Related Manuals for E-Wheels EW-36
Summary of Contents for E-Wheels EW-36
- Page 1 E-Wheels Electric Scooters EW-36 / EW-66 Electric Mobility Scooter EW-36 EW-66 Read this manual completely before riding your electric mobility scooter www.ActiveForever.com...
- Page 2 VOID YOUR WARRANTY! This PRODUCT IS NOT INTENDED FOR EXTREME or OFF-ROAD Use! Please take care of your scooter! DO NOT JUMP or ABUSE THIS PRODUCT! DO NOT RIDE IN WET/ICY CONDITIONS! Failure to follow these instructions will VOID YOUR WARRANTY www.ActiveForever.com...
- Page 3 The user of this product assumes ALL risks associated with its use. To minimize these RISKS, the user must wear safety helmet, goggles, gloves, elbow and kneepads and appropriate footwear. This product is ELECTRIC! DO NOT ride this product in wet conditions, puddles or rainy weather. www.ActiveForever.com...
- Page 4 *NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT SUPERVISION. *NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE INFLUENCE OF ALCOHOL. If a situation arises that is not covered in the manual, proceed with caution and use good judgment. www.ActiveForever.com...
-
Page 5: Table Of Contents
Wet Weather & Night Riding ………………………. 8 Specifications …………………………………………. 11 Components ………………………………………….. Assembly and Setup ……………………………….. 14 Routine Operation ………………………………….. 15 Battery Care and Maintenance…………………. Battery Charging …………………………………… Other Maintenance …………………………………. 23 Fuse ……………………………………………………… 24 Scheduled Maintenance …………………………. Troubleshooting ………………………………………. 26 Warranty / Returns ………………………………… www.ActiveForever.com... -
Page 6: Riding Safety
Use caution! Like any sport, cycling carries the risk of injury and damage. By choosing to ride the EW-36/EW-66 you assume all responsibility for these risks. Thus, you need to know and practice the rules of safe and responsible riding. -
Page 7: Safety Basics & Operating Instructions
Wear bright, visible clothing that is not so loose that it can catch on moving parts of the EW-36/EW-66 or objects at the side of the road or trail. o Think about your speed, and keep your speed consistent with safe operating conditions. -
Page 8: Operating Reminders And Suggestions
Riders who are jumping their EW-36/ EW-66risk serious damage to their EW-36/EW-66 and will void their warranty. o Never carry anything which obstructs your vision or your complete control of the EW-36/EW-66 or which could become entangled in the moving parts of the EW-36/EW-66. -
Page 9: Wet Weather & Night Riding
(as well as the brakes of other vehicles sharing the road) is dramatically reduced. This makes it harder to control speed and easier to lose control. To make sure that you can slow down and stop safely in wet www.ActiveForever.com... -
Page 10: Night Riding
Rules of the Road, and take the following precautions: Make sure that your EW-36/EW-66 is equipped with correctly positioned and securely mounted reflectors. Make sure your clothing or cargo does not obstruct a reflector or light. -
Page 11: Other Reminders
The battery does NOT require deep discharging. If your EW-36/Ew-66 is put into storage, re-charge its battery at least once every 90 days. Do not store your EW-36/EW-66 in direct sunlight for an extended time. www.ActiveForever.com... -
Page 12: Specifications
Store your EW-36/EW-66 in a dry place. Exposing your EW-36/EW-66 to rain, snow, or other precipitation may result in damage. SPECIFICATIONS EW-36 EW-66 COLOR: Red, Silver, Dark Blue, Orange COLOR: Red or Silver POWER: Electric POWER: Electric WATTS: 500 Watt... -
Page 13: Components
COMPONENTS 1.Battery Storage Access 5. Instrument panel (tilt seat forward) 6. Throttle (4 batteries total) 7. Brake levers 2. Seat Recline Adjuster 8. Ignition Switch 3. Drop Down Arm Rests 9. Basket 4. Forward/Reverse switch 10. Variable speed control www.ActiveForever.com... - Page 14 1. Brake levers 2. High/low beam selector 3. Rearview mirrors 4. Instrument Panel 5. Headlight switch 6. Throttle 7. Ignition switch 8. Forward/Reverse switch 9. Turn Signal 10. Speed Control Knob www.ActiveForever.com...
-
Page 15: Assembly And Setup
ASSEMBLY AND SETUP 1) Remove your EW-36/EW-66 from its shipping carton. EW-36/EW-66 weighs about 150 lbs, so get help, and use care. Cut away any residual packing materials with a knife or scissors. 2) Attach the Rear View Mirrors to the mounting holes. A wrench can be used to tighten the lock nuts at the base of each mirror. -
Page 16: Routine Operation
4) Verify the proper adjustment and function of the brakes. 5) Make sure the EW-36/EW-66 is in good mechanical order. Visually inspect and hand-check the vehicle, and snug any loose bolts, screws, or other fasteners. - Page 17 When the brake handle is squeezed it cuts power to the accelerator. 6) Give the EW-36/EW-66 some acceleration and speed by first applying the throttle gently. Try not to brake and accelerate needlessly.
-
Page 18: Battery Care And Maintenance
200 times recharging. If you re-charge the battery before it is exhausted, you will dramatically extend the battery’s cycle life. In Summary Always try to recharge the Battery Pack within 24 hours after use to maximize battery cycle life and prevent damage. www.ActiveForever.com... -
Page 19: Battery Trouble
What’s Inside Your EW-36/EW-66 Battery The Battery is composed of four 12 Volt, 20 Amp-hour capacity batteries, in series, for a total capacity of 48 V, 20 Ah. The component batteries are a standard, commercially available size. Keep three things in mind, however, should you choose to service your battery. -
Page 20: Battery Temperature Sensitivity
When the air temperature is under 0 ºF, the battery power will decline more than one third. So it is natural that the EW-36/ EW-66 will not reach its normal mileage in winter or in cold weather. -
Page 21: Battery Charging
Ideally, you should charge it every 20 days. Even a healthy battery will discharge itself slowly. Even with its power off, the EW-36/EW-66 state-of-charge will decline gradually over time. Remember to fully charge the battery before your first ride. - Page 22 4) Plug the end of the charger’s cord into the socket of the adaptor first. Next connect the adaptor to the EW-36/EW-66 (the charger port in located below thefront of the seat). Then plug the chargers’ AC cords into the wall outlet.
- Page 23 You should charge your EW-36/EW-66 after each ride. You should charge your EW-36/EW-66 if it has not been used for 30 days or more. WARNING Do not place the battery near heat or fire. Do not expose the chargers to water.
-
Page 24: Other Maintenance
OTHER MAINTENANCE Your EW-36/EW-66 should be checked once a year for a thorough inspection and adjustment. This can guarantee the comfort, safety and the normal operating life of the EW-36/EW-66 Front and Rear Brakes The adjustment of the front brake is the same as in a common motorcycle. -
Page 25: Fuse
Fuse The EW-36/EW-66 comes with one 25A Glass Fuse. The fuse is located under the headlight fairing. Lubrication You should inspect and maintain your EW-36/EW-66 and lubricate the mechanical power transmission components. The brake cables may also need lubrication Lubricate the brake cables with silicone or graphite lubricant. -
Page 26: Scheduled Maintenance
Scheduled Maintenance EW-36/EW-66 should be checked from time to time. Refer to the maintenance schedule in the following chart: Check ● adjust lubricate Parts daily days days Bolts, nuts, screws etc-to ensure that ● ● ● nothing is loose. Footboard-to ensure it is not worn out ●... -
Page 27: Troubleshooting
2. Loose wiring in 2. Send to a qualified charged. battery pack. service technician. 3. Defective Charger. 4. Replace Charger. NOTE: if other problems occur, do not attempt to disassemble the electric bike on your own, please contact your retailer www.ActiveForever.com...