Lennox Hearth Products EBSTNM-2 Homeowner's Care And Operation Instructions Manual

Lennox Hearth Products EBSTNM-2 Homeowner's Care And Operation Instructions Manual

B-vent multi-open elite series

Advertisement

EBST (See-through)
EBCL (Corner-Left)
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
EBPF (Peninsula)
EBCR (Corner-Right)
OTL Report No. 116-F-07-5
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND

OPERATION INSTRUCTIONS

B-VENT MULTI-OPEN
ELITE
B-VENTED GAS APPLIANCES
P/N 875,012M REV. D 05/2004
MODELS
M
l i
v i l
t l o
M
o
e d
E
B
S
T
N
M
2 -
E
B
C
R
E
B
S
T
P
M
2 -
E
B
C
R
E
B
P
F
N
M
2 -
E
B
C
L
E
B
P
F
P
M
2 -
E
B
C
L
E
B
B
A
Y
N
M
E
B
B
A
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié installeur, agence de service ou le fournisseur
de gaz.
®
SERIES
s l
E
e l
r t c
n o
c i
N
M
2 -
E
B
S
T
N
E
2 -
E
P
M
2 -
E
B
S
T
P
E
2 -
E
N
M
2 -
E
B
P
F
N
E
2 -
E
P
M
2 -
E
B
P
F
P
E
2 -
E
Y
N
P
E
B
B
A
Y
N
E
M
o
e d
s l
B
C
R
N
E
2 -
B
C
R
P
E
2 -
B
C
L
N
E
2 -
B
C
L
P
E
2 -
1

Advertisement

Table of Contents
loading

Summary of Contents for Lennox Hearth Products EBSTNM-2

  • Page 1: Operation Instructions

    HOMEOWNER'S CARE AND OPERATION INSTRUCTIONS B-VENT MULTI-OPEN ® ELITE SERIES B-VENTED GAS APPLIANCES P/N 875,012M REV. D 05/2004 MODELS EBST (See-through) EBPF (Peninsula) v i l t l o r t c EBCL (Corner-Left) EBCR (Corner-Right) RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE LES INSTRUCTIONS DONNÉ...
  • Page 2: Table Of Contents

    CONGRATULATIONS! GENERAL INFORMATION Note: Installation and repair should be per- In selecting this LENNOX B-Vented Gas Appliance you have chosen the finest and formed by a qualified service person. The appli- most dependable fireplace to be found anywhere. Its a beautiful, prestigious ance should be inspected annually by a quali- alternative to a wood burning fireplace.
  • Page 3: Operation/Care Of Your Appliance

    The following table shows the units' gas ori- The appliance and its individual shut-off valve must WARNING: CHILDREN AND ADULTS be disconnected from the gas supply piping system fice size for the elevations indicated: SHOULD BE ALERTED TO THE HAZARDS during any pressure testing of that system at pres- sures in excess of psig (3.5 kPa).
  • Page 4: Gas Controls/Control Compartment Access

    Gas Controls/Control Compartment Access Remove the modesty panel carefully, so that none of the wires become loose or discon- nected. Now complete access to the gas con- The gas controls can be found behind the trol valve and its related controls is attainable. control compartment access panel.
  • Page 5: Variable Flame Adjustment

    Variable Flame Height Adjustment CAUTION: DO NOT TOUCH THE FRONT EN- WARNING: DO NOT OPERATE THE SHUTOFF CLOSURE GLASS WITH YOUR HANDS WHILE ( Millivolt Appliances only) LEVER UNLESS A COMPLETE OUTSIDE THE FIREPLACE IS IN USE. COMBUSTION AIR SYSTEM HAS BEEN IN- 1.
  • Page 6: Maintenance

    Manual-Reset Safety Limit Switch B - To access the blocked flue safety switch Maintenance This appliance is equipped with a manual- when top radiant panel is covered with non- The appliance and venting system should be reset blocked flue safety limit switch. Refer to combustible material: thoroughly inspected before initial use and at Figure 5 for its location.
  • Page 7: Maintenance Schedule

    Maintenance Schedule Annually (Before the onset of the Burning Season) Maintenance Task Accomplishing Person Procedure Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operat- and Controls ing. Check piping for leaks. Vacuum the con- trol compartment, fireplace logs and burner area.
  • Page 8: Burner Adjustments

    4. Reinstall the modesty panel by inserting the Lower Compartment Door and Hinge WARNING: DO NOT ATTEMPT TO SUBSTI- tongues on the left side of it into the slots on Top Flange TUTE THE MATERIALS USED ON THESE Modesty Panel the left side cabinet panel.
  • Page 9: Log Placement

    Log Placement WARNING: LOG SET GETS VERY HOT AND WILL REMAIN HOT UP TO ONE HOUR AFTER GAS SUPPLY IS TURNED OFF. HANDLE ONLY WHEN LOG SET IS COOL. TURN OFF ALL GAS TO THE APPLIANCE BEFORE INSTALLING THE GRATE AND LOG SET. WARNING: THIS APPLIANCE IS NOT DE- SIGNED TO BURN WOOD.
  • Page 10: Electronic Appliance Checkout

    If you 120 V. should experience any problem, first refer to the Hot side of Outlet trouble shooting guide in this manual. If problem LENNOX HEARTH PRODUCTS 24 V persists, contact your Lennox distributor. 1110 West Taft Avenue WIRING DIAGRAMS...
  • Page 11: Accessory Components

    ACCESSORY COMPONENTS Door Frame Kits A decorative door frame kit is available for use with these appliances. The DTK is de- signed to attach directly to the front face of the appliance at its extreme edges. The DTK provides a picture frame finish for the appli- ance.
  • Page 12 ACCESSORY COMPONENTS CONTINUED s t i i n i t i n . n i . n i Remote Control System (Deluxe) H0251 RCL-T Deluxe Remote Control System (Model RCL-T) The Model RCL-T (Deluxe) Remote Control Charcoal Finish Louvers Kits System has all of the features of the standard system along with an added easy to read LCD screen which presents access to many en-...
  • Page 13 ACCESSORY COMPONENTS CONTINUED 2-Piece Polished Brass and Brushed Stainless Louvers Kits Decorative louvers are available for use with all Multi-Open Series appliances. These louvers are designed to replace either the middle char- coal louver of each set or the charcoal louver in each set closest to the glass door.
  • Page 14: Lighting Instructions - Millivolt

    LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo •...
  • Page 15 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
  • Page 16: Lighting Instructions - Electronic

    LIGHTING INSTRUCTIONS — ELECTRONIC FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. When lighting the appliance, follow these instructions •...
  • Page 17 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
  • Page 18: Troubleshooting Guide - Millivolt

    TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM ote: Before troubleshooting, make sure that the appliance main line gas shut-off valve and the gas control valve are in the "OPEN" position and the burner ON/OFF switch is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. POSSIBLE CAUSES SYMPTOM CORRECTIVE ACTION...
  • Page 19: Troubleshooting Guide - Electronic

    TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM ote: Before troubleshooting, make sure that the appliance main line gas shut-off valve and the gas control valve are in the "OPEN" position and the burner ON/OFF switch is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION...
  • Page 20 REPLACEMENT PARTS GAS CONTROLS — SIT MILLIVOLT t i n t o l t o l t o l c i t ) l e GAS CONTROLS — HONEYWELL ELECTRONIC l l e t o l t i n ) t i c i t ) l e t o l...
  • Page 21: Replacement Parts List

    REPLACEMENT PARTS LIST , t n . n i . n i . n i . n i e l t . n i , e l . n i . n i . n i , e l . n i , e l .
  • Page 22 REPLACEMENT PARTS Note: - EBPF-2 Shown - see the tables on pages 20 and 21 for replacement parts applicable to EBST-2, EBCR-2, EBCL-2 and EBBAY fireplaces. Cabinet Corner Post Location Inside Location Rear Burner Front Burner NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
  • Page 23 NOTES: NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
  • Page 24 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2002 by LENNOX HEARTH PRODUCTS P/N 875,012M REV.

Table of Contents