Heatmaster DG-SS-18/24/30NG Installation Instructions Manual

American gas log outdoor burner/hearth kits

Advertisement

HEATMASTER, LLC
AMERICAN GAS LOG
Models:
DG-SS-18/24/30NG
AGL-SS-18/24 NG
H-SS-24NG
HM2-SS-24NG
Outdoor Burner/Hearth Kits
For use use with Natural gas only
Check with your local building code agency before you begin installation to ensure compliance with local codes, including
the need for permits and follow-up inspections. If you encounter any problems regarding code approvals, or if you need clar-
ification of any of the instructions contained here, contact the Technical Services Dept., 919.331.0078 or 919.331.0079.
Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING
If the information in these instruc-
tions is not followed exactly, a
fire may result causing property
damage, personal injury, or death.
• Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of
this or any other appliance.
• What to do if you smell gas:
- Do not try to light any appliance.
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas
supplier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or
the gas supplier.
CAUTION
DO NOT DISCARD THIS MANUAL
Read, understand
and follow these
instructions for safe
i n s t a l l a t i o n a n d
operation.
IM-117
Outdoor Burner/Hearth Kits • 12/08
Installation and service of this
appliance should be performed by
qualified personnel.It is suggested
NFI certified or factory-trained
professionals, or technicians
supervised by an
NFI certified profes-
sional.
Leave this manual with
party responsible for
use and operation.
WARNING
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass and other surfaces are hot during
operation and cool down.
Keep children away.
CAREFULLY SUPERVISE children in same room as
appliance.
Alert children and adults to hazards of high
temperatures.
Keep clothing, furniture, draperies and other
combustibles away.
In the Commonwealth of Massachusetts:
This appliance must be installed by a licensed plumber
or gas fitter.
The chimney flue damper, when used with gas logs, will
be welded open or completely removed.
A CO detector shall be installed in the room where the
appliance is installed.
Installation
Instructions
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the DG-SS-18/24/30NG and is the answer not in the manual?

Questions and answers

Summary of Contents for Heatmaster DG-SS-18/24/30NG

  • Page 1 HEATMASTER, LLC Installation AMERICAN GAS LOG Instructions Models: Installation and service of this appliance should be performed by DG-SS-18/24/30NG qualified personnel.It is suggested AGL-SS-18/24 NG NFI certified or factory-trained professionals, or technicians H-SS-24NG supervised by an HM2-SS-24NG NFI certified profes- sional.
  • Page 2: Homeowner Reference Information

    Read this manual before installing or operating this appliance. Please retain this owner’s manual for future reference. Congratulations Congratulations on selecting a Heatmaster/American Gas This owner’s manual should be retained for future reference. Log,LLC.,outdoor gas burner system—an elegant and clean We suggest you keep it with your other important documents alternative to burning wood. The gas log set you have se- and product manuals.
  • Page 3 Listing and Code Approvals A. Appliance Certification WARNING The Gas Log Hearth Kits have been tested and listed for outdoor use in the U.S. in accordance with ANSI Z21.84-2003 Improper installation, adjustment, alteration, service (Gas Log Set). They have been listed by OMNI Test Labs for or maintenance can cause injury or property damage.
  • Page 4: Getting Started

    Installation and use of any damaged appliance or vent system component. • Modification of the appliance or vent system. • Installation other than as instructed by Heatmaster/ American Gas Log, LLC. • Improper positioning of the gas logs or the glass door.
  • Page 5 Use ONLY optional accessories approved for this appliance. • Using non-listed accessories voids warranty. • Using non-listed accessories may result in a safety hazard. • Only Heatmaster/American Gas Log, LLC approved accessories may be used safely. IM-117 Outdoor Burner/Hearth Kits • 12/08...
  • Page 6: Appliance Preparation

