Table of Contents
Advertisement
Owners &
Installation
LISTINGS AND CODE APPROVALS
These gas appliances have been
tested in accordance with AG 103,
NZS 5262 and have been certified by
the Australian Gas Association for
installation and operation as
described in these Installation and
Operating Instructions.
Your unit should be serviced
annually by an authorised service
person.
Freestanding Gas Fire
Geneva
PLEASE KEEP THESE INSTRUCTIONS
FOR FUTURE REFERENCE
WARNING:
Improper installation, adjustment, altera-
tion, service or maintenance can cause
injury or property damage. Refer to this
manual. For assistance or additional infor-
mation consult an authorized installer, serv-
ice agency or the gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other flamma-
ble vapours and liquids in the vicinity of this
or any other appliance.
Installation and service must be performed
by an authorized installer, service agency or
the gas supplier.
Australia
P.O. Box 533
Braeside, Victoria
3195
918-080b
FOR YOUR SAFETY
What to do if you smell gas:
Do not try to light any appli-
ance
Do not touch any electrical
switch: do not use any
phone in your building.
Immediately call your gas
supplier from a neighbour's
phone. Follow the gas sup-
plier's instructions.
If you cannot reach your
gas supplier, call the fire
department.
New Zealand
1-37 Mt
Wellington Hwy.Panmure,
P.O. Box 14349
Auckland 6.
Models: F37-NG
F37-LPG
01/20/04
Advertisement
Table of Contents
Related Manuals for Masport Geneva F37-NG
Summary of Contents for Masport Geneva F37-NG
- Page 1 Owners & Installation Freestanding Gas Fire Geneva Models: F37-NG F37-LPG PLEASE KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE WARNING: FOR YOUR SAFETY Improper installation, adjustment, altera- What to do if you smell gas: tion, service or maintenance can cause Do not try to light any appli- injury or property damage.
-
Page 2: Specifications Diagram
Masport Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodfire, at the flick of a switch. The models F37-NG, and F37-LPG of this series has been approved by AGA for both safety and efficiency. -
Page 3: Table Of Contents
Door Installation ............13 Pressure Testing ............14 Valve Description ............14 Louvre Installation ............14 Optional Wall Thermostat .......... 14 Optional Remote Control ........... 15 Final Check ............... 15 Wiring Diagram ............15 F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 4: Data Plate
Check the label on the unit and if there standing Gas Fire. We have printed a copy of pedestal door. is a difference, the label on the unit is the correct one. (Australia Only) F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 5: Installation
Make it a practice to have all of BURNERS AND CIRCULATING AIR your gas appliances checked annually. PASSAGEWAYS OF THE APPLI- 13) Do not slam shut or strike the glass door. ANCE BE KEPT CLEAN. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 6: Installation Checklist
This unit can be installed on a solid combustible surface like a wood floor. This unit can also be installed directly on carpeting or vinyl when the bottom pedestal cover plate (provided with unit) is installed. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 7: Exterior Flue Terminal Locations
(IV)A flue terminal of this type shall not be located under a roofed area unless the roofed area is fully open on at least two sides and a free flow of air at the appliance is achieved. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 8: Exterior Flue Terminal Locations
7 and in your local building The Masport Room Sealed System are engi- codes. neered products that have been designed and tested for use with the F37-NG, and F37-LPG. IMPORTANT The gas appliance and flue system The Masport warranty will be voided and seri-... -
Page 9: Fluing Arrangements - Vertical Terminations For Both Residential & Manufactured Homes/Mobile Homes
To set the Flue restriction as indicated in the diagram, simply loosen the screws and push the flue restrictor plate to the correct position. Tighten the screws. Vent Restrictor Vent Restrictor Vent Vent (fully open) Restrictor Restrictor Plate Plate F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 10: Horizontal Installations
The location of the horizontal flue termi- nation on an exterior wall must meet all local and national building codes, and must not be blocked or obstructed. For External Flue Terminal Locations, see diagram on page 7. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 11: Conversion From Ng To Lpg
Tighten screws securely. with the appliance. 15) Check operation of flame control. 6) Pull off the pilot cap to expose the pilot 16) Check for proper flame appearance and orifice. glow on logs. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 12: Aeration Adjustment
Caution: Carbon will be produced if the air C)02-44 shutter is closed too much. Note: Any damage due to carboning re- Embers Embers sulting from improperly setting the aeration controls is NOT cov- ered under warranty. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 13: Door Installation
