Table of Contents
Advertisement
P/N 875030M Rev. E 01/2011
This manual is one of a set of two supporting this product.
Refer to P/N 850036M for Installation Instructions.
Ce manuel est disponible en francais, simplement
en faire la demande. Numéro de la pièce 875030CF.
WHAT'S INSIDE
Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Safety and Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
FREE Safety Guard Offer
(Protects Against Burns)
Important Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Attaching the Safety-in-Operation Warnings . . . . . . . . . . . . . . 5
L'information de sûreté importante
[EN FRANÇAIS]
Apposition des mises en garde relatives à la sécurité d'utilisation
Información importante de seguridad
[EN ESPAÑOL]
Colocación de advertencias de seguridad en operación
Wait...
DON'T
INSTALLER: Leave this manual with the appliance.
THROW
CONSUMER: Retain this manual for future reference.
IT AWAY!
f i r e - p a r t s . c o m
This manual contains
INSTALLATEUR : Laissez cette notice avec l'appareil.
important operating
CONSOMMATEUR : Conservez cette notice pour consultation ultérieure.
and safety
information.
WARNING / AVERTISSEMENT / AVISO
• HOT GLASS WILL CAUSE
BURNS.
• DO NOT TOUCH GLASS
UNTIL COOLED.
• NEVER ALLOW CHILDREN
TO TOUCH GLASS.
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may
result, causing property damage, personal injury,
or death.
-
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
•
department.
- Installation and service must be performed by a
. . . . . . . . . . . . . 2
. . . . . . . . . . . . 3–4
. . . 5
. . . . . . . . . . . . 3–4
. . . . . . . . . . 5
• UNE SURFACE VITRÉE CHAUDE
PEUT CAUSER DES BRÛLURES.
• LAISSER REFROIDIR LA SURFACE
VITRÉE AVANT D'Y TOUCHER.
• NE PERMETTEZ JAMAIS À UN ENFANT
DE TOUCHER LA SURFACE VITRÉE.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incindie ou d'explosion ou pour
éviter tout dommage matériel, toute blessure ou la mort.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir des
• Appelez immédiatement votre fournisseur de gaz depuis
• Si vous ne pouvez rejoindre le fournisseur de gaz,
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
CARE AND OPERATION INSTRUC TIONS
ELDV Direct-Vent
Gas Fireplaces
MODELS
MILLIVOLT:
ELDV-35NM
ELDV-35PM
ELDV-40NM
ELDV-40PM
ELDV-45NM
ELDV-45PM
Portland
US
OTL Report No. 116-F-39C-5
téléphones se trouvant dans le bâtiment où vous trouvez.
un voisin. Suivez les instructions du fournisseur.
appelez le service des incindies.
™
ELECTRONIC:
ELDV-35NE
ELDV-40NE
ELDV-45NE
• EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
• USTED DEBE NUNCA
TOCAR EL VIDRIO CALIENTE.
• LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Lennox Hearth Products ELDV-35NM
Summary of Contents for Lennox Hearth Products ELDV-35NM
- Page 1 This manual is one of a set of two supporting this product. MILLIVOLT: ELECTRONIC: Refer to P/N 850036M for Installation Instructions. Ce manuel est disponible en francais, simplement ELDV-35NM ELDV-35PM ELDV-35NE en faire la demande. Numéro de la pièce 875030CF. ELDV-40NM...
-
Page 2: Table Of Contents
To prevent severe burns and injuries, install To receive your FREE SAFETY GUARD, call 1-800-786-7976 a screen or physical barrier to prevent direct or visit www.lennox.com (Lennox Hearth Products / Owner Resources) contact with the glass. SAFETY GUARD To order a FREE Lennox ®... - Page 3 Toutes les parties de votre foyer ¡Todas las partes de la chimenea Lennox Hearth Products deviennent Lennox Hearth Products se ponen EXTRÊMEMENT CHAUDES ! MUY CALIENTES! Afin d'éviter de vous brûler gravement ou de Instale una malla o barrera física para evitar vous blesser, installez une grille ou une barrière...
