This document discloses subject matter in which Bayliner has proprietary rights. The information and design disclosed herein were originated by and are the prop- erty of Bayliner. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therein, or to construct boats or any item from it, except by written permission from or written agreement with Bayliner.
CONTENTS Chapter 1: Welcome Aboard Chapter 2: Components/Systems Dealer Service Electrical System 12 Volt DC System - Fuses and Circuit Boating Experience Breakers Safety Standards Battery Charger Shore Power/110 Volt AC System Engine & Accessories Guidelines Fresh Water System Qualified Maintenance Water Heater Structural Limitations 110-Volt AC/12-Volt DC Refrigerator...
Page 6
Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this supplement to call attention to potentially dan- gerous situations which could lead to either personal injury or product damage. Read ALL warnings carefully and follow all safety instructions. DANGER! This box alerts you to immediate hazards which WILL cause severe personal injury or death if the warning is ignored.
• Contact your dealer if you have any problems with your new boat. • If your dealer cannot help, call our customer service hotline: 360-435-8957 or send us a FAX: 360-403-4235. • Buy replacement parts from any authorized Bayliner dealer. Boating Experience WARNING! CONTROL HAZARD! A qualified operator must be in control of the boat at all times.
• CHAPTER 1: WELCOME ABOARD Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Safety Standards DANGER! DANGER PERSONAL SAFETY HAZARD! DO NOT allow anyone to ride on parts of the boat not designated for such use. Sitting on seat backs, lounging on the forward deck, bow riding, gunwale riding or occupying the transom platform while underway is especially hazardous and will cause personal injury or death.
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 1: WELCOME ABOARD Structural Limitations If equipped, the transom platform and bow platform are designed to be lightweight for proper boat balance. The load limit for these platforms is 30 pounds per square foot, evenly distributed.
• CHAPTER 1: WELCOME ABOARD Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Carbon Monoxide (CO) DANGER! CARBON MONOXIDE POISONING HAZARD! DANGER Carbon monoxide gas (CO) is colorless, odorless, and extremely dangerous. All engines, generators, and fuel burning appliances produce CO as exhaust. Direct and prolonged exposure to CO will cause BRAIN DAMAGE or DEATH.
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 1: WELCOME ABOARD Sources of CO Sources of CO include: a. Using engine or generator when boat is moored in a confined space. b. Mooring close to another boat that...
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Chapter 2: Components/Systems Electrical System We strongly recommend that you read and understand the Electrical Section of the Owner’s Manual. DANGER E X T R E M E F IR E /E X P L O S IO N H A Z A R D ! •...
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS 12 Volt DC System - Fuses and Circuit Breakers Both the engine and accessory circuits are protected by a large circuit breaker located on the engine. In addition, a fuse block for branch accessory circuits is located behind the helm panel.
Page 14
• CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement WARNING F IR E /E X P L O S IO N /S H O C K /E L E C T R IC A L S Y S T E M...
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Fresh Water System Fresh water systems are available on some models. These pressure-type (demand) systems operate when the water pump switch (located near the sink in the cuddy cabin) is in the ON position. Turn the pump switch OFF when the boat is not in use and when the water tank is empty.
• CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Alcohol or Alcohol/Electric Stove Operating instructions for the alcohol or alcohol/electric stove can be found in the boat’s owner’s packet. Carefully read and follow the manufacturer’s operating instructions and warnings before using the stove.
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Navigation and Interior Lights We strongly recommend that you understand navigation light usage by reading the navigation section of the Owner’s Manual. The navigation and interior lights supplied with your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1.
• CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Portable toilet Your boat may come equipped with a portable toilet. Be sure to read and carefully follow the manufacturer’s operat- ing instructions included in your boat’s owner’s packet.
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Fuel System WARNING FIRE/EXPLOSION HAZARD - It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling. For your safety and the safety of your passengers, the fueling instructions in the Owner’s Manual must be carefully followed.
• CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Fuel Filters All tanks are equipped with a fine mesh screen filter on the fuel pickup tube (located inside or on the outside of the tank) to the fuel line fitting. In addition, when supplied by the engine manufacturer, and additional filter is installed on the engine.
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 2: COMPONENTS/SYSTEMS Bilge Pumps Your boat is equipped with two impeller-type bilge pumps. They are controlled by a switch on the dash panel, which should be activated whenever water begins to accumulate in the bilge. Some models will also have an automatic bilge pump switch (“autofloat switch”), mounted next to the bilge pump.