    Appliance Preparation Note: Have the gas supply line installed in accordance WARNING with local building codes, if any. If not, follow ANSI 223.1. Installation should be done by a qualified installer approved Fire Risk and/or licensed as required by the locality. (In the Common- Explosion Risk wealth of Massachusetts installation must be performed by Verify inlet pressures.
  • Page 7: Gas Pressure

    C. Gas Pressure • Gas Supply Pressure: Minimum inlet gas supply pressure must be 3.5 in. W.C. for the purpose of input adjustment. Proper input pressures are required for optimum appliance Maximum inlet gas pressure must not exceed 10.0 in. W.C. performance. Gas line sizing requirements need to be made The gas line supplying the appliance must be sufficient following NFPA51.
  • Page 8: Installation Instructions

    Installation Instructions A. Install the Damper Stop • Open the damper to the fully open position and secure it open with the stop as shown in Figure 4.1. • If the damper stop doesn’t fit your application, use a permanent means that will keep the damper open at least to the minimum vent opening as outlined in Table 1, Section 1.B.
  • Page 9: Install The Logs

    E. Install the Logs F. Adjust the Burner Flame • The burner flame can be adjusted at the manual shutoff valve beside the fireplace to obtain the desired flame WARNING appearance. • The flame color will stabilize after ten minutes of Fire Risk operation. Explosion Risk Personal Injury Risk G. Inspect the Venting System Failure to position the parts in accordance The fireplace venting system is designed and constructed to with the diagrams provided with the log develop a positive flow adequate to remove flue gases to the...
  • Page 10: Lighting Instructions

    Asphyxiation Risk Gas-burning appliances produce smoke and carbon monoxide gas during operation. • The damper must be open Operating Instructions • The chimney must draw properly These fumes can be harmful if not vented A. Lighting Instructions properly. FOR YOUR SAFETY READ BEFORE LIGHTING FOR YOUR SAFETY READ BEFORE LIGHTING WARNING! IF THESE INSTRUCTIONS ARE NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT...
  • Page 11: Glass Doors

    • Have the chimney and adjacent structure inspected and cleaned by qualified professionals. Heatmaster/American • Glass doors may be closed when the hearth kit is not being Gas Log,LLC. recommends that NFI certified professionals, used.
  • Page 12: Maintaining And Servicing The Appliance

    Maintaining and Servicing the Appliance A. Servicing Your Appliance C. Annual Inspection WARNING WARNING Risk of injury or property damage Annual inspection by qualified technician recommended. Before servicing: Check: • Turn off gas. • Condition of doors, surrounds and fronts. • Turn off electricity to appliance. • Obstructions of combustion and ventilation • Disable remote control, if one is present. air.
  • Page 13: Reference Materials

    Reference Materials A. Replacement Parts HeartH Kits Service Parts Exploded Parts Diagram For replacement parts please call Heatmaster/American Gas Log, LLC. 3625 Benson Rd, Angier, NC 27501 919.330.0078. or 919.330.0079 IM-117 Outdoor Burner/Hearth Kits • 12/08...
  • Page 14 HeartH Kits Service Parts Service Parts List Description of Part Qty. Burner Pan - DG-SS Only BPA-112-16S BPA-600-22S BPA-600-29S Burner/Grate- AGL-SS AGLSS Burner BPA-900-2430 Grate - DG-SS Only GR-112-20S GR-600-24S GR-112-30 HM2-SS/Grate Only 11-1270SS Orifice, DG-SS BPO-2-26 BPO-2-26 BPO-2-16 Orifice, H-SS BPO-2-26 Orifice, AGLSS 11-1036 Orifice, HM2-SS 11-1036...
  • Page 15 DECORATIVE GAS LOG LIMITED WARRANTY Heatmaster/American Gas Log, LLC. extends the following warranty for decorative gas log sets as described herein, while it is in its location or original installation. Dealers and employees of Heatmaster/American Gas Log, LLC., have no authority to make any warranty or authorize any remedies in addition to or inconsistent with the terms of this Program.

Table of Contents