Summary of Contents for HearthStone Manchester 8360
Page 1
Manchester (Model 8360) Woodstove OWNER'S MANUAL Installation And Operating Instructions SAVE THIS OWNER’S MANUAL FOR FUTURE REFERENCE PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL AND USE YOUR NEW MANCHESTER WOOD STOVE. If this room heater is not properly installed, a house fire may result. To reduce the risk of fire, follow the installation instructions.
Page 2
Intentionally Blank Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Install the stove in your central living area to allow heat to radiate naturally to distant rooms. Do not install your stove in a poorly insulated area. This is inefficient and would likely result in higher fuel usage. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
5. There is excessive condensation on windows in the winter. Never use a wood grate or other device to 6. A ventilation system is installed in elevate the fire. the house. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Inspect the stove, stovepipe, and chimney thoroughly for any sign of damage before firing the stove again. You must correct any damage before using your stove again. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
15 to 36 lbs. per cubic foot depending on type of wood, moisture content, packing density and other factors. Figure 1 – Manchester Dimensions (Shown with optional blower) Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
If the floor is made of combustible material, then a non-combustible floor protector is required between the floor and the stove. An example of a non- Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Installations in Canada require 18” (45.72 cm) of floor protection on both side and front. Rear clearance required only if stovepipe runs horizontally back above the top or behind the stove. Figure 2 – Hearth Dimensions Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
*SIDE WITH DOOR MUST BE 18” FROM SIDE WALL UNLESS THE SIDE DOOR LOCKING KIT IS INSTALLED. CONSIDER SPACE FOR LOADING OF STOVE USING THE SIDE DOOR. FOR CLOSE CLEARANCE HEAT SHIELD, USE KIT #93-68600 Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
*For double wall pipe clearance to ceiling refer to pipe manufacturer specifications. ** Close Clearance Heatshield, kit #93- 68600 See Parallel Clearance to Combustibles for clearances to the sides of the stove. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 12
Chimney Connector Systems and Clearances Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
When considering Hearthstone recommends the termination be at the placement of the duct from the outside of the house same level, or lower than the air intake on the stove.
Disregarding the screws can cause joints to venting system. Upon inspection, immediately separate from the vibrations that result from a replace rusted, cracked, or broken components. creosote chimney fire. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 15
If the chimney needs repair, complete There are two ways to install a prefabricated metal them before installing and using your stove. Do not chimney: install your stove until the chimney is safe for use. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 16
(these installation has a required chimney height that keep the liner warmer for better performance) provides too much draft. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 17
Figure 7 – Typical Chimney Configurations Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 18
2'-0" 2'-0" MINIMUM MINIMUM 3'-0" 3'-0" MINIMUM MINIMUM 10'-0" Figure 8 – Chimney Height Requirements Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
CAUTION: MAINTAIN THE STRUCTURAL Figure 10 INTEGRITY OF THE MOBILE HOME WALLS, FLOOR, CEILING, AND ROOF WHEN INSTALLING AND USING YOUR STOVE. CAUTION: REMOVE THE CHIMNEY WHEN TRANSPORTING THE MOBILE HOME! Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
HOOSING IREWOOD Burn only natural firewood (known as cordwood) in the Manchester 8360 Wood Heater. This stove is not designed to burn other fuels. Medium CAUTION: CHEMICALS FLAMMABLE FLUIDS TO START THE FIRE. DO Juniper, Rocky Mtn 3,150 21.8...
If you adhere to the operating procedures in this The air control does not close completely. manual, steel, cast iron, refractory Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 24
35 to 45 minutes to fully heat the stovepipe the accumulation of creosote. Inspect the venting and chimney. system frequently using burn rates consistently. Figure 14 AIR CONTROL POSITIONS Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 25
THE FRONT DOOR, SIDE DOOR AND ASH PAN can remain hot for several days once removed DOOR MUST REMAIN CLOSED WHEN from the firebox. OPERATION EXCPET FOR START UP AND LOADING. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
12. After 5 or 6 fires, check the glass retainer screws, and retighten if necessary. Required Glass Kit: Part Number: 90-58901 (Glass with gasket applied). Use only 5mm Ceramic IR, or Neoceram IR glass. Contact your Hearthstone dealer. Hearthstone Quality Home Heating Products, Inc ®...
We recommend that before each heating season Required Glass Kit: PN: 93-58300 (Glass with you have the entire system professionally inspected, gasket applied). cleaned and repaired, if necessary. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Do not over-fire the stove. Monitor stove temperatures. Use FINISH seasoned wood only. Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
5360-060 SIDE DOOR HINGE CLIP 5360-062 FRONT DOOR HINGE (NO PIN) 5360-071 SECONDARY AIR PIPE #1 5360-072 SECONDARY AIR PIPE #2 5360-073 SECONDARY AIR PIPE #3 5360-085 TOP HEAT SHIELD Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Hearthstone Quality Home Heating Products, Inc. Warranty Department 317 Stafford Avenue Morrisville, VT 05661 NOTE: SENDING IN THE SIGNED WARRANTY REGISTRATION FORM IS NOT REQUIRED AS A CONDITION OF WARRANTY COVERAGE OR HEARTHSTONE’S PERFORMANCE. Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...
Page 33
Notes: Hearthstone Quality Home Heating Products, Inc ® Manchester Model 8360...