• CHAPTER 2: COMPONENTS/SYSTEMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Autofloat Switch If applicable, the autofloat switch TYPICAL FLOAT SWITCH should also be checked often for proper operation. Lift the float by turning the plastic insert where the wires enter the housing, 1/4 turn counter-clockwise (Fig.
Page 29
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Fresh Water System Option PORT HULLSIDE GALLEY BACKSIDE TO COLD WATER TO HOT WATER FAUCET FAUCET (OPTION) PORT TO GALLEY TO TRANSOM SHOWER WATER HEATER TO THRU-HULL FROM SINK DRAIN AFT BILGE &...
Page 30
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Air Conditioning Option SEA WATER A/C WATER PICKUP STRAINER PUMP SEACOCK CONTROL AFT BERTH PANEL VENT DRAIN INTO VENT BILGE A/C UNIT ENTRY STEPS TO THRU-...
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Electrical Routing DECK ELECTRICAL ROUTING DINETTE LIGHTS DASH HARNESS STEREO FUSE BLOCK V-BERTH LOCATION LIGHT HARD TOP WIPERS DINETTE LIGHT HEAD LIGHT CABIN GALLEY LIGHTS SPEAKERS...
Page 33
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Fresh Water/Marine Head System PORT FWD SIDE OF HEAD PICKUP BULKHEAD VIEW SEACOCK TO FAUCET HEAD TO WASTE TANK BILGE PUMP FRESH WATER TANK TO FAUCET...
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Helm Area FUSEBLOCK WINDLASS SWITCH (OPTION) WASTE PUMP SWITCH Air Conditioning System AIR CONDITIONING AIR CONDITIONING ROUTING WATER PICKUP TO HANGING LOCKER TOP TO AFT STATE ROOM...
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Marine Head System DOCKSIDE PUMP- TANK VENT OUT DECK FITTING THRU-HULL MARINE HEAD HOLDING TANK MARINE HEAD TO HOLDING TANK MACERATOR SEAWATER PICKUP TO MARINE HEAD...
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement 2859 Express (SC) Layout View Fuel Capacity Overall Bridge Maximum Water Tank Holding Tank Beam Length Clearance Draft Capacity (gal) Capacity (gal) (gal) 27’ 8” 9’ 1”...
Page 45
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Marine Head System TO VENT WATER THRU-HULL HOSE TANK TO MACERATOR HOLDING TANK HEAD TO TANK HEAD TO HOLDING TANK DECK WASTE TANK VENT TANK VENT...
Page 46
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Fresh Water System WATER FILL WATER DECK FITTING HEATER TANK VENT HOT FROM WATER HEATER HOT TO HOT TO HEAD SINK COLD TO HEAD HEATER COLD TO...
Page 47
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Shower Drain System FROM SHOWER DRAIN TO PUMP FROM PUMP TO THRU-HULL FILTER PORT STBD SHOWER PUMP SHOWER PUMP Galley Sink Drain GALLEY GALLEY COLD SINK...
Page 48
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Deck 12 Volt DC Wire Routing COCKPIT DASH LIGHT INTERIOR LIGHT HEAD LIGHT (TYPICAL PORT/STBD) INTERIOR TO WINDLASS COMPASS LIGHTS MAIN SWITCH WIPER TO WINDLASS TO BREAKER TOGGLE SWITCH &...
Page 49
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement CHAPTER 3: DRAWINGS & DIAGRAMS Hull 110 Volt AC Harness REFRIGERATOR AFT HANGING LOCKER OUTLET OUTLET TO BATTERY CHARGER HEAD OUTLET TO GALLEY TO DECK Air Conditioning Routing SEAWATER PUMP STRAINER...
Page 50
• CHAPTER 3: DRAWINGS & DIAGRAMS Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Helm Area WINDLASS TOGGLE SWITCH MACERATOR PANEL WINDLASS PANEL Fuel System FUEL FILL DECK FITTING FUEL VENT THRU-HULL FUEL FEED FUEL HOSE TANK...
• Ciera 22’ to 28’ Cruisers Owner’s Manual Supplement Chapter 4: Wiring Diagrams Please read the electrical sections included in the Owner’s Manual and this Owner’s Manual Supplement for impor- tant safeguards concerning your boat’s electrical system. 2252 Express (CP)
LIMITED WARRANTY AND ALLOW US AN OPPORTUNITY TO RESOLVE THE MATTER. We require that you return your boat, at your expense, to your selling dealer or, if necessary, to the Bayliner factory. You will be responsible for all transportation, haulouts and other expenses incurred in returning the boat for warranty service.