Summary of Contents for Champion Power Equipment 73536i
Page 1
PORTABLE INVERTER GENERATOR MODEL NUMBER 73536i US Patent # D656897, 8391012 10006 Santa Fe Springs Road SAVE THESE INSTRUCTIONS Santa Fe Springs CA 90670 Important Safety Instructions USA / 1-877-338-0999 MADE IN CHINA are included in this manual. REV 73536i-20130314 www.championpowerequipment.com...
Page 2
FCC Statement 1. This device complies with Part 15 of the FCC Rules. accordance with the instructions, may cause harmful Operation is subject to the following two conditions: interference to radio communications. However, there (1) This device may not cause harmful interference. is no guarantee that interference will not occur in a (2) This device must accept any interference particular installation.
ENGLISH INTRODUCTION Introduction Accessories Congratulations on your purchase of a Champion Power Champion Power Equipment manufactures and sells Equipment inverter generator. CPE designs and builds accessories designed to help you get the most from your generators to strict specifications. With proper use and purchase.
Please call our help line at 1-877-338-0999 situation which, if not avoided, could result in death or serious injury. CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. REV 73536i-20130221...
Inform your electricity provider immediately if you or anyone in your household depends on electrical euipment to live. Inform your electrical provider immediately if a loss of power would cause you or anyone in your household to experience a medical emergency. REV 73536i-20130221...
Page 7
– Electrical output is lost – Equipment sparks, smokes or emits flames A spark arrestor may be required. The operator – Equipment vibrates excessively should contact local fire agencies for laws or regulations relating to fire prevention requirements. REV 73536i-20130221...
Fuel Lever Vent – Turn this valve to the “On” Maintenance Cover – Oil filler, Air filter, and position to supply air to the tank. Carburetor access. Fuel Cap – Remove to add fuel. Muffler Recoil Starter – Used to start the engine. REV 73536i-20130221...
(12) 12V DC 8A Outlet – Use this outlet to charge 12V automotive type batteries ONLY. * These outlets are used for connecting two Champion (13) Ground Terminal – Consult an electrician for local model 73536i generators for parallel operation.
The recommended oil type is 10W-30 automotive 2. Loosen the cover screw and remove the maintenance oil. cover. NOTE Check oil often during the break-in period. Refer to the Maintenance section for recommended service intervals. 3. Remove oil fill cap/dipstick to add oil. REV 73536i-20130221...
During operation the muffler and exhaust fumes produced will become hot. If adequate cooling and breathing space are not supplied, or if the generator is blocked or contained, temperatures can become extremely heated and may lead to fire. REV 73536i-20130221...
For periods of high electrical load or momentary falls below a critical threshold. fluctuations, the Economy Control Switch should be turned OFF. REV 73536i-20130221...
Prolonged exposure to engine exhaust can cause serious injury or death. WARNING While charging a device do no place on the exhaust side of the generator. Extreme heat caused by exhaust can damage the device, and cause a potential fire hazard. REV 73536i-20130221...
ENGLISH OPERATION Do Not Overload Generator Parallel Operation Two Champion model 73536i generators can be Capacity operated in parallel to increase the total available Follow these simple steps to calculate the running and electrical power to 3000 watts. A Champion model starting watts necessary for your purposes.
8. Use the spark plug tool to fi rmly install the plug. cover screws. 9. Attach the spark plug cap to the plug. 6. Dispose of used oil at an approved waste 10. Reinstall the spark plug access cap, and management facility. maintenance cover. REV 73536i-20130221...
Use a damp cloth to clean exterior surfaces of the engine. Use a soft bristle brush to remove dirt and oil. Failure to clean the spark arrester will result in Use an air compressor (25 PSI) to clear dirt and debris degraded engine performance. from the engine. REV 73536i-20130221...
Contact our help line at 1-877-338-0999 to locate the Use a damp cloth to clean exterior surfaces of the generator. nearest Champion Power Equipment certified service Use a soft bristle brush to remove dirt and oil. dealer for your generator or engine maintenance needs.
Page 19
– When storing the generator for short or extended periods of time make sure that the Engine Switch and the Fuel Valve are set in the OFF position. REV 73536i-20130221...
Review load and adjust. See “Power Management” Faulty cords or device Check for damaged, bare or frayed wires. Replace defective device For further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment.com REV 73536i-20130221...
Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc.
Page 28
The United States Environment Protection Agency (U.S. EPA.) and the California Air Resources Board (CARB) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of California Air Resources Board (CARB) emission regulations.
Page 29
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
Page 30
You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.