4W R1365 QRE141J-682Y C RESISTOR 6.8K 5% 1/4W...
Page 32
RX-7010RBK/RX-7012RSL (System control & Audio board) Electrical parts list Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area BK701 LV42093-001A FL HOLDER(L) C1415 NCB31HK-101X C CAPACITOR BK702 LV42092-001A FL HOLDER(R) C1416 QETN1HM-474Z E CAPACITOR .47MF 20% 50V...
Page 33
RX-7010RBK/RX-7012RSL (System control & Audio board) Electrical parts list Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area IC427 BA15218F-XE R 486 NRSA63J-104X MG RESISTOR IC428 M62446FP-X R 487 NRSA63J-102X MG RESISTOR...
Page 34
RX-7010RBK/RX-7012RSL Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area R 754 NRSA63J-152X MG RESISTOR R1432 NRSA63J-103X MG RESISTOR R 757 NRSA63J-103X MG RESISTOR...
Page 35
RX-7010RBK/RX-7012RSL (System control & Audio board) Electrical parts list Block No. 03 Item Remarks Parts number Parts name Area S 736 QSW0683-001Z PUSH SWITCH S 737 QSW0683-001Z PUSH SWITCH S 738 QSW0683-001Z PUSH SWITCH S 739 QSW0683-001Z PUSH SWITCH TAPE/CDR...
Page 36
RX-7010RBK/RX-7012RSL (DSP board) Electrical parts list Block No. 04 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 601 NCB31HK-102X C CAPACITOR C2508 NCS31HJ-330X C CAPACITOR C 602 NCB31HK-102X C CAPACITOR C2512 NCF31CZ-104X C CAPACITOR...
Page 37
RX-7010RBK/RX-7012RSL (DSP board) Electrical parts list Block No. 04 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area IC672 TC7SET32FU-X R 674 NRSA63J-432X MG RESISTOR IC681 PQ3DZ53-X R 675 NRSA63J-432X MG RESISTOR IC682 IMX9-W TRANSISTOR...
Page 38
RX-7010RBK/RX-7012RSL Electrical parts list Block No. 04 (DSP board) Item Remarks Parts number Parts name Area R2561 NRSA63J-104X MG RESISTOR R2562 NRSA63J-104X MG RESISTOR R2563 NRSA63J-103X MG RESISTOR R2564 NRSA63J-103X MG RESISTOR R2565 NRSA63J-202X MG RESISTOR R2566 NRSA63J-202X MG RESISTOR...
Page 39
RX-7010RBK/RX-7012RSL Electrical parts list (Tuner board) Block No. 05 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area AT101 QNB0014-001 ANT TERMINAL Q 102 2SC535/BC/-T TRANSISTOR BK 1 LV31618-001A SHIELD BKT Q 103 2SC461/BC/-T TRANSISTOR...
Page 40
RX-7010RBK/RX-7012RSL Packing materials and accessories parts list Block No. Block No. A2~A6 3-20...
Page 41
RX-7010RBK/RX-7012RSL Parts list (Packing) Block No. M2MM Item Parts number Parts name Q'ty Description Area QPA02503505P POLY BAG FOR INST LV20983-011A CARTON BOX RX-7010RBK LV20983-013A CARTON BOX RX-7012RSL LV20925-001A PACKING PAD LV20926-001A PACKING PAD QPC06507015P POLY BAG FOR SET Parts list (Accessories) Block No.