-
Page 4: Important Safety Information
Important Safety Information L'information de sûreté importante AVERTISSEMENT. Ne pas utiliser l’appareil si le panneau frontal WARNING: Do not operate appliance with the glass front en verre n’est pas en place, est craqué ou brisé. Confiez le removed, cracked or broken. Replacement of the glass remplacement du panneau à... -
Page 5: Attaching The Safety-In-Operation Warnings
3. Si no puede encontrar las etiquetas, sírvase llamar Lennox Hearth Products or your nearest Lennox ment parlée dans la résidence du propriétaire. a Lennox Hearth Products o al distribuidor de Hearth Products dealer to receive additional 3. Si vous ne trouvez pas les étiquettes, veuillez Lennox Hearth Products más cercano para recibir... -
Page 6: General Information
General Information INSTALLATION, SERVICE, These appliances are designed to operate on natural gas or propane AND MAINTENANCE gas only. The use of other fuels or The fireplace models covered in this manual IMPORTANT: Improper installation, combinations of fuels will degrade the are direct-vent sealed combustion gas fireplace adjustment, alteration, service, or heaters designed for residential application. - Page 7 BTU Input Test gauge connections are provided on the Burner Orifice Sizes front of the millivolt gas control valve, identi- Elevation 0-4500 feet ( 0-1372 meters) Millivolt and electronic models come standard fied IN for the inlet and OUT for the manifold Model Nat.Gas Propane...
-
Page 8: Operation/Care Of Your Appliance
OPERATION AND CARE OF YOUR APPLIANCE To replace the door, engage the tabs with the slots and push it into position. WARNING On millivolt systems, the piezo igniter, HI/LO flame adjustment knob, and pilot and main Young children should be carefully supervised when they are in the gas OFF/ON control knob are located below same room as the appliance. -
Page 9: Variable Flame Adjustment
Electronic Appliances - Note: It is recommended that batteries not be installed in the battery holder until a power Pressure-Tap Burner Stage (Manifold) To light electronic appliances refer to the detailed Terminal outage, or if the appliance is to be operated Regulator lighting instructions found on Pages 24 and solely with two (2) "D"... -
Page 10: Maintenance
MAINTENANCE Note: Clean glass after first two weeks of opera- Replacing Logs tion (after Burn-In period is over) and then only when necessary and when the fireplace is cool. If the logs become damaged by accident or (See Maintenance Schedule, Page 26) Wipe surface with clean, dampened, soft cloth. -
Page 11: Front Glass Enclosure Panel, Removal And Installation
Front Glass Enclosure Panel, Removal 5. Position the door in front of the firebox open- WARNING ing with the bottom of the door held away and Installation from the fireplace (Figure 5). Hook the top Any safety screen or guard flange of the door frame over the top of the WARNING removed for servicing the appli-... -
Page 12: Install Volcanic Stone, Embers And Logs
INSTALL VOLCANIC STONE, GLOWING Note: The log set and fire are artistically ar- Glowing Embers ranged to provide a random asymmetric look EMBERS AND LOGS to the fire. The fire intentionally does not burn Separate into Quarter Size (separate) Pieces in the left rear quarter of the log set. - Page 13 ELDV3530 LOG PLACEMENT Number Description Log, Center Log, Rear Log, Front Log, Left Log, Right Catalog Number for the entire log set: H4656 Baffle Pins Baffle Align the f i r e - p a r t s . c o m holes at the bottom of log (4) over...
- Page 14 ELDV4035 LOG PLACEMENT Number Description Log, Center Log, Rear Log, Front Log, Left Log, Right Catalog Number for the entire log set: H4657 Baffle Pins Baffle Align the holes at the bottom of log (4) over the pins on logs (1) and (2) f i r e - p a r t s .