Note: The door latch may require ad- justment as the door gasket ma- terial compresses after a few fires and after glass replace- ment. Turn the latch catch in- E)02-45 ward or outward. Notch Cutout Diagram 3 F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 14: Pressure Testing
Note that the wires are connected to the "TH" on the gas valve. Use table below to determine the maximum wire length: CAUTION Do not connect the millivolt wall thermostat wires to the 240V wires. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 15: Optional Remote Control
This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 16: Operating Instructions
1) Turn OFF the flame switch. heat output range the fan will shut off automat- ically. 2) Push in gas control knob slightly and turn to "OFF" position. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 17: Copy Of Lighting Plate Instructions
2) Push in gas control knob slightly and turn to "OFF" position. You may shut off the pilot during prolonged non use periods to conserve fuel. DO NOT REMOVE THIS INSTRUCTION PLATE 918-254 F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 18: Maintenance
If the door gasket requires replacement use THORIZED SERVICE TECHNICIAN 7/8" diameter oval door gasket (Part # 650-920). TO INSPECT THE APPLIANCE AND TO REPLACE ANY PART OF CON- Top View of pilot flame F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 19: Latch Adjustment
10) Replace new gasket by gluing it in place. to center glass. 11) Install door onto stove and check the seal. 6) Remove glass from extrusions. When re- moving center glass, leave white insulation in place. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 20: Fan Maintenance
1) Unplug or discon- nect power source to stove. 2) Remove the rear access panel on the back of the stove. The fan can only be accessed from the back of the stove. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... -
Page 21: Firebox Paint
While the painted surface is designed for high durability, the combustion conditions can cause deterioration of the paint finish. This is not unique to Masport Gas Fires. If the surface discolors or blisters simply scuff any loose paint from the firebox and lightly respray with Masport high temperature paint. -
Page 22: Replacement Parts List
24) 948-255 556074 Door Latch - c/w J-Hook *Not available as a replacement part. 25) * Flex Pipe (3" ID) 26) * Clamp for Flex Pipe 27) 910-233 560065 Fan Auto On/Off Thermodisc F37 Masport Rear Flued Room Sealed Freestanding Gas Heater... - Page 23 68) W840470 Pilot Assembly Gasket *Not available as a replacement part. 71) 730-528 Log Stand 904-390 551859 Pilot Orifice #52 - NG 75) 730-935 Log Set 78) 730-550 Burner Assy - NG/LPG F37 Masport Rear Flued Room Sealed Freestanding Gas Heater...
- Page 24 Side Glass 107) 936-243 560087 Glass Gasket 108) 940-322/P Centre Glass 111) * Door Frame Fibre Paper 112) 750-015 Door Glass Extrusion 208) 940-325/P Wrap Glass *Not available as a replacement part. F37 Masport Rear Flued Room Sealed Freestanding Gas Heater...
- Page 25 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ F37 Masport Rear Flued Room Sealed Freestanding Gas Heater...
- Page 26 _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ ____________________________________________________________ __________________________________________________________ ____________________________________________________________ _______________________________________________________ _____________________________________________________ __________________________________________________________ _________________________________________________________ _________________________________________________________ ______________________________________________________ ______________________________________________________ _______________________________________________________________ ___________________________________________________________ __________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ _____________________________________________________________ __________________________________________________________ __________________________________________________________ _____________________________________________________ ________________________________________________________ _________________________________________________________ _________________________________________________________ F37 Masport Rear Flued Room Sealed Freestanding Gas Heater...
-
Page 27: Warranty
WARRANTY THE MASPORT EXPRESS WARRANTY All new Masport Gas appliances are warranted, subject to the This Express Warranty Does Not Cover: following conditions, to be free from defects in material or 1. Defects, malfunctions or failures caused by incorrect workmanship under normal use. The Express Warranty on all... - Page 28 Printed in Canada © Copyright 2004, FPI Fireplace Products International Ltd. All rights reserved.