Troubleshooting; Specifications; Warranty; Customer Assistance - Honeywell RLV430 User Manual

Troubleshooting

PROBLEM
Thermostat is hot.
Heater is always On.
Thermostat indicates
that heating is On, but
the heater is not On.
Wrong temperature is
displayed.
Wrong time is dis-
played.
Temperature does not
change according to the
programmed schedule.
The normal display dis-
appears and reappears
after a few minutes.
Display looks faded
when heating is acti-
vated.

Specifications

Supply: 120/240 VAC, 50/60 Hz
Power consumption (off): 860 mW
Minimum load: 2 A (resistive only)
500 W @ 240 VAC
250 W @ 120 VAC
Maximum load:14.6 A (resistive only)
3500 W @ 240 VAC
1750 W @ 120 VAC
Display range: 0°F to 99°F (0°C to 99°C)
Display resolution: 1°F (1°C)
Setpoint range: 40°F to 80°F (5°C to 27°C)
Setpoint interval: 1°F (1°C)
Storage temperature: -4°F to 120°F (-20°C to 50°C)
Accuracy - proportional: ± 0,27°F (0,15°C)
conventional: ± 0,9°F (0,5°C)
Dimensions: 4.8 x 4.5 x 1 inches (120 x 115 x 26 mm)
Approval: CSA / UL
RLV430
SOLUTIONS
This condition is normal. Under normal
operation, the thermostat housing may
reach a temperature between 95°F
(35°C) and 104°F (40°C).
The thermostat has not been correctly
wired.
Reset the thermostat.
The thermostat has not been correctly
wired.
Reset the thermostat.
The thermostat is exposed to air draft.
Eliminate the draft.
The sticker on the thermostat's screen
has not been removed.
The thermostat was without power for
more than 2 hours.
Check that the thermostat is in Auto-
matic mode. Check the schedule and
clock settings.
The thermal protection device on the
heater is open. This can happen after a
power failure or if the heater is
obstructed by furniture or curtains.
The heating system is less than the
required minimum load. This thermo-
stat cannot be used below that rating.
9.

Warranty

Honeywell warrants this product, excluding battery, to be free from
defects in the workmanship or materials, under normal use and ser-
vice, for a period of one (1) year from the date of purchase by the
consumer. If at any time during the warranty period the product is
determined to be defective or malfunctions, Honeywell shall repair or
replace it (at Honeywell's option).
If the product is defective,
(i) return it, with a bill of sale or other dated proof of purchase, to
the place from which you purchased it, or
(ii) call Honeywell Customer Care at 1-800-468-1502. Customer
Care will make the determination whether the product should be
returned to the following address: Honeywell Return Goods,
Dock 4 MN10-3860, 1885 Douglas Dr N, Golden Valley, MN
55422, or whether a replacement product can be sent to you.
This warranty does not cover removal or reinstallation costs. This
warranty shall not apply if it is shown by Honeywell that the defect or
malfunction was caused by damage which occurred while the prod-
uct was in the possession of a consumer.
Honeywell's sole responsibility shall be to repair or replace the prod-
uct within the terms stated above. HONEYWELL SHALL NOT BE
LIABLE FOR ANY LOSS OR DAMAGE OF ANY KIND, INCLUDING
ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING,
DIRECTLY OR INDIRECTLY, FROM ANY BREACH OF ANY WAR-
RANTY, EXPRESS OR IMPLIED, OR ANY OTHER FAILURE OF
THIS PRODUCT. Some states do not allow the exclusion or limitation
of incidental or consequential damages, so this limitation may not
apply to you.
THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEY-
WELL MAKES ON THIS PRODUCT. THE DURATION OF ANY
IMPLIED WARRANTIES, INCLUDING THE WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PUR-
POSE, IS HEREBY LIMITED TO THE ONE-YEAR DURATION OF
THIS WARRANTY. Some states do not allow limitations on how long
an implied warranty lasts, so the above limitation may not apply to
you.
This warranty gives you specific legal rights, and you may have other
10.
rights which vary from state to state.
If you have any questions concerning this warranty, please write Hon-
eywell Customer Relations, 1985 Douglas Dr, Golden Valley, MN
55422 or call 1-800-468-1502. In Canada, write Retail Products
ON15-02H, Honeywell Limited/Honeywell Limitée, 35 Dynamic Drive,
Scarborough, Ontario M1V4Z9.

Customer Assistance

If you have any questions about the operation of your thermostat,
please go to http://yourhome.honeywell.com, or call Honeywell
Customer Care toll-free at 1-800-468-1502.
As an E
determined that this product meets the E
guidelines for energy efficiency.
®
S partner, Honeywell has
NERGY TAR
NERGY
69-1874ES
11.
12.
S
TAR
9/7/05 4/8