Troubleshooting & Adjustments; Troubleshooting The Tractor - Briggs & Stratton 2609762 Operator's Manual

Troubleshooting &
Adjustments
Troubleshooting
While normal care and regular maintenance will extend the life
of your equipment, prolonged or constant use may eventually
require that service be performed to allow it to continue
operating properly.
The troubleshooting guide below lists the most common
problems, their causes, and remedies.
See the information on the following pages for instructions on
how to perform most of these minor adjustments and service
repairs yourself. If you prefer, all of these procedures can be
performed for you by your local authorized dealer.

Troubleshooting the Tractor

PROBLEM
Engine will not
turnover or start.
Engine starts hard or
runs poorly.
Engine knocks.
Excessive oil
consumption.
LOOK FOR
Brake pedal not depressed.
PTO (electric clutch) switch is in ON position.
Cruise control engaged.
Out of fuel.
Engine flooded.
Fuse is blown.
Battery terminals require cleaning.
Battery discharged or dead.
Wiring loose or broken.
Solenoid or starter motor faulty.
Safety interlock switch faulty.
Water in fuel.
Gas is old or stale.
Fuel mixture too rich.
Engine has other problem.
Low oil level.
Using wrong grade oil.
Engine running too hot.
Using wrong grade oil.
Too much oil in crankcase.
WARNING
To avoid serious injury, perform maintenance on the
tractor or mower only when the engine is stopped and
the parking brake engaged.
Always remove the ignition key, disconnect the spark
plug wire and fasten it away from the plug before
beginning the maintenance, to prevent accidental
starting of the engine.
REMEDY
Fully depress brake pedal.
Place in OFF position.
Move knob to NEUTRAL/OFF position.
If engine is hot, allow it to cool, then refill
the fuel tank.
Disengage the choke.
See authorized dealer.
See Cleaning the Battery and Cables.
Recharge or replace battery.
Visually check wiring. If wires are frayed or
broken, see authorized dealer.
See authorized dealer.
See authorized dealer.
See authorized dealer.
See authorized dealer.
Clean air filter.
See authorized dealer.
See engine manual.
See engine manual.
See authorized dealer.
See engine manual.
Drain excess oil.
22