- Page 15 ELDV4540 LOG PLACEMENT (REPEAT STEPS 1 ThRU 4 FROM ELDV4035 LOG PLACEMENT AND ThEN ADD ThE FOLLOWING STEPS) Number Description Log, Center Log, Rear Log, Front Log, Left Log, Right Log, Right/Rear Log, Left/Rear Catalog Number for the entire log set: H4658 f i r e - p a r t s .
-
Page 16: Burner Flame Appearance/Sooting
BURNER ADjUSTMENTS (QUALIFIED TECHNICIANS ONLY) Flame Appearance and sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame may be blue and will gradually turn yellowish-orange during the first 15 minutes of operation. -
Page 17: Burner Flame Adjustments
Burner Air Shutter Adjustment Procedure SIT MILLIVOLT PILOT ASSEMBLY Burner Air Shutter Adjustment Proper Pilot Flame Appearance WARNINGS Igniter Rod Pilot Hood Shutter • Air shutter adjustment should Venturi only be performed by a quali- Thermocouple 3/8" Min. fied professional service (9 mm) technician. -
Page 18: Warranty
If you encounter any problems or have any REPLACEMENT PARTS Please call Lennox Hearth Products for the questions concerning the installation or ap- phone number of your nearest Lennox Hearth plication of this system, please contact your... -
Page 19: Product Reference Information
ACCESSORY COMPONENTS Product Reference Information Cat. Model Ship. Ship. Weight Volumn H3948 ELDV-35NM 159 lb. 26.1 cu. ft. H3949 ELDV-35PM 159 lb. 26.1 cu. ft. H3950 ELDV-35NE 159 lb. 26.1 cu. ft. H3951 ELDV-40NM 182 lb. 26.06 cu. ft. H3952 ELDV-40PM 182 lb. - Page 20 ACCESSORY COMPONENTS CONTINUED Style View Doors - Style View Doors come in 2 beautiful styles. They are easy to install and will not require hardware to attach them to the standard glass door frame. The door includes heavy duty magnet door latches and functional twin-pane doors. Arch Pane Design Square Pane Design ARCH PANE DESIGN KITS...
- Page 21 ACCESSORY COMPONENTS CONTINUED Bag of Glowing Embers Bag of Volcanic Stone Forced Air Blower Kit Replacement ember materials or volcanic stone are Single Speed H4678 LBLK-100 available for use with these appliances. Order kits as part of the periodic maintenance of the appliance. Forced Air Kit s t i The LBLK-100 blower provides constant velocity...
-
Page 22: Lighting Instructions - Millivolt
LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INjURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo •... - Page 23 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS à LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. •...
-
Page 24: Lighting Instructions - Electronic
LIGHTING INSTRUCTIONS — ELECTRONIC FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INjURY OR LOSS OF LIFE. • Do not use any phone in your building. A. - Page 25 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS à LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 26: Maintenance Schedule
MAINTENANCE SCHEDULE Annually (Before the onset of the Burning Season) MAINTENANCE TASK ACCOMPLISHING PERSON PROCEDURE Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operating. Check piping and Controls for leaks. Vacuum the control compartment, fireplace logs and burner area. -
Page 27: Troubleshooting Guide - Millivolt
TROUBLEShOOTING ThE MILLIVOLT CONTROL SYSTEM Note: Before troubleshooting the gas control system, Ensure external gas shut off valve, located at gas supply inlet, (and wall switch, iff applicable), is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION... -
Page 28: Troubleshooting Guide - Electronic
TROUBLEShOOTING ThE ELECTRONIC IGNITION SYSTEM Note: Before troubleshooting, be sure that the appliance main line gas shut-off valve, the gas control valve and the wall switch are in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION... -
Page 29: Replacement Parts List
, t e , e t l a r Gas Controls - SIT Millivolt Contact an Authorized Lennox Hearth Products dealer to obtain any of Item Description Natural Gas Propane Gas these parts. Never use substitute materials. Use of non-approved parts Part No. - Page 30 REPLACEMENT PARTS f i r e - p a r t s . c o m NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
- Page 31 Notes f i r e - p a r t s . c o m...
- Page 32 - p a r t s . c o m